SE—Structures and Environment

Abstract Releases of ammonia (NH 3 ), hydrogen sulphide (H 2 S) and carbon dioxide (CO 2 ) from deep manure pits were investigated in two overnight tests to minimize the influence of solar radiation and sudden outdoor temperature changes using two pig fattening buildings. The rooms of the buildings had been emptied and cleaned between groups of pigs. The identical buildings had tunnel and pit ventilation fans and 2·4 m deep under-floor pits with a surface area of 800 m 2 each. The first test was conducted in Building 3A. A new manure additive was applied in the pit to reduce gas and odour emission. The pit ventilation mode was used and the building was heated for about 1 h with one direct-fired propane space heater. The second test was conducted in Building 3B, in which the pit did not receive the additive application. The tunnel ventilation mode was used and the building was heated for about 2 h with two space heaters. Gas concentrations, ventilation, temperatures and differential pressure were continuously measured overnight. Gas release rates in the tests were compared with the gas release rates in the same buildings when they were fully occupied. Ammonia release rates during heating were 167±11 g/h (mean±95% confidence interval) in the first test and 46±2 g/h in the second test, equivalent to 65·5 and 24·9% of the rates from fully occupied buildings, respectively. The maximum H 2 S release rates measured after 1 h of heating were 9·6 g/h in the first test and 3·1 g/h in the second test, equivalent to 80 and 41% of the full buildings, respectively. The maximum CO 2 release rates after heating were 3·4 kg/h in the first test and 7·0 kg/h in the second test. Heating immediately increased NH 2 , H 2 S and CO 2 concentrations and release rates in the under-floor pits in both tests. Ventilation modes and rates affected the indoor gas concentrations at different locations. Higher ventilation rate was related to higher gas release rate in the first test. A peculiar behaviour of H 2 S characterized by burst releases was found in the two tests. It was a new phenomenon not yet reported in the literature and might be related to some unexpected incidents involving acute H 2 S concentrations in animal facilities.

[1]  E. Buijsman,et al.  Anthropogenic NH3 emissions in europe , 1987 .

[2]  N. K. Patni,et al.  TRANSIENT HAZARDOUS CONDITIONS IN ANIMAL BUILDINGS DUE TO MANURE GAS RELEASED DURING SLURRY MIXING , 1991 .

[3]  Ji-Qin Ni,et al.  Mechanistic Models of Ammonia Release from Liquid Manure: a Review , 1999 .

[4]  A.J.A. Aarnink,et al.  Effect of Slatted Floor Area on Ammonia Emission and on the Excretory and Lying Behaviour of Growing Pigs , 1996 .

[5]  J. Hartung,et al.  A comparison of three balance methods for calculating ventilation rates in livestock buildings , 1998 .

[6]  J. Ni.  Emission of carbon dioxide and ammonia from mechanically ventilated pig house , 1998 .

[7]  J. B. Gerrish,et al.  Hydrogen sulfide production in swine confinement units , 1975 .

[8]  Ji-Qin Ni,et al.  Production of carbon dioxide in a fattening pig house under field conditions. II. Release from the manure , 1999 .

[9]  B. Crook,et al.  Airborne dust, ammonia, microorganisms, and antigens in pig confinement houses and the respiratory health of exposed farm workers. , 1991, American Industrial Hygiene Association journal.

[10]  C. E. Van't Klooster,et al.  Determination of Minimum Ventilation Rate in Pig Houses with Natural Ventilation based on Carbon Dioxide Balance , 1994 .

[11]  H. W. Norton,et al.  Effects of Aerial Ammonia on Growth and Health of Young Pigs , 1980 .

[12]  J. J. R. Feddes,et al.  Feed Consumption as a Parameter for Establishing Minimum Ventilation Rates , 1991 .

[13]  K. Donham,et al.  Acute toxic exposure to gases from liquid manure. , 1982, Journal of occupational medicine. : official publication of the Industrial Medical Association.

[14]  Albert J. Heber,et al.  HYDROGEN SULFIDE EMISSIONS FROM A MECHANICALLY-VENTILATED SWINE BUILDING DURING WARM WEATHER , 1998 .

[15]  J. Oosthoek,et al.  Reduction of ammonia volatilization from pig houses using aerated slurry as recirculation liquid , 1992 .

[16]  V. R. Phillips,et al.  Control of Gaseous Emissions from Livestock Buildings and Manure Stores , 1994 .

[17]  P. A. Burrough,et al.  Soil acidification from atmospheric ammonium sulphate in forest canopy throughfall , 1982, Nature.

[18]  F. N. Reece,et al.  Ammonia in the Atmosphere during Brooding Affects Performance of Broiler Chickens , 1980 .

[19]  Ji-Qin Ni,et al.  Effect of manure on ammonia emission from a fattening pig house with partly slatted floor , 1999 .

[20]  B. F. Pain,et al.  Loss of nitrogen through ammonia volatilisation during and following the application of pig or cattle slurry to grassland , 1989 .

[21]  Ji-Qin Ni,et al.  Production of carbon dioxide in a fattening pig house under field conditions. I. Exhalation by pigs , 1999 .

[22]  Arthur J. Muehling,et al.  Gases and Odors from Stored Swine Wastes , 1970 .