An innovative gas sensor incorporating ZnO–CuO nanoflakes in planar MEMS technology

Abstract In this work, a simple and cost effective MEMS based gas sensor incorporating ZnO–CuO nanoflakes is presented. For ZnO–CuO nanoflakes synthesis, brass film was deposited on oxidized Si substrate by radio frequency (RF) diode sputtering and subsequently subjected to thermal oxidation process. The oxidized samples were characterized using SEM, XRD, XPS and Raman spectroscopy. For the fabrication of the complete sensor, planar MEMS technology with integrated microheater was adopted. This technology uses sputter deposited and recessed SiO 2 platform in Si substrate for providing thermal isolation to reduce the power consumption of Ni microheater and prevents heat spreading from heater area. The microheater performance was simulated and experimentally verified. The sensor was tested for different toxic gases and volatile organic compounds (VOCs) over range of operating temperatures and concentrations for optimal sensing performances. The sensing results revealed that the sensor had highest response for acetone vapours over other gases. Also, it showed reproducible and stable performance.

[1]  Guang-Can Guo,et al.  Origin of ferroelectricity in high-T(c) magnetic ferroelectric CuO. , 2010, Physical review letters.

[2]  Xintang Huang,et al.  Fabrication of a SnO2-Based Acetone Gas Sensor Enhanced by Molecular Imprinting , 2014, Sensors.

[3]  Anoop Lal Vyas,et al.  Integration of ZnO nanostructures with MEMS for ethanol sensor , 2012 .

[4]  Shoou-Jinn Chang,et al.  Highly sensitive ZnO nanowire ethanol sensor with Pd adsorption , 2007 .

[5]  Zuxun Zhang,et al.  Multifunctional CuO nanowire devices: p-type field effect transistors and CO gas sensors , 2009, Nanotechnology.

[6]  G. Choi,et al.  CO gas sensing properties of ZnO–CuO composite , 1998 .

[7]  Jae-Hun Kim,et al.  Optimum shell thickness and underlying sensing mechanism in p–n CuO–ZnO core–shell nanowires , 2016 .

[8]  L. A. Patil,et al.  Cr2O3-activated ZnO thick film resistors for ammonia gas sensing operable at room temperature , 2007 .

[9]  A. Haque,et al.  Copper oxide based nanostructures for improved solar cell efficiency , 2014 .

[10]  Hongwei Sun,et al.  Fabrication and integration of metal oxide nanowire sensors using dielectrophoretic assembly and improved post-assembly processing , 2010 .

[11]  Sudipta Seal,et al.  Micromachined nanocrystalline SnO2 chemical gas sensors for electronic nose , 2004 .

[12]  Y. Ju,et al.  Growth of metal and metal oxide nanowires driven by the stress-induced migration , 2012 .

[13]  Jordi Riu,et al.  Gas sensors based on nanostructured materials. , 2007, The Analyst.

[14]  J T L Thong,et al.  Improving the NH3 gas sensitivity of ZnO nanowire sensors by reducing the carrier concentration , 2008, Nanotechnology.

[15]  J. Andrew Yeh,et al.  A Sub-ppm Acetone Gas Sensor for Diabetes Detection Using 10 nm Thick Ultrathin InN FETs , 2012, Sensors.

[16]  Yeon-Tae Yu,et al.  Functionalization of ZnO nanorods by CuO nanospikes for gas sensor applications , 2014 .

[17]  P. Chand,et al.  Structural, optical and ferroelectric behavior of CuO nanostructures synthesized at different pH values , 2013 .

[18]  Daniela Manno,et al.  WO3 gas sensors prepared by thermal oxidization of tungsten , 2008 .

[19]  Partha Bhattacharyya,et al.  A low power MEMS gas sensor based on nanocrystalline ZnO thin films for sensing methane , 2008, Microelectron. Reliab..

[20]  Anoop Lal Vyas,et al.  Fabrication and Characterization of Low Temperature Acetone Sensor Using CuO Nanowires , 2011 .

[21]  Jing Wang,et al.  CuO-In 2 O 3 core-shell nanowire based chemical gas sensors , 2014 .

[22]  S. Chang,et al.  Highly Sensitive ZnO Nanowire Acetone Vapor Sensor With Au Adsorption , 2008, IEEE Transactions on Nanotechnology.

[23]  Milutin Stanacevic,et al.  Nanosensor Device for Breath Acetone Detection , 2010 .

[24]  A. Onodera,et al.  Electronic Ferroelectricity in II-VI Semiconductor ZnO , 2012 .

[25]  Adisorn Tuantranont,et al.  Characterization of n-type and p-type semiconductor gas sensors based on NiOx doped TiO2 thin films , 2009 .

[26]  Raju Khan,et al.  Nanojunction effects in multiple ZnO nanowire gas sensor , 2010 .

[27]  H. Demir,et al.  Free-standing ZnO–CuO composite nanowire array films and their gas sensing properties , 2011, Nanotechnology.

[28]  B. Mondal,et al.  Acetone and ethanol sensing of barium hexaferrite particles: A case study considering the possibilities of non-conventional hexaferrite sensor , 2014 .

[29]  Partha Bhattacharyya,et al.  Operating Temperature, Repeatability, and Selectivity of TiO 2 Nanotube-Based Acetone Sensor: Influence of Pd and Ni Nanoparticle Modifications , 2015, IEEE Transactions on Device and Materials Reliability.

[30]  Yan Li,et al.  Synthesis of Zn2SnO4 via a co-precipitation method and its gas-sensing property toward ethanol , 2015 .

[31]  Haibin Yang,et al.  Selective acetone sensor based on dumbbell-like ZnO with rapid response and recovery , 2008 .

[32]  C. Jacob,et al.  Surface enhanced Raman scattering and photoluminescence properties of catalytic grown ZnO nanostructures , 2009 .

[33]  Hui Zhang,et al.  CuO nanodendrites synthesized by a novel hydrothermal route , 2004 .

[34]  G. Mutinati,et al.  CuO nanowire gas sensors for CO detection in humid atmosphere , 2013, 2013 Transducers & Eurosensors XXVII: The 17th International Conference on Solid-State Sensors, Actuators and Microsystems (TRANSDUCERS & EUROSENSORS XXVII).

[35]  Ahsanulhaq Qurashi,et al.  Ultra-fast Microwave Synthesis of ZnO Nanowires and their Dynamic Response Toward Hydrogen Gas , 2009, Nanoscale research letters.

[36]  Hyun Jae Kim,et al.  Low power micro-gas sensors using mixed SnO2 nanoparticles and MWCNTs to detect NO2, NH3, and xylene gases for ubiquitous sensor network applications , 2010 .

[37]  Haibin Yang,et al.  Growth and selective acetone detection based on ZnO nanorod arrays , 2009 .

[38]  R. Mariappan,et al.  Structural, morphological, optical and gas sensing properties of pure and Ru doped SnO2 thin films by nebulizer spray pyrolysis technique , 2015 .

[39]  Martin Moskovits,et al.  CHEMICAL SENSING AND CATALYSIS BY ONE-DIMENSIONAL METAL-OXIDE NANOSTRUCTURES , 2004 .

[40]  Changsheng Xie,et al.  Solution-Processed Gas Sensors Based on ZnO Nanorods Array with an Exposed (0001) Facet for Enhanced Gas-Sensing Properties , 2012 .

[41]  Yiqian Wang,et al.  Effect of surface stresses on CuO nanowire growth in the thermal oxidation of copper , 2011 .

[42]  Z. Fan,et al.  Zinc oxide nanostructures: synthesis and properties. , 2005, Journal of nanoscience and nanotechnology.

[43]  Young Soo Yoon,et al.  Work function effects of ZnO thin film for acetone gas detection , 2012 .

[44]  S. Choopun,et al.  ZnO Nanobelt Based Conductometric H2 and NO2 Gas Sensors , 2005, IEEE Sensors, 2005..

[45]  S. Chandra,et al.  A MEMS based acetone sensor incorporating ZnO nanowires synthesized by wet oxidation of Zn film , 2014 .

[46]  G. Sberveglieri,et al.  Indium oxide quasi-monodimensional low temperature gas sensor , 2006 .

[47]  Pietro Siciliano,et al.  Sprayed SnO2 thin films for NO2 sensors , 1999 .

[48]  Sung-Hoon Choa,et al.  Development of Micro-Heaters with Optimized Temperature Compensation Design for Gas Sensors , 2011, Sensors.

[49]  G. Choi,et al.  Composition Dependence of the Electrical Conductivity of ZnO(n)–CuO(p) Ceramic Composite , 2005 .

[50]  Jyh-Ming Ting,et al.  Growth of single crystal ZnO nanowires using sputter deposition , 2003 .

[51]  Chii-Wann Lin,et al.  Fabrication of NOx gas sensors using In2O3-ZnO composite films , 2010 .

[52]  Xindong Zhang,et al.  Highly stabilized and rapid sensing acetone sensor based on Au nanoparticle-decorated flower-like ZnO microstructures , 2015 .

[53]  R. Kumar,et al.  Zinc Oxide Nanostructures for NO2 Gas–Sensor Applications: A Review , 2014, Nano-Micro Letters.

[54]  Youbin Zheng,et al.  Gas sensing properties of p-type semiconducting vanadium oxide nanotubes , 2012 .

[55]  Giorgio Sberveglieri,et al.  Very low power consumption micromachined CO sensors , 1999 .

[56]  W. Shi,et al.  Photoluminescence properties of various CVD-grown ZnO nanostructures , 2010 .

[57]  David V. Keyson,et al.  Synthesis and characterization of CuO flower-nanostructure processing by a domestic hydrothermal microwave , 2008 .

[58]  Chan Woong Na,et al.  Highly sensitive and selective trimethylamine sensor using one-dimensional ZnO–Cr2O3 hetero-nanostructures , 2012, Nanotechnology.

[59]  José R. Ramos-Barrado,et al.  Use of low-temperature nanostructured CuO thin films deposited by spray-pyrolysis in lithium cells , 2005 .

[60]  S. S. Kim,et al.  A novel approach to improving oxidizing-gas sensing ability of p-CuO nanowires using biased radial modulation of a hole-accumulation layer , 2014 .

[61]  Chandan Kumar Sarkar,et al.  A highly sensitive methane sensor with nickel alloy microheater on micromachined Si substrate , 2012 .

[62]  Giorgio Sberveglieri,et al.  Thermal treatment stabilization processes in SnO/sub 2/ thin films catalyzed with Au and Pt , 2002 .

[63]  Yoon Myung,et al.  Unravelling transient phases during thermal oxidation of copper for dense CuO nanowire growth , 2014 .

[64]  H. Tuller,et al.  Comparative gas sensor response of SnO2, SnO and Sn3O4 nanobelts to NO2 and potential interferents , 2015 .

[65]  G. Eranna,et al.  Metal Oxide Nanostructures as Gas Sensing Devices , 2011 .

[66]  Xin Wang,et al.  Reduced graphene oxide decorated with CuO–ZnO hetero-junctions: towards high selective gas-sensing property to acetone , 2014 .

[67]  I-Cherng Chen,et al.  Laterally grown ZnO nanowire ethanol gas sensors , 2007 .

[68]  A. Iraji zad,et al.  Room temperature H2S gas sensor based on rather aligned ZnO nanorods with flower-like structures , 2015 .