Defect monitoring using scanning photoluminescence spectroscopy in multicrystalline silicon wafers

Scanning photoluminescence (PL) spectroscopy was performed on as-grown and processed multicrystalline silicon (mc-Si) wafers to investigate the defect distribution affecting the efficiency of solar cells. In highly inhomogeneous mc-Si prepared by (i) edge-defined film-fed growth or (ii) a block-casting technique, regions of a wafer with enhanced recombination activity and reduced minority carrier lifetime exhibit an intensive `defect' PL band at room temperature with the maximum at about 0.8 eV. By comparing PL mapping with the distribution of dislocations, we present experimental evidence that the 0.8 eV band corresponds to electrically active dislocation networks. This was confirmed using low-temperature PL spectroscopy, which revealed a characteristic quartet of the dislocation D-lines. One of these dislocation lines, D1, can be tracked as temperature increases and linked to the `defect' band. Strong linear polarization of the 0.8 eV PL band corresponds to a preferential localization of defects in regions with a high level of elastic stress measured with scanning infrared polariscopy. The origin of the 0.8 eV PL band is attributed to dislocations contaminated with impurity precipitates.

[1]  M. Tajima.  Characterization of semiconductors by photoluminescence mapping at room temperature , 1990 .

[2]  S. Finkbeiner,et al.  Temperature dependence of the indirect energy gap in crystalline silicon , 1996 .

[3]  E. C. Lightowlers,et al.  Luminescence associated with the presence of dislocations in silicon , 1993 .

[4]  M. Yamada.  Quantitative photoelastic measurement of residual strains in undoped semi‐insulating gallium arsenide , 1985 .

[5]  E. Weber,et al.  Dislocation-related photoluminescence in silicon , 1985 .

[6]  M. Tajima,et al.  Calibration of the Photoluminescence Method for Determining As and Al Concentrations in Si , 1990 .

[7]  S. Danyluk,et al.  Residual stress measurement in silicon sheet by shadow moire interferometry , 1987 .

[8]  J. Kalejs,et al.  Scanning room-temperature photoluminescence in polycrystalline silicon , 1999 .

[9]  Einar Ö. Sveinbjörnsson,et al.  Room temperature electroluminescence from dislocation‐rich silicon , 1996 .

[10]  S. Ostapenko,et al.  Spatially resolved defect diagnostics in multicrystalline silicon for solar cells , 2000 .

[11]  Hall,et al.  Impurity-related photoluminescence from silicon at room temperature. , 1994, Physical review. B, Condensed matter.

[12]  S. Koveshnikov,et al.  Defect diagnostics using scanning photoluminescence in multicrystalline silicon , 1999 .

[13]  G. Davies,et al.  The optical properties of luminescence centres in silicon , 1989 .

[14]  S. Lederhandler.  Infrared Studies of Birefringence in Silicon , 1959 .

[15]  H. Hovel.  Scanned photoluminescence of semiconductors , 1992 .

[16]  M. Warashina,et al.  Photoluminescence Due To Oxygen Precipitates Distinguished from the D Lines in Annealed Si , 1995 .