Pitfalls when correlating TLP, HBM and MM testing

Correlation between human body model (HBM), machine model (MM) and transmission line pulse (TLP) testing is still under discussion. In this paper, it is shown that the lack of correlation is due to misinterpretations in the test results, due to the fact that soft and hard failures are often confused. This is illustrated by ESD results of test structures with grounded-gate NMOSTs and field oxide devices, measured according to HBM, MM and by means of TLP testing. It is shown that for a valid comparison, it is essential to combine electrical measurements with a thorough physical failure analysis in order to establish the failure signature. Once the failure signature and the current path are taken into account, a good correlation is found.

[1]  G. Reimbold,et al.  An attempt to explain thermally induced soft failures during low level ESD stresses: study of the differences between soft and hard NMOS failures , 1998 .

[2]  X. Guggenmos,et al.  Risetime effects of HBM and square pulses on the failure thresholds of GGNMOS transistors , 1996 .

[3]  A. Amerasekera,et al.  ESD failure modes: characteristics mechanisms, and process influences , 1992 .

[4]  J. Bruines,et al.  Suppression and origin of soft ESD failures in a submicron CMOS process , 1994 .

[5]  C. Musshoff,et al.  Does The Esd-failure Current Obtained By Transmissionline Pulsing Always Correlate To Human Body Model Tests? , 1997 .

[6]  G. Reimbold,et al.  An attempt to explain thermally induced soft failures during low level ESD stresses: study of the differences between soft and hard NMOS failures. , 1997, Proceedings Electrical Overstress/Electrostatic Discharge Symposium.

[7]  Horst Gieser,et al.  RISETIME EFFECTS OF HBM AND SQUARE PULSES TRANSISTORS ON THE FAILURE THRESHOLDS OF GGNMOS , 1996 .

[8]  M. Kelly,et al.  A comparison of electrostatic discharge models and failure signatures for CMOS integrated circuit devices , 1995, Electrical Overstress/Electrostatic Discharge Symposium Proceedings.

[9]  Guido Groeseneken,et al.  NMOS transistor behaviour under CDM stress conditions and relation to other ESD models , 1995 .

[10]  X. Guggenmos,et al.  Does The Esd-failure Current Obtained By Transmissionline Pulsing Always Correlate To Human Body Model Tests? , 1997, Proceedings Electrical Overstress/Electrostatic Discharge Symposium.

[11]  P. Mortini,et al.  Influence of parasitic structures on the ESD performance of a pure bipolar process , 1996 .