Numerical and experimental investigations of pressure fluctuations in single-channel pumps

To elucidate the characteristics and generation mechanism of pressure fluctuations in single-channel pumps, the unsteady flow in three single-channel pumps with the same impeller equipped with a spiral volute (model 1), a circular volute (model 2), and a torus (model 3) were analyzed by computational fluid dynamics. Experiments on global performance characteristics in the volute of model 1 were performed, and fast response pressure sensors were installed in the spiral volute to measure pressure fluctuations. The results indicate that the numerical results are in good agreement with the experimental results. This study shows that a phase delay exists between different volute monitoring points and the pressure fluctuations in the volute are mainly caused by the potential interactions between the impeller blade and volute wall. Comparison of the pressure fluctuations amplitude of the impeller outlet shows that pressure fluctuation amplitude of model 3 is one order of magnitude lower than those of the others and the wake at the impeller outlet played an important role in pressure fluctuations. The standard deviation of pressure was introduced to describe the pressure fluctuations strength. It shows that the pressure fluctuation strength of the pressure surface is apparently higher than that of the suction surface, and the maximum pressure fluctuation strength in the blade is consistent with the flow separation area, indicating that flow separation is also an important factor for pressure fluctuations in single-channel pumps.

[1]  Chuan Wang,et al.  Optimal design of multistage centrifugal pump based on the combined energy loss model and computational fluid dynamics , 2017 .

[2]  Jianping Yuan,et al.  Numerical prediction of 3-D periodic flow unsteadiness in a centrifugal pump under part-load condition , 2014 .

[3]  Sun-Sheng Yang,et al.  Influence of Blade Number on the Performance and Pressure Pulsations in a Pump Used as a Turbine , 2012 .

[4]  Ji Pei,et al.  Numerical Prediction of Unsteady Pressure Field Within the Whole Flow Passage of a Radial Single-Blade Pump , 2012 .

[5]  Zhifeng Yao,et al.  Experimental Investigation of Time-Frequency Characteristics of Pressure Fluctuations in a Double-Suction Centrifugal Pump , 2011 .

[6]  Giovanna Cavazzini,et al.  Time–frequency characterization of the unsteady phenomena in a centrifugal pump , 2008 .

[7]  Ilmar F. Santos,et al.  Frequencies in the Vibration Induced by the Rotor Stator Interaction in a Centrifugal Pump Turbine , 2007 .

[8]  Jorge Parrondo,et al.  Steady and unsteady radial forces for a centrifugal pump with impeller to tongue gap variation , 2006 .

[9]  Joaquin Fernandez-Francos,et al.  The Effect of the Operating Point on the Pressure Fluctuations at the Blade Passage Frequency in the Volute of a Centrifugal Pump , 2002 .

[10]  Hiroshi Tsukamoto,et al.  Fundamental Analysis on Rotor-Stator Interaction in a Diffuser Pump by Vortex Method , 2001 .

[11]  Hiroshi Tsukamoto,et al.  Numerical Study of Pressure Fluctuations Caused by Impeller-Diffuser Interaction in a Diffuser Pump Stage , 2001 .

[12]  N. P. Kruyt,et al.  Experimental and theoretical study of the flow in the volute of a low specific-speed pump , 2001 .

[13]  Joseph Katz,et al.  Effect of Modification to Tongue and Impeller Geometry on Unsteady Flow, Pressure Fluctuations and Noise in a Centrifugal Pump , 1995 .

[14]  J. H. Wagner,et al.  Turbine Rotor-Stator Interaction , 1982 .

[15]  Huang Xianbe,et al.  Analysis of Low-frequency Pressure Pulsations in Vaneless Centrifugal Pump Volute , 2014 .

[16]  Xi Zeng.  Mechanical Characteristic Analysis of Softness Consolidation Abrasives Pneumatic Wheel , 2014 .

[17]  Hans Josef Dohmen,et al.  Periodically Unsteady Flow in a Single-Blade Centrifugal Pump: Numerical and Experimental Results , 2005 .

[18]  Hans Josef Dohmen,et al.  Calculation of Hydrodynamic Forces and Flow Induced Vibrations of Centrifugal Sewage Water Pumps , 2003 .

[19]  A. Inokuty,et al.  ON CENTRIFUGAL PUMPS , 1913 .