Electrochemistry and in situ Raman spectroelectrochemistry of low and high quality boron doped diamond layers in aqueous electrolyte solution

Abstract In this work we report on electrochemical and in situ Raman spectroelectrochemical characterization of low quality (LQ) ultrathin nanocrystalline and high quality (HQ) polycrystalline boron doped diamond (BDD) compared especially in terms of the sp 2 carbon content. The BDD films were grown by microwave plasma enhanced chemical vapor deposition and doped with various boron concentrations from 250 to 8000 ppm (boron/carbon ratio in the gas phase) at different conditions. The quality (presence of graphitic or amorphous phases) and boron doping levels in the BDD films were analyzed by micro-Raman spectroscopy. From the neutron depth profiling, it was found that the boron content in the near surface region ( 19  cm −3 to 58 × 10 20  cm −3 for B/C from 250 ppm to 8000 ppm, respectively. The electrochemical measurements have been performed in aqueous 0.5 M H 2 SO 4 in the potential range from −2 to 2.5 V vs. Hg/Hg 2 SO 4 . Cyclic voltammetry showed that the electrochemical potential window was independent on the boron doping but depended on the film quality, i.e. when the sp 2 carbon content increased the width of potential window decreased. The in situ Raman spectroelectrochemistry was performed in aqueous electrolyte solution (0.5 M H 2 SO 4 ) in the potential range from −1.5 to 1.5 V vs. Hg/Hg 2 SO 4 using two laser excitations (633 nm and 457 nm). In the case of films containing high amount of sp 2 carbonaceous phase (low quality), the modes belonging to sp 2 carbonaceous phases changed their intensities. The intensity of the D, G and D′ Raman peaks increased in cathodic direction, while in anodic direction bleaching of these peaks was observed. The diamond films prepared with very small amount of sp 2 carbon (high quality) exhibited no spectroelectrochemical changes in the potential region tested.

[1]  Christoph E. Nebel,et al.  Surface electronic properties of H‐terminated diamond in contact with adsorbates and electrolytes , 2006 .

[2]  D. Riley,et al.  The influence of doping levels and surface termination on the electrochemistry of polycrystalline diamond , 2004 .

[3]  L. Kavan,et al.  The influence of strong electron and hole doping on the Raman intensity of chemical vapor-deposition graphene. , 2010, ACS nano.

[4]  John Robertson,et al.  In situ Raman spectro-electrochemistry study of single-wall carbon nanotube mat , 2004 .

[5]  J. Foord,et al.  Studies of the chemical functionalisation of diamond electrodes , 2007 .

[6]  L. Kavan,et al.  Electrochemical doping of double-walled carbon nanotubes: an in situ Raman spectroelectrochemical study. , 2004, Chemphyschem : a European journal of chemical physics and physical chemistry.

[7]  L. Kavan.  Nanomaterials based on carbon and Ti(IV) oxides: some aspects of their electrochemistry , 2012 .

[8]  L. Kavan,et al.  In situ Vis–NIR and Raman spectroelectrochemistry at fullerene peapods , 2002 .

[9]  R. Kalish,et al.  Electrochemical behavior of boron-doped diamond electrodes , 1996 .

[10]  A. T. Collins,et al.  Impurity conduction in synthetic semiconducting diamond , 1970 .

[11]  Y. Einaga,et al.  Giant electric double-layer capacitance of heavily boron-doped diamond electrode , 2010 .

[12]  J. Butler,et al.  The structural and electrochemical properties of boron-doped nanocrystalline diamond thin-film electrodes grown from Ar-rich and H2-rich source gases , 2009 .

[13]  L. Kavan,et al.  Raman spectroscopy and in situ Raman spectroelectrochemistry of bilayer ¹²C/¹³C graphene. , 2011, Nano letters.

[14]  R. Boukherroub,et al.  Influence of the surface termination on the electrochemical properties of boron-doped diamond (BDD) interfaces , 2008 .

[15]  L. Kavan,et al.  Spectroelectrochemistry of carbon nanostructures. , 2007, Chemphyschem : a European journal of chemical physics and physical chemistry.

[16]  N. G. Ferreira,et al.  Nanodiamond Films for Applications in Electrochemical Systems , 2012 .

[17]  L. Kavan,et al.  Ionic liquid for in situ Vis/NIR and Raman spectroelectrochemistry: Doping of carbon nanostructures. , 2003, Chemphyschem : a European journal of chemical physics and physical chemistry.

[18]  Katherine B. Holt,et al.  Scanning Electrochemical Microscopy Studies of Redox Processes at Undoped Nanodiamond Surfaces , 2009 .

[19]  P. Hubík,et al.  Superconductive B-doped nanocrystalline diamond thin films: Electrical transport and Raman spectra , 2006 .

[20]  B. Liu,et al.  Effect of electronic structures on electrochemical behaviors of surface-terminated boron-doped diamond film electrodes , 2007 .

[21]  Gaetano Granozzi,et al.  Evolution of Electrical, Chemical, and Structural Properties of Transparent and Conducting Chemically Derived Graphene Thin Films , 2009 .

[22]  Greg M. Swain,et al.  The electrochemical activity of boron-doped polycrystalline diamond thin film electrodes , 1993 .

[23]  J. Luong,et al.  Boron-doped diamond electrode: synthesis, characterization, functionalization and analytical applications. , 2009, The Analyst.

[24]  M. Kalbáč,et al.  In‐Situ Vis–Near‐Infrared and Raman Spectroelectrochemistry of Double‐Walled Carbon Nanotubes , 2005 .

[25]  F. Tuinstra,et al.  Raman Spectrum of Graphite , 1970 .

[26]  H. B. Martin,et al.  Voltammetry Studies of Single‐Crystal and Polycrystalline Diamond Electrodes , 1999 .

[27]  D. Fink,et al.  Deconvolution of charged particle spectra from neutron depth profiling using Simplex method. , 2010, The Review of scientific instruments.

[28]  A. Fujishima,et al.  A study of the crystalline growth of highly boron-doped CVD diamond: preparation of graded-morphology diamond thin films , 2001 .

[29]  S. T. Lee,et al.  Characterization of heavily boron-doped diamond films , 1996 .

[30]  S. Sampath,et al.  Electrochemical Reduction of Oriented Graphene Oxide Films: An in Situ Raman Spectroelectrochemical Study , 2009 .

[31]  A. Fujishima,et al.  Electrochemical selectivity for redox systems at oxygen-terminated diamond electrodes ☆ , 1999 .

[32]  J. Robertson,et al.  Interpretation of Raman spectra of disordered and amorphous carbon , 2000 .

[33]  E. N. Loubnin,et al.  Effect of crystal structure on the electrochemical behaviour of synthetic semiconductor diamond: Comparison of growth and a nucleation surfaces of a coarse-grained polycrystalline film , 2003 .

[34]  Kazuhito Hashimoto,et al.  Electrochemical Behavior of Highly Conductive Boron‐Doped Diamond Electrodes for Oxygen Reduction in Alkaline Solution , 1998 .

[35]  Keith N. Rosser,et al.  Raman and conductivity studies of boron-doped microcrystalline diamond, facetted nanocrystalline diamond and cauliflower diamond films , 2008 .

[36]  T. Itoh,et al.  In situ raman spectroelectrochemistry of electron transfer between glassy carbon and a chemisorbed nitroazobenzene monolayer. , 2002, Journal of the American Chemical Society.

[37]  D. Tryk,et al.  Relationships between surface character and electrochemical processes on diamond electrodes: dual roles of surface termination and near-surface hydrogen , 2001 .

[38]  L. Kavan,et al.  Spectroelectrochemistry of carbon nanotubes. , 2011, Chemphyschem : a European journal of chemical physics and physical chemistry.

[39]  Structural and photoluminescence properties of silicon nanocrystals embedded in SiC matrix prepared by magnetron sputtering , 2010 .

[40]  D. Riley,et al.  Electrochemical studies of moderately boron doped polycrystalline diamond in non-aqueous solvent , 2002 .

[41]  F. Marken,et al.  Boron-doped diamond electrodes in organic media: Electrochemical activation and selectivity effects , 2007 .

[42]  N. G. Ferreira,et al.  Investigation of a Cu/Pd Bimetallic System Electrodeposited on Boron-Doped Diamond Films for Application in Electrocatalytic Reduction of Nitrate , 2012 .

[43]  L. Kavan,et al.  Tuning of sorted double-walled carbon nanotubes by electrochemical charging. , 2010, ACS nano.

[44]  L. Ley,et al.  Surface transfer doping of diamond , 2004, Nature.

[45]  M. D. Krotova,et al.  Photoelectrochemical properties of semiconductor diamond , 1987 .

[46]  M. Panizza,et al.  Electrochemical oxidation of water on synthetic boron-doped diamond thin film anodes , 2003 .

[47]  Electrochemical oxidation and reduction processes at diamond electrodes of varying phase purity , 2006 .

[48]  P. May,et al.  Impedance studies of boron-doped CVD diamond electrodes , 2000 .

[49]  Xu,et al.  Standard electrochemical behavior of high-quality, boron-doped polycrystalline diamond thin-film electrodes , 2000, Analytical chemistry.

[50]  Stefan Nowy,et al.  The diamond/aqueous electrolyte interface: an impedance investigation. , 2008, Langmuir : the ACS journal of surfaces and colloids.

[51]  Y. Pleskov,et al.  Synthetic semiconductor diamond electrodes : Electrochemical behaviour of homoepitaxial boron-doped films orientated as (111), (110), and (100) faces , 2006 .

[52]  L. Kavan,et al.  In situ Raman and Vis-NIR spectroelectrochemistry at single-walled carbon nanotubes , 2000 .

[53]  Yoichiro Sato,et al.  Boron concentration dependence of Raman spectra on {100} and {111} facets of B-doped CVD diamond , 1998 .