An online state of charge estimation method with reduced prior battery testing information

An online State of Charge (SOC) estimation method with reduced prior battery testing information is proposed in this paper, in which no testing data obtained in laboratory is needed, including the relationship between the open circuit voltage (OCV) and the SOC. The first order RC battery model is utilized to interpret the characteristics of the lithium-ion battery. The genetic algorithm is introduced to carry out the online identification for the battery model. Parameters obtained by the identification are applied to the joint SOC estimation method to estimate the SOC of the battery. An experimental battery test workbench is established to validate the proposed method. Several drive cycle current profiles are scaled down and applied to the battery. The experiment results show that the parameters obtained by the proposed method could characterize the battery well, even for different drive cycles, and accurate SOC of the battery could be obtained online.

[1]  Jianqiu Li,et al.  On-line equalization for lithium-ion battery packs based on charging cell voltages: Part 2. Fuzzy logic equalization , 2014 .

[2]  Yi-Hsien Chiang,et al.  Online estimation of internal resistance and open-circuit voltage of lithium-ion batteries in electr , 2011 .

[3]  Jun Xu,et al.  A new method to estimate the state of charge of lithium-ion batteries based on the battery impedance model , 2013 .

[4]  Jon P. Christophersen,et al.  U.S. Department of Energy Vehicle Technologies Program: Battery Test Manual For Plug-In Hybrid Electric Vehicles , 2014 .

[5]  Ahmad Pesaran,et al.  Temperature-Dependent Battery Models for High-Power Lithium-Ion Batteries , 2001 .

[6]  Binggang Cao,et al.  A Comparison Study of the Model Based SOC Estimation Methods for Lithium-Ion Batteries , 2013, 2013 IEEE Vehicle Power and Propulsion Conference (VPPC).

[7]  C. Moo,et al.  Enhanced coulomb counting method for estimating state-of-charge and state-of-health of lithium-ion batteries , 2009 .

[8]  Guangjun Liu,et al.  Estimation of Battery State of Charge With $H_{\infty}$ Observer: Applied to a Robot for Inspecting Power Transmission Lines , 2012, IEEE Transactions on Industrial Electronics.

[9]  Xiaosong Hu,et al.  Estimation of State of Charge of a Lithium-Ion Battery Pack for Electric Vehicles Using an Adaptive Luenberger Observer , 2010 .

[10]  Guangjun Liu,et al.  A battery state of charge estimation method using sliding mode observer , 2008, 2008 7th World Congress on Intelligent Control and Automation.

[11]  Gregory L. Plett,et al.  Extended Kalman filtering for battery management systems of LiPB-based HEV battery packs: Part 2. Modeling and identification , 2004 .

[12]  Binggang Cao,et al.  The State of Charge Estimation of Lithium-Ion Batteries Based on a Proportional-Integral Observer , 2014, IEEE Transactions on Vehicular Technology.

[13]  Hongwen He,et al.  Evaluation of Lithium-Ion Battery Equivalent Circuit Models for State of Charge Estimation by an Experimental Approach , 2011 .

[14]  Jun Xu,et al.  Online battery state of health estimation based on Genetic Algorithm for electric and hybrid vehicle applications , 2013 .

[15]  IL-Song Kim,et al.  A Technique for Estimating the State of Health of Lithium Batteries Through a Dual-Sliding-Mode Observer , 2010, IEEE Transactions on Power Electronics.

[16]  Yangsheng Xu,et al.  Battery state-of-charge estimation based on H∞ filter for hybrid electric vehicle , 2008, 2008 10th International Conference on Control, Automation, Robotics and Vision.

[17]  Gregory L. Plett,et al.  Sigma-point Kalman filtering for battery management systems of LiPB-based HEV battery packs: Part 1: Introduction and state estimation , 2006 .

[18]  Il-Song Kim,et al.  Nonlinear State of Charge Estimator for Hybrid Electric Vehicle Battery , 2008, IEEE Transactions on Power Electronics.

[19]  William Leithead,et al.  Survey of gain-scheduling analysis and design , 2000 .

[20]  Jianqiu Li,et al.  On-line equalization for lithium-ion battery packs based on charging cell voltages: Part 1. Equalization based on remaining charging capacity estimation , 2014 .

[21]  Tao Xu,et al.  Electrical Power and Energy Systems , 2015 .

[22]  Valerie H. Johnson,et al.  Battery performance models in ADVISOR , 2002 .

[23]  Il-Song Kim,et al.  The novel state of charge estimation method for lithium battery using sliding mode observer , 2006 .

[24]  K. Tsang,et al.  Identification and modelling of Lithium ion battery , 2010 .

[25]  Binggang Cao,et al.  SOC Based Battery Cell Balancing with a Novel Topology and Reduced Component Count , 2013 .

[26]  Weijun Gu,et al.  Online cell SOC estimation of Li-ion battery packs using a dual time-scale Kalman filtering for EV applications , 2012 .