Nafion/organically modified silicate hybrids membrane for vanadium redox flow battery

In our previous work, Nafion/SiO(2) hybrid membrane was prepared via in situ sol-gel method and used for the vanadium redox flow battery (VRB) system. The VRB with modified Nafion membrane has shown great advantages over that of the VRB with Nafion membrane. In this work, a novel Nafion/organically modified silicate (ORMOSIL) hybrids membrane was prepared via in situ sol-gel reactions for mixtures of tetraethoxysilane (TEOS) and diethoxydimethylsilane (DEDMS). The primary properties of Nafion/ORMOSIL hybrids membrane were measured and compared with Nafion and Nafion/SiO(2) hybrid membrane. The permeability of vanadium ions through the Nafion/ORMOSIL hybrids membrane was measured using an UV-vis spectrophotometer. The results indicate that the hybrids membrane has a dramatic reduction in crossover of vanadium ions compared with Nafion membrane. Fourier transform infrared spectra (FT-IR) analysis of the hybrids membrane reveals that the ORMOSIL phase is well formed within hybrids membrane. Cell tests identify that the VRB with Nafion/ORMOSIL hybrids membrane presents a higher coulombic efficiency (CE) and energy efficiency (EE) compared with that of the VRB with Nafion and Nafion/SiO(2) hybrid membrane. The highest EE of the VRB with Nafion/ORMOSIL hybrids membrane is 87.4% at 20mA cm(-2). while the EE of VRB with Nafion and the EE of VRB with Nafion/SiO(2) hybrid membrane are only 73.8% and 79.9% at the same current density. The CE and EE of VRB with Nafion/ORMOSIL hybrids membrane is nearly no decay after cycling more than 100 times (60mA cm(-2)), which proves the Nafion/ORMOSIL hybrids membrane possesses high chemical stability during long charge-discharge process under strong acid solutions. The self-discharge rate of the VRB with Nafion/ORMOSIL hybrids membrane is the slowest among the VRB with Nafion, Nafion/SiO(2) and Nafion/ORMOSIL membrane,which further proves the excellent vanadium ions blocking characteristic of the prepared hybrids membrane. (c) 2008 Elsevier B.V. All rights reserved.

[1]  Ch. Fabjan,et al.  Possible use of vanadium redox-flow batteries for energy storage in small grids and stand-alone photovoltaic systems , 2004 .

[2]  Maria Skyllas-Kazacos,et al.  A study of the V(II)/V(III) redox couple for redox flow cell applications , 1985 .

[3]  Maria Skyllas-Kazacos,et al.  Modification of membranes using polyelectrolytes to improve water transfer properties in the vanadium redox battery , 2003 .

[4]  Robert B. Moore,et al.  Novel Nafion/ORMOSIL Hybrids via in Situ Sol-Gel Reactions. 1. Probe of ORMOSIL Phase Nanostructures by Infrared Spectroscopy , 1995 .

[5]  Ch. Fabjan,et al.  The vanadium redox-battery: an efficient storage unit for photovoltaic systems , 2001 .

[6]  R. Savinell,et al.  Evaluation of a Sol-Gel Derived Nafion/Silica Hybrid Membrane for Proton Electrolyte Membrane Fuel Cell Applications: I. Proton Conductivity and Water Content , 2001 .

[7]  Silvia Licoccia,et al.  Nafion–TiO2 hybrid membranes for medium temperature polymer electrolyte fuel cells (PEFCs) , 2005 .

[8]  Maria Skyllas-Kazacos,et al.  Characteristics and performance of 1 kW UNSW vanadium redox battery , 1991 .

[9]  H. Ohya,et al.  Crosslinking of anion exchange membrane by accelerated electron radiation as a separator for the all-vanadium redox flow battery , 1997 .

[10]  Microstructural Evolution of a Silicon Oxide Phase in a Perfluorosulfonic Acid Ionomer by an In Situ Sol-Gel Reaction .2. Dielectric Relaxation Studies , 1990 .

[11]  Robert B. Moore,et al.  Novel Nafion®/ORMOSIL hybrids via in situ sol-gel reactions: 2. Probe of ORMOSIL phase nanostructure by 29Si solid state NMR spectroscopy , 1996 .

[12]  Xinping Qiu,et al.  Influences of permeation of vanadium ions through PVDF-g-PSSA membranes on performances of vanadium redox flow batteries. , 2005, The journal of physical chemistry. B.

[13]  D. Collins,et al.  Power Sources 3 , 1971 .

[14]  Toraj Mohammadi,et al.  Preparation of sulfonated composite membrane for vanadium redox flow battery applications , 1995 .

[15]  Jian Chen,et al.  Modification of Nafion membrane using interfacial polymerization for vanadium redox flow battery applications , 2008 .

[16]  Xinping Qiu,et al.  Self-assembled polyelectrolyte multilayer modified Nafion membrane with suppressed vanadium ion crossover for vanadium redox flow batteries , 2008 .

[17]  L. Klein,et al.  Transport properties of Nafion™ composite membranes for proton-exchange membranes fuel cells , 2003 .

[18]  B. Tian,et al.  Proton conducting composite membrane from Daramic/Nafion for vanadium redox flow battery , 2004 .

[19]  Jinwei Chen,et al.  Studies on polypyrrole modified nafion membrane for vanadium redox flow battery , 2008 .

[20]  R. Savinell,et al.  Evaluation of a Sol-Gel Derived Nafion/Silica Hybrid Membrane for Polymer Electrolyte Membrane Fuel Cell Applications: II. Methanol Uptake and Methanol Permeability , 2001 .

[21]  Maria Skyllas-Kazacos,et al.  Evaluation of membranes for the novel vanadium bromine redox flow cell , 2006 .

[22]  A. Dicks,et al.  Nafion/polyaniline/silica composite membranes for direct methanol fuel cell application , 2007 .

[23]  Maria Skyllas-Kazacos,et al.  Investigation of the V(V)/V(IV) system for use in the positive half-cell of a redox battery , 1985 .

[24]  R. Lichtenthaler,et al.  Sorption isotherms of vanadium with H3O+ ions in cation exchange membranes , 1998 .

[25]  Xinping Qiu,et al.  Nafion/SiO2 hybrid membrane for vanadium redox flow battery , 2007 .

[26]  C. Ponce de León,et al.  Redox flow cells for energy conversion , 2006 .

[27]  K. Mauritz,et al.  Nafion®/ORMOSIL nanocomposites via polymer-in situ sol–gel reactions. 1. Probe of ORMOSIL phase nanostructures by 29Si solid-state NMR spectroscopy , 2002 .

[28]  C. Rydh.  Environmental assessment of vanadium redox and lead-acid batteries for stationary energy storage , 1999 .

[29]  Anthony G. Fane,et al.  New All‐Vanadium Redox Flow Cell , 1986 .

[30]  K. Mauritz,et al.  Nafion®/(SiO2, ORMOSIL, and dimethylsiloxane) hybrids via in situ sol-gel reactions : Characterization of fundamental properties , 1998 .

[31]  Jing Peng,et al.  Pre-irradiation grafting of styrene and maleic anhydride onto PVDF membrane and subsequent sulfonation for application in vanadium redox batteries , 2008 .

[32]  Toraj Mohammadi,et al.  Evaluation of the chemical stability of some membranes in vanadium solution , 1997 .

[33]  K. Mauritz,et al.  Microstructural evolution of a silicon oxide phase in a perfluorosulfonic acid ionomer by an in situ sol-gel reaction. 1. Infrared spectroscopic studies , 1989 .

[34]  Yasushi Katayama,et al.  Investigations on V(IV)/V(V) and V(II)/V(III) redox reactions by various electrochemical methods , 2005 .