Optimization of saccharification of sweet sorghum bagasse using response surface methodology

Abstract The lignocellulose rich sweet sorghum bagasse (SSB) is a good feedstock for bioethanol production after conversion of its insoluble carbohydrates, mainly cellulose, to fermentable sugars. Main focus of the present investigation was therefore, to determine the optimum conditions for enzymatic saccharification of SSB using indigenously produced cellulases from a novel fungal consortium of Aspergillus flavus F-80 and Aspergillus niger MTCC-2425. Response surface methodology was adopted by using a three factor-three level Box–Behnken design by selecting substrate concentration (%, w/v), saccharification time (h) and enzyme loading (FPU g−1 substrate) as the main process parameters. Data obtained from RSM were subjected to the analysis of variance (ANOVA) and analyzed using a second order polynomial equation. The developed model was found to be robust and was used to optimize the % saccharification yield during enzymatic hydrolysis. Under optimized conditions (substrate concentration 6%, w/v, time 48 h and enzyme loading of 22 FPU g−1 substrate), maximum saccharification yield of 51.21% was achieved. Structural modification of SSB due to enzymatic saccharification was supported by changes in thermal decomposition behavior and pore formation observed during thermogravimetric and SEM analysis, respectively.

[1]  P. Sanjana Reddy,et al.  Sweet Sorghum - A Potential Alternate Raw Material for Bio-ethanol and Bio- energy , 2005 .

[2]  K. L. Kalra,et al.  Enzymatic saccharification of pretreated sunflower stalks , 2002 .

[3]  J. Wright.  Ethanol from biomass by enzymatic hydrolysis , 1988 .

[4]  Zsófia Kádár,et al.  Sweet Sorghum as Feedstock for Ethanol Production: Enzymatic Hydrolysis of Steam-Pretreated Bagasse , 2009, Applied biochemistry and biotechnology.

[5]  W. Qi,et al.  Enhanced Enzymatic Hydrolysis of Lignocellulose by Optimizing Enzyme Complexes , 2010, Applied biochemistry and biotechnology.

[6]  M. Penttilä,et al.  Regulation of production of plant polysaccharide degrading enzymes by Trichoderma , 1998 .

[7]  C. Hongzhang,et al.  Effect of the ash on enzymatic hydrolysis of steam-exploded rice straw. , 2010, Bioresource technology.

[8]  M. Galbe,et al.  Influence of Enzyme Loading and Physical Parameters on the Enzymatic Hydrolysis of Steam‐Pretreated Softwood , 2001, Biotechnology progress.

[9]  F. Tao,et al.  Ethanol fermentation by an acid-tolerant Zymomonas mobilis under non-sterilized condition , 2005 .

[10]  Van Soest,et al.  Use of detergents in the analysis of fibrous feeds. 2. A rapid method for the determination of fiber and lignin. , 1963 .

[11]  R. J. Straub,et al.  Enzymic saccharification of alfalfa fibre after liquid hot water pretreatment , 1999 .

[12]  D. Eveleigh,et al.  Measurement of saccharifying cellulase , 2009, Biotechnology for biofuels.

[13]  Herng-Kuang Sheen,et al.  Hydrolysis characteristics of sugarcane bagasse pretreated by dilute acid solution in a microwave irradiation environment , 2012 .

[14]  T. K. Ghose.  Measurement of cellulase activities , 1987 .

[15]  G. L. Miller,et al.  Protein determination for large numbers of samples. , 1959 .

[16]  Qiang Yu,et al.  High consistency enzymatic saccharification of sweet sorghum bagasse pretreated with liquid hot water. , 2012, Bioresource technology.

[17]  Datta Madamwar,et al.  Solid State Fermentation of Lignocellulosic Waste for Cellulase and β‐Glucosidase Production by Cocultivation ofAspergillus ellipticusand Aspergillus fumigatus , 1997 .

[18]  Mats Galbe,et al.  Optimization of temperature and enzyme concentration in the enzymatic saccharification of steam-pretreated willow , 1990 .

[19]  H. K. Manonmani,et al.  Saccharification of sugar-cane bagasse with enzymes from Aspergillus ustus and Trichoderma viride. , 1987 .

[20]  K. Muthukumarappan,et al.  Optimization of switchgrass and extruder parameters for enzymatic hydrolysis using response surface methodology , 2011 .

[21]  L. Xia,et al.  Enzymatic hydrolysis of corncob and ethanol production from cellulosic hydrolysate , 2007 .

[22]  John N. Saddler,et al.  A comparison between simultaneous saccharification and fermentation and separate hydrolysis and fermentation using steam-pretreated corn stover , 2007 .

[23]  M. Galbe,et al.  Steam pretreatment of dilute H2SO4-impregnated wheat straw and SSF with low yeast and enzyme loadings for bioethanol production. , 2008 .

[24]  Ethanol Production from H2SO3-Steam-Pretreated Fresh Sweet Sorghum Stem by Simultaneous Saccharification and Fermentation , 2010, Applied biochemistry and biotechnology.

[25]  M. Penner,et al.  Apparent substrate inhibition of the Trichoderma reesei cellulase system , 1991 .

[26]  Ying-Jin Yuan,et al.  Process optimization to convert forage and sweet sorghum bagasse to ethanol based on ammonia fiber expansion (AFEX) pretreatment. , 2010, Bioresource technology.

[27]  M. M. Bradford.  A rapid and sensitive method for the quantitation of microgram quantities of protein utilizing the principle of protein-dye binding. , 1976, Analytical biochemistry.

[28]  T. Vancov,et al.  Enhanced enzyme saccharification of Sorghum bicolor straw using dilute alkali pretreatment. , 2010, Bioresource technology.

[29]  L. Fan,et al.  Kinetic studies of enzymatic hydrolysis of insoluble cellulose: Analysis of the initial rates , 1982, Biotechnology and bioengineering.

[30]  Mohammad J. Taherzadeh,et al.  Bioethanol production from sweet sorghum bagasse by Mucor hiemalis , 2011 .

[31]  C. M. Kinoshita,et al.  Steam explosion of sugarcane bagasse as a pretreatment for conversion to ethanol. , 1998 .

[32]  Charles E. Wyman,et al.  Ethanol from lignocellulosic biomass: Technology, economics, and opportunities , 1994 .

[33]  S. Ferreira,et al.  Box-Behnken design: an alternative for the optimization of analytical methods. , 2007, Analytica chimica acta.

[34]  K. Réczey,et al.  Chemical pretreatments of corn stover for enhancing enzymatic digestibility , 2002, Applied biochemistry and biotechnology.

[35]  B. Saha,et al.  Lime pretreatment, enzymatic saccharification and fermentation of rice hulls to ethanol , 2008 .

[36]  D. Fengel,et al.  Wood: Chemistry, Ultrastructure, Reactions , 1983 .

[37]  K. Mohanty,et al.  Optimisation of the acid catalysed pretreatment of areca nut husk fibre using the Taguchi design method , 2011 .

[38]  M. Vossoughi,et al.  Optimisation of dilute-acid pretreatment conditions for enhancement sugar recovery and enzymatic hydrolysis of wheat straw , 2012 .

[39]  S. Chakravarthy,et al.  Sweet Sorghum as Feedstock for Biofuel Production: A Review , 2011, Sugar Tech.

[40]  Bin Yang,et al.  Fast and efficient alkaline peroxide treatment to enhance the enzymatic digestibility of steam-exploded softwood substrates. , 2002, Biotechnology and bioengineering.

[41]  Alain Dufresne,et al.  Review of recent research into cellulosic whiskers, their properties and their application in nanocomposite field. , 2005, Biomacromolecules.

[42]  Johnathan E. Holladay,et al.  Studying cellulose fiber structure by SEM, XRD, NMR and acid hydrolysis , 2007 .

[43]  J N Saddler,et al.  Factors affecting cellulose hydrolysis and the potential of enzyme recycle to enhance the efficiency of an integrated wood to ethanol process , 2000, Biotechnology and bioengineering.