Biomechanics of smooth adhesive pads in insects: influence of tarsal secretion on attachment performance

Many insects possess smooth adhesive pads on their legs, which adhere by thin films of a two-phasic secretion. To understand the function of such fluid-based adhesive systems, we simultaneously measured adhesion, friction and contact area in single pads of stick insects (Carausius morosus). Shear stress was largely independent of normal force and increased with velocity, seemingly consistent with the viscosity-effect of a continuous fluid film. However, measurements of the remaining force 2 min after a sliding movement show that adhesive pads can sustain considerable static friction. Repeated sliding movements and multiple consecutive pull-offs to deplete adhesive secretion showed that on a smooth surface, friction and adhesion strongly increased with decreasing amount of fluid. In contrast, pull-off forces significantly decreased on a rough substrate. Thus, the secretion does not generally increase attachment but does so only on rough substrates, where it helps to maximize contact area. When slides were repeated at one position so that secretion could accumulate, sliding shear stress decreased but static friction remained clearly present. This suggests that static friction which is biologically important to prevent sliding is based on non-Newtonian properties of the adhesive emulsion rather than on a direct contact between the cuticle and the substrate.

[1]  M. Barquins,et al.  Rubber friction variation with rate and temperature: some new observations , 1986 .

[2]  S. Gorb,et al.  Ultrastructural architecture and mechanical properties of attachment pads in Tettigonia viridissima (Orthoptera Tettigoniidae) , 2000, Journal of Comparative Physiology A.

[3]  Beat Kleiner,et al.  Graphical Methods for Data Analysis , 1983 .

[4]  Stanislav N. Gorb,et al.  Ultrastructure of attachment specializations of hexapods (Arthropoda): evolutionary patterns inferred from a revised ordinal phylogeny , 2001 .

[5]  F. Brochard-Wyart,et al.  Dewetting at Soft Interfaces , 1998 .

[6]  B. Persson,et al.  Adhesion between an elastic body and a randomly rough hard surface , 2002, The European physical journal. E, Soft matter.

[7]  S. Gorb,et al.  Scale effects on the attachment pads and friction forces in syrphid flies (Diptera, Syrphidae). , 2001, The Journal of experimental biology.

[8]  Jim Hardie,et al.  THE ORGANS OF ADHESION IN THE APHID MEGOURA VICIAE , 1988 .

[9]  Nigel E. Stork,et al.  The adherence of beetle tarsal setae to glass , 1983 .

[10]  J. Israelachvili.  Intermolecular and surface forces , 1985 .

[11]  A. F. G. Dixon,et al.  The Mechanism by Which Aphids Adhere to Smooth Surfaces , 1990 .

[12]  G. Walker,et al.  The adhesive organ of the blowfly, Calliphora vomitoria: a functional approach (Diptera: Calliphoridae) , 1985 .

[13]  E. B. Page.  Ordered Hypotheses for Multiple Treatments: A Significance Test for Linear Ranks , 1963 .

[14]  R. Full,et al.  An Integrative Study of Insect Adhesion: Mechanics and Wet Adhesion of Pretarsal Pads in Ants1 , 2002, Integrative and comparative biology.

[15]  U. Schwarz,et al.  Chemical composition of the attachment pad secretion of the locust Locusta migratoria. , 2002, Insect biochemistry and molecular biology.

[16]  Stanislav Gorb,et al.  Biological microtribology: anisotropy in frictional forces of orthopteran attachment pads reflects the ultrastructure of a highly deformable material , 2000, Proceedings of the Royal Society of London. Series B: Biological Sciences.

[17]  Werner Baumgartner,et al.  Biomechanics of ant adhesive pads: frictional forces are rate- and temperature-dependent , 2004, Journal of Experimental Biology.

[18]  Matthias Scherge,et al.  Structural Design and Biomechanics of Friction-Based Releasable Attachment Devices in Insects1 , 2002, Integrative and comparative biology.

[19]  Y. Jiao,et al.  Adhesion measured on the attachment pads of Tettigonia viridissima (Orthoptera, insecta). , 2000, The Journal of experimental biology.

[20]  S. Gorb.  Attachment Devices of Insect Cuticle , 2001, Springer Netherlands.

[21]  C. Verdier,et al.  Peeling of polydimethylsiloxane adhesives at low velocities: Cohesive failure , 2005 .

[22]  H. Dewitz.  Ueber die Fortbewegung der Thiere an senkrechten, glatten Flächen vermittelst eines Secretes , 2005, Archiv für die gesamte Physiologie des Menschen und der Tiere.

[23]  David Tabor,et al.  The effect of surface roughness on the adhesion of elastic solids , 1975, Proceedings of the Royal Society of London. A. Mathematical and Physical Sciences.

[24]  G. Walker.  Adhesion to smooth surfaces by insects — a review , 1993 .

[25]  Shoziro Ishii,et al.  Adhesion of a Leaf Feeding Ladybird Epilachna vigintioctomaculta (Coleoptera : Coccinellidae) on a Virtically Smooth Surface , 1987 .

[26]  A. Volokitin,et al.  On the nature of surface roughness with application to contact mechanics, sealing, rubber friction and adhesion. , 2005, Journal of physics. Condensed matter : an Institute of Physics journal.

[27]  Thomas A. McMahon,et al.  Biomechanics of the movable pretarsal adhesive organ in ants and bees , 2001, Proceedings of the National Academy of Sciences of the United States of America.

[28]  T. Tadros.  Fundamental principles of emulsion rheology and their applications , 1994 .

[29]  Howard A. Barnes,et al.  Rheology of emulsions — a review , 1994 .

[30]  Oliver Betz,et al.  Performance and adaptive value of tarsal morphology in rove beetles of the genus Stenus (Coleoptera, Staphylinidae). , 2002, The Journal of experimental biology.

[31]  Barnes W.J.P.,et al.  BIONICS AND WET GRIP , 2004 .

[32]  T. Endlein,et al.  Locomotion and adhesion: dynamic control of adhesive surface contact in ants. , 2004, Arthropod structure & development.

[33]  Bharat Bhushan,et al.  Adhesion and stiction: Mechanisms, measurement techniques, and methods for reduction , 2003 .

[34]  F. P. Bowden,et al.  The Friction and Lubrication of Solids , 1964 .

[35]  B. Francis,et al.  Apparatus-specific analysis of fluid adhesion measurements , 2001 .

[36]  Stanislav Gorb,et al.  Adhesion forces measured at the level of a terminal plate of the fly's seta , 2004, Proceedings of the Royal Society of London. Series B: Biological Sciences.

[37]  F. Brochard-Wyart,et al.  Dewetting Nucleation Centers at Soft Interfaces , 2001 .

[38]  P. Gennes,et al.  Dewetting of a water film between a solid and a rubber , 1994 .

[39]  Nigel E. Stork,et al.  A comparison of the adhesive setae on the feet of lizards and arthropods , 1983 .

[40]  Patricia McGuiggan,et al.  Fundamental experimental studies in tribology : the transition from interfacial friction of undamaged molecularly smooth surfaces to normal friction with wear , 1990 .

[41]  Stanislav Gorb,et al.  Contact behaviour of tenent setae in attachment pads of the blowfly Calliphora vicina (Diptera, Calliphoridae) , 2001, Journal of Comparative Physiology A.

[42]  Nigel E. Stork,et al.  Experimental Analysis of Adhesion of Chrysolina Polita (Chrysomelidae: Coleoptera) on a Variety of Surfaces , 1980 .

[43]  A. Roberts.  The shear of thin liquid films , 1971 .

[44]  David Tabor,et al.  Adhesion of solids and the effect of surface films , 1950, Proceedings of the Royal Society of London. Series A. Mathematical and Physical Sciences.

[45]  Stanislav N Gorb,et al.  Ontogenesis of the attachment ability in the bug Coreus marginatus (Heteroptera, Insecta) , 2004, Journal of Experimental Biology.