The angle of repose of bulk corn stover particles

Abstract Lignocellulosic biomass feedstock such as corn stover, the residues left on the field after corn grain harvest, has been studied as one of the renewable feedstocks to be used for fuel ethanol conversion in the near future. The primary objective of this work was to determine the angle of repose (AoR) of bulk corn stover particles prepared to four particle sizes (chopped and particles screened through 6.4, 3.2 and 1.6 mm) at two moisture contents (dry,  20%). The results show that particles size and feedstock moisture content were important variables that affected the angle of repose for all three angle of repose methods (piling AoR loose-base, piling AoR fixed-base and sliding AoR) investigated. In general, increasing moisture content and particle size increased the piling AoR (loose-base), piling AoR (fixed-base) and sliding angle of repose. Characterization of the flow behavior of bulk corn stover particles using the piling AoR (loose-base) and comparison with three granular bulk solids of biological origin (corn, soybean and distillers dried grains with solubles, DDGS) indicated that dry and wet stover particles of the particle size ranges tested in this study have a poor flow behavior.

[1]  Teodoro Espinosa-Solares,et al.  Macroscopic mass and energy balance of a pilot plant anaerobic bioreactor operated under thermophilic conditions , 2006, Applied biochemistry and biotechnology.

[2]  J. C. Olsen,et al.  THE AMERICAN INSTITUTE OF CHEMICAL ENGINEERS. , 1912, Science.

[3]  Jysoo Lee.  Avalanches in (1 + 1)-dimensional piles: a molecular dynamics study , 1993 .

[4]  V. Frette,et al.  Avalanche dynamics in a pile of rice , 1996, Nature.

[5]  Ugur Tüzün,et al.  Stratification in poured granular heaps , 1998, Nature.

[6]  Kurt A. Rosentrater,et al.  SOME PHYSICAL PROPERTIES OF DISTILLERS DRIED GRAINS WITH SOLUBLES (DDGS) , 2006 .

[7]  C. Wyman,et al.  Features of promising technologies for pretreatment of lignocellulosic biomass. , 2005, Bioresource technology.

[8]  Volkhard Buchholtz,et al.  Numerical investigations of the evolution of sandpiles , 1994 .

[9]  G. H. Brusewitz,et al.  TECHNICAL NOTES: ANGLES OF REPOSE OF GROUND MARIGOLD PETALS AS A FUNCTION OF PARTICLE SIZE, MOISTURE CONTENT, AND FLOW ENHANCER , 1999 .

[10]  David Train,et al.  SOME ASPECTS OF THE PROPERTY OF ANGLE OF REPOSE OF POWDERS , 1958, The Journal of pharmacy and pharmacology.

[11]  R L Carr,et al.  EVALUATING FLOW PROPERTIES OF SOLIDS , 1965 .

[12]  Paul Zulli,et al.  An experimental and numerical study of the angle of repose of coarse spheres , 2002 .

[13]  J. W. Carson,et al.  Six steps to designing a storage vessel that really works , 1999 .

[14]  G. G. Stokes.  "J." , 1890, The New Yale Book of Quotations.

[15]  Robert D. Perlack,et al.  Feedstock cost analysis of corn stover residues for further processing , 2003 .

[16]  R. Jullien,et al.  Particle Size Segregation by Shaking in Two-Dimensional Disc Packings , 1993 .