Review of On-Chip Inductor Structures With Magnetic Films

A comparison of on-chip inductors with magnetic materials from previous studies is presented and examined. Results from on-chip inductors with magnetic material integrated into a 90 nm CMOS processes are presented. The inductors use copper metallization and amorphous Co-Zr-Ta magnetic material. Inductance densities of up to 1700 nH/mm2 were obtained thanks to inductance increases of up to 31 times, significantly greater than previously published on-chip inductors. With such improvements, the effects of eddy currents, skin effect, and proximity effect become clearly visible at higher frequencies. Co-Zr-Ta was chosen for its good combination of high permeability, good stability at high temperature (> 250degC), high saturation magnetization, low magnetostriction, high resistivity, minimal hysteretic loss, and compatibility with silicon technology. The Co-Zr-Ta alloy can operate at frequencies up to 9.8 GHz, but trade-offs exist between frequency, inductance, and quality factor. Our inductors with thick copper and thicker magnetic films have dc resistances as low as 0.04 Omega, and quality factors of up to 8 at frequencies as low as 40 MHz.

[1]  N. Saleh,et al.  Permalloy thin-film inductors , 1970 .

[2]  R. Meyer,et al.  Si IC-compatible inductors and LC passive filters , 1990 .

[3]  M. Yamaguchi,et al.  Analysis of the inductance and the stray capacitance of the dry-etched micro inductors , 1991 .

[4]  M. Mino,et al.  A new planar microtransformer for use in macro-switching-converters , 1991, PESC '91 Record 22nd Annual IEEE Power Electronics Specialists Conference.

[5]  M. Yamaguchi,et al.  Application of YIG film to thin film inductors , 1991 .

[6]  Masahiro Yamaguchi,et al.  Characteristics and analysis of a thin film inductor with closed magnetic circuit structure , 1992, 1992. Digests of Intermag. International Magnetics Conference.

[7]  K. Arai,et al.  Estimation of the in-situ permeabilities in thin-film inductors , 1993 .

[8]  Mark G. Allen,et al.  A fully integrated planar toroidal inductor with a micromachined nickel-iron magnetic bar , 1994 .

[9]  M. Allen,et al.  A new toroidal-meander type integrated inductor with a multilevel meander magnetic core , 1994 .

[10]  Ki-Hong Kim.  Characteristics of an integrated spiral inductor with an underlying n-well , 1997 .

[11]  Masahiro Yamaguchi,et al.  MICROFABRICATION AND CHARACTERISTICS OF MAGNETIC THIN-FILM INDUCTORS IN THE ULTRAHIGH FREQUENCY REGION , 1999 .

[12]  Characteristics of twin spiral type thin film inductor with Fe-based nanocrystalline core , 1999, IEEE International Magnetics Conference.

[13]  Chong H. Ahn,et al.  3-D microfabricated toroidal planar inductors with different magnetic core schemes for MEMS and power electronic applications , 1999 .

[14]  Stephen P. Boyd,et al.  Simple accurate expressions for planar spiral inductances , 1999, IEEE J. Solid State Circuits.

[15]  Masahiro Yamaguchi,et al.  Magnetic thin-film inductors for RF-integrated circuits , 2000 .

[16]  Jae-Sung Song,et al.  Characteristics of film type inductors using a FeZrBAg magnetic material , 2001 .

[17]  K. Arai,et al.  Sandwich type ferromagnetic RF integrated inductor , 2001, 2001 IEEE MTT-S International Microwave Sympsoium Digest (Cat. No.01CH37157).

[18]  Shan X. Wang,et al.  High frequency (GHz) and low resistance integrated inductors using magnetic materials , 2001, Proceedings of the IEEE 2001 International Interconnect Technology Conference (Cat. No.01EX461).

[19]  Yvan Avenas,et al.  Micro fabricated power inductors on silicon , 2002, 2002 IEEE 33rd Annual IEEE Power Electronics Specialists Conference. Proceedings (Cat. No.02CH37289).

[20]  Shan X. Wang,et al.  High-frequency microinductors with amorphous magnetic ground planes , 2002 .

[21]  Masahiro Yamaguchi,et al.  Equivalent circuit analysis of an RF integrated ferromagnetic inductor , 2002 .

[22]  Tetsuo Inoue,et al.  Planar inductor with ferrite layers for DC-DC converter , 2003 .

[23]  E. Brandon,et al.  Fabrication and characterization of microinductors for distributed power converters , 2003 .

[24]  K. Venkatachalam,et al.  Measured electrical performance of V-groove inductors for microprocessor power delivery , 2003, Digest of INTERMAG 2003. International Magnetics Conference (Cat. No.03CH37401).

[25]  T. O'Donnell,et al.  Microfabricated coupled inductors for DC-DC converters for microprocessor power delivery , 2004, 2004 IEEE 35th Annual Power Electronics Specialists Conference (IEEE Cat. No.04CH37551).

[26]  C. Patrick Yue,et al.  Tunable on-chip inductors up to 5 GHz using patterned permalloy laminations , 2005, IEEE InternationalElectron Devices Meeting, 2005. IEDM Technical Digest..

[27]  Y. Miura,et al.  A planar inductor using Mn-Zn ferrite/polyimide composite thick film for low-Voltage and large-current DC-DC converter , 2005, IEEE Transactions on Magnetics.

[28]  M. Tewes,et al.  Integration of crossed anisotropy magnetic core into toroidal thin-film inductors , 2005, IEEE Transactions on Microwave Theory and Techniques.

[29]  D. Flynn,et al.  Fabrication process of a micro-inductor utilising a magnetic thin film core , 2005 .

[30]  S. Couderc,et al.  Bidirectional ferromagnetic spiral inductors using single deposition , 2005, IEEE Transactions on Magnetics.

[31]  Yongsoo Oh,et al.  Planar inductor with ferrite layers for DC-DC converter , 2005, The 13th International Conference on Solid-State Sensors, Actuators and Microsystems, 2005. Digest of Technical Papers. TRANSDUCERS '05..

[32]  R. Hida,et al.  Low-Resistance Integrated Toroidal Inductor for Power Management , 2006, IEEE transactions on magnetics.

[33]  Joachim N. Burghartz,et al.  Shape-induced ultrahigh magnetic anisotropy and ferromagnetic resonance frequency of micropatterned thin Permalloy films , 2006 .

[34]  P. Ancey,et al.  Low Resistance Integrated Toroidal Inductors for Power Management , 2006, INTERMAG 2006 - IEEE International Magnetics Conference.

[35]  G. Schrom,et al.  Integrated On-Chip Inductors With Magnetic Films , 2006, IEEE Transactions on Magnetics.

[36]  Yong Zhou,et al.  Fabrication of a solenoid-type inductor with Fe-based soft magnetic core , 2007 .

[37]  D. O'Sullivan,et al.  Microfabricated inductors for 20 MHz Dc-Dc converters , 2008, 2008 Twenty-Third Annual IEEE Applied Power Electronics Conference and Exposition.

[38]  Dok Won Lee,et al.  Fabrication and Analysis of High-Performance Integrated Solenoid Inductor With Magnetic Core , 2008, IEEE Transactions on Magnetics.

[39]  Peter Hazucha,et al.  Integrated on-chip inductors using magnetic material (invited) , 2008 .