Frequency Modulation Technique for MEMS Resistive Sensing

Frequency modulation technique can be applied to microelectromechanical systems (MEMS) transducers that require some form of resistive sensing. For example, electrothermal sensing is being investigated as a viable means of measuring displacement in micromachined transducers. This paper proposes a highly sensitive readout circuit, which can convert 10 Ω change of resistance in a 400 Ω electrothermal sensor to more than 200 kHz frequency variation (350-550 KHz). The frequency variations are then converted to voltage values by means of a frequency demodulation. In addition, the proposed technique achieves high linearity from the voltage applied to the actuator to the voltage measured at the sensor's output, which can potentially eliminate the need for an additional linearization if the sensor is used in a feedback loop. The proposed approach leads to high sensitivity in the MEMS electrothermal sensing since the method is not affected by amplitude variations that could arise from the readout circuit.

[1]  E. Vittoz,et al.  A CMOS Chopper Amplifier , 1986, ESSCIRC '86: Twelfth European Solid-State Circuits Conference.

[2]  William P. King,et al.  Electrical noise characteristics of a doped silicon microcantilever heater-thermometer , 2010, 2010 IEEE Sensors.

[3]  Ralf Brederlow,et al.  Low-frequency noise of integrated polysilicon resistors , 2001 .

[4]  T. Pialis,et al.  Analysis of timing jitter in ring oscillators due to power supply noise , 2003, Proceedings of the 2003 International Symposium on Circuits and Systems, 2003. ISCAS '03..

[5]  Kyutae Lim,et al.  A ring VCO with wide and linear tuning characteristics for a cognitive radio system , 2008, 2008 IEEE Radio Frequency Integrated Circuits Symposium.

[6]  S. Tseng,et al.  A CMOS MEMS thermal sensor with high frequency output , 2008, 2008 IEEE Sensors.

[7]  Daniele Marioli,et al.  Oscillator-based signal conditioning with improved linearity for resistive sensors , 1998, IEEE Trans. Instrum. Meas..

[8]  Gerd K. Binnig,et al.  Scanning Tunneling Microscope , 2020, Definitions.

[9]  Ramesh Harjani,et al.  Analysis and design of low-phase-noise ring oscillators , 2000, ISLPED'00: Proceedings of the 2000 International Symposium on Low Power Electronics and Design (Cat. No.00TH8514).

[11]  Pascal Nouet,et al.  A low power interface circuit for resistive sensors with digital offset compensation , 2010, Proceedings of 2010 IEEE International Symposium on Circuits and Systems.

[12]  M. Sawan,et al.  A wide tuning range voltage-controlled ring oscillator dedicated to ultrasound transmitter , 2004, Proceedings. The 16th International Conference on Microelectronics, 2004. ICM 2004..

[13]  Beth L. Pruitt,et al.  Review: Semiconductor Piezoresistance for Microsystems , 2009, Proceedings of the IEEE.

[14]  P. Bruschi,et al.  Design of CMOS chopper amplifiers for thermal sensor interfacing , 2008, 2008 Ph.D. Research in Microelectronics and Electronics.

[15]  L. Howell,et al.  Actuators for Micropositioners and Nanopositioners , 2006 .

[16]  Yong Zhang,et al.  Active Release of Microobjects Using a MEMS Microgripper to Overcome Adhesion Forces , 2009, Journal of Microelectromechanical Systems.

[17]  Gerber,et al.  Atomic Force Microscope , 2020, Definitions.

[18]  M. Berroth,et al.  Reduction of CMOS Inverter Ring Oscillator Close-in Phase Noise by Current Mode Instead of Voltage Mode Supply , 2006, 2006 Ph.D. Research in Microelectronics and Electronics.

[19]  Daniele Marioli,et al.  A low-cost interface to high-value resistive sensors varying over a wide range , 2004, IEEE Transactions on Instrumentation and Measurement.

[20]  M. Tonteling,et al.  A MEMS actuator for integrated carbon nanotube strain sensing , 2005, IEEE Sensors, 2005..

[21]  David S. Ricketts,et al.  The Designer's Guide to Jitter in Ring Oscillators , 2009 .

[22]  A Bazaei,et al.  A Micromachined Nanopositioner With On-Chip Electrothermal Actuation and Sensing , 2010, IEEE Electron Device Letters.

[23]  Changzhi Li,et al.  A 1–9 GHz Linear-Wide-Tuning-Range Quadrature Ring Oscillator in 130 nm CMOS for Non-Contact Vital Sign Radar Application , 2010, IEEE Microwave and Wireless Components Letters.

[24]  Robert K. Messenger,et al.  Piezoresistive Feedback Control of a MEMS Thermal Actuator , 2009, Journal of Microelectromechanical Systems.

[25]  A. Baschirotto,et al.  A 141-dB Dynamic Range CMOS Gas-Sensor Interface Circuit Without Calibration With 16-Bit Digital Output Word , 2007, IEEE Journal of Solid-State Circuits.

[26]  G. Binnig,et al.  A micromechanical thermal displacement sensor with nanometre resolution , 2005 .

[27]  Randall L. Geiger,et al.  Transfer characterization of CMOS ring voltage controlled oscillators , 2001, Proceedings of the 44th IEEE 2001 Midwest Symposium on Circuits and Systems. MWSCAS 2001 (Cat. No.01CH37257).

[28]  B. Nelson,et al.  Monolithically Fabricated Microgripper With Integrated Force Sensor for Manipulating Microobjects and Biological Cells Aligned in an Ultrasonic Field , 2007, Journal of Microelectromechanical Systems.

[29]  M. Ono.  [Scanning tunneling microscope]. , 1990, Tanpakushitsu kakusan koso. Protein, nucleic acid, enzyme.

[30]  A.A. Abidi,et al.  Phase Noise and Jitter in CMOS Ring Oscillators , 2006, IEEE Journal of Solid-State Circuits.