Aging of photocatalytic coatings under a water flow: Long run performance and TiO2 nanoparticles release

Abstract Although photocatalytic coatings may experience severe wearing in most of their application, little work has been done to investigate their aging in a comprehensive way. In this article, we present an original experimental protocol to simulate an accelerated aging of photocatalytic coatings under a water flow, and test it on two materials: a well-known commercial product, Pilkington Activ™, and an experimental coating. The influence of intrinsic properties of the coatings (chemical nature, thickness) as well as environmental parameters (water matrix, UV-light) is investigated while the consequences of aging are evaluated under three different endpoints, related either to the long run performance of photocatalytic coatings or their environmental impact: (i) loss of the photocatalytic activity, (ii) degradation of mechanical properties, and (iii) release of TiO 2 nanoparticles. It is observed that both photocatalytic coatings experienced a deactivation of their active sites upon prolonged immersion. The extent of deactivation varies depending on the coating, being around 20% for experimental coatings and 65% for Pilkington Activ™ but shows little dependency on water matrix or illumination. An alteration of mechanical properties is seen on experimental coatings, which was accompanied by TiO 2 emissions as high as 150.5 μg L −1 . Although no reduction in film hardness or adhesion could be evidenced for Pilkington Activ™, TiO 2 concentrations up to 30.8 μg L −1 was detected in the aging water showing that some release of TiO 2 nanoparticles also took place on this material. Interestingly, a common mechanism of release, triggered by an interaction between TiO 2 , NaCl and UVA could be identified. Most severe damages were observed in presence of sodium chloride. These results suggest that the use of photocatalytic coatings with surface-bound nanoparticles in environmental applications may entail new entries of nanomaterials into the aqueous medium. They also prove that aging assays are an effective way of assessing the emissions.

[1]  A. Pierre,et al.  Effects of sodium and calcium ions on the aggregation of titanium dioxide, at high pH, in aqueous dispersions , 1993 .

[2]  L. Montanarella,et al.  Role of humic acids in the TiO2-photocatalyzed degradation of tetrachloroethene in water , 1999 .

[3]  M. Mohseni,et al.  Development of novel TiO2 sol–gel-derived composite and its photocatalytic activities for trichloroethylene oxidation , 2004 .

[4]  Krishnan Rajeshwar,et al.  Heterogeneous photocatalytic treatment of organic dyes in air and aqueous media , 2008 .

[5]  H. Y. Chen,et al.  Inhibition of the adsorption and photocatalytic degradation of an organic contaminant in an aqueous suspension of TiO2 by inorganic ions , 1997 .

[6]  C. Ni,et al.  Size dependency of nanocrystalline TiO2 on its optical property and photocatalytic reactivity exemplified by 2-chlorophenol , 2006 .

[7]  J. Herrmann,et al.  Why inorganic salts decrease the TiO2 photocatalytic efficiency , 2005 .

[8]  Chitsan Lin,et al.  Photocatalytic oxidation of toxic organohalides with TiO2/UV: the effects of humic substances and organic mixtures. , 2007, Chemosphere.

[9]  Saber Ahmed,et al.  Influence of parameters on the heterogeneous photocatalytic degradation of pesticides and phenolic contaminants in wastewater: a short review. , 2011, Journal of environmental management.

[10]  R. Doong,et al.  Photoassisted reduction of metal ions and organic dye by titanium dioxide nanoparticles in aqueous solution under anoxic conditions. , 2010, The Science of the total environment.

[11]  Richard D Handy,et al.  Toxicity of titanium dioxide nanoparticles to rainbow trout (Oncorhynchus mykiss): gill injury, oxidative stress, and other physiological effects. , 2007, Aquatic toxicology.

[12]  H. Jang,et al.  Effect of Particle Size and Phase Composition of Titanium Dioxide Nanoparticles on the Photocatalytic Properties , 2001 .

[13]  R. Yoon,et al.  Application of Extended DLVO Theory: II. Stability of Silica Suspensions , 1993 .

[14]  N. Jaffrézic,et al.  Size effects in liquid-phase photo-oxidation of phenol using nanometer-sized TiO2 catalysts , 2008 .

[15]  A. C. Fischer-Cripps,et al.  Critical review of analysis and interpretation of nanoindentation test data , 2006 .

[16]  E. Matijević,et al.  Particle adhesion and removal in model systems: X. The effect of electrolytes on particle detachment☆ , 1986 .

[17]  M Boller,et al.  Synthetic TiO2 nanoparticle emission from exterior facades into the aquatic environment. , 2008, Environmental pollution.

[18]  Nanna B. Hartmann,et al.  Algal testing of titanium dioxide nanoparticles--testing considerations, inhibitory effects and modification of cadmium bioavailability. , 2010, Toxicology.

[19]  D. Dionysiou,et al.  Correlation of structural properties and film thickness to photocatalytic activity of thick TiO2 films coated on stainless steel , 2006 .

[20]  Roe-Hoan Yoon,et al.  Application of Extended DLVO Theory , 1993 .

[21]  M. Audier,et al.  Transparent photocatalytic films deposited on polymer substrates from sol–gel processed titania sols , 2003 .

[22]  D. Bahnemann,et al.  Highly photoactive supported TiO2 prepared by thermal hydrolysis of TiOSO4: Optimisation of the method and comparison with other synthetic routes , 2005 .

[23]  John Crittenden,et al.  Impact of natural organic matter and divalent cations on the stability of aqueous nanoparticles. , 2009, Water research.

[24]  M. Tadé,et al.  Volatile organic compounds in indoor environment and photocatalytic oxidation: state of the art. , 2007, Environment international.

[25]  J. Cairns,et al.  Aquatic toxicology. Part 2 , 1990 .

[26]  R. L. Sawhney,et al.  Solar photocatalytic removal of metal ions from industrial wastewater , 2008 .

[27]  J. Weber,et al.  Influence of pH and chloride anion on the photocatalytic degradation of organic compounds , 2001 .

[28]  Michael Burkhardt,et al.  Release of silver nanoparticles from outdoor facades. , 2010, Environmental pollution.

[29]  T. Yoshikawa,et al.  Size Effects of Nanomaterials on Lung Inflammation and Coagulatory Disturbance , 2008, International journal of immunopathology and pharmacology.

[30]  Jeremy J. W. Chen,et al.  Titanium dioxide nanoparticles induce emphysema‐like lung injury in mice , 2006, FASEB journal : official publication of the Federation of American Societies for Experimental Biology.

[31]  Dionysios D. Dionysiou,et al.  Evaluating the activities of immobilized TiO2 powder films for the photocatalytic degradation of organic contaminants in water , 2004 .

[32]  C. Chan,et al.  Size Effects in Gas-Phase Photo-oxidation of Trichloroethylene Using Nanometer-Sized TiO2 Catalysts , 2000 .

[33]  M. Anpo,et al.  Photocatalytic hydrogenation of propyne with water on small-particle titania: size quantization effects and reaction intermediates , 1987 .

[34]  HungMin Chein,et al.  Evaluation of nanoparticle emission for TiO2 nanopowder coating materials , 2006 .

[35]  L. Reijnders.  Hazard reduction for the application of titania nanoparticles in environmental technology. , 2008, Journal of hazardous materials.

[36]  W. A. Adams,et al.  The photocatalysis of N,N-diethyl-m-toluamide (DEET) using dispersions of Degussa P-25 TiO2 particles , 2009 .

[37]  Arturo A Keller,et al.  Influence of natural organic matter on the aggregation and deposition of titanium dioxide nanoparticles. , 2011, Journal of hazardous materials.

[38]  B. S. Murty,et al.  Effect of dehydration rate on non-hydrolytic TiO2 thin film processing: Structure, optical and photocatalytic performance studies , 2011 .

[39]  R. Gadow,et al.  Properties of High Velocity Suspension Flame Sprayed (HVSFS) TiO2 coatings , 2009 .

[40]  J. Molina-Bolívar,et al.  The role played by hydration forces in the stability of protein-coated particles: non-classical DLVO behaviour , 1999 .

[41]  K. Kasemets,et al.  Toxicity of nanoparticles of CuO, ZnO and TiO2 to microalgae Pseudokirchneriella subcapitata. , 2009, The Science of the total environment.

[42]  M. Bizarro,et al.  Photocatalytic activity enhancement of TiO2 films by micro and nano-structured surface modification , 2009 .

[43]  M. Toyoda,et al.  Effect of crystallinity of anatase on photoactivity for methyleneblue decomposition in water , 2004 .

[44]  R. Taurino,et al.  Functionalization of ceramic tile surface by sol-gel technique. , 2009, Journal of colloid and interface science.

[45]  D. Ollis,et al.  Decolorization of organic dyes on Pilkington Activ™ photocatalytic glass , 2007 .

[46]  J. Gómez‐Herrero,et al.  WSXM: a software for scanning probe microscopy and a tool for nanotechnology. , 2007, The Review of scientific instruments.

[47]  D. Dionysiou,et al.  Effects of water parameters on the degradation of microcystin-LR under visible light-activated TiO2 photocatalyst. , 2011, Water research.

[48]  T. Tsai,et al.  Promoter effect of vanadia on Co/Mo/Al2O3 catalyst for deep hydrodesulfurization via the hydrogenation reaction pathway , 2010 .

[49]  T. Webb,et al.  Pulmonary toxicity study in rats with three forms of ultrafine-TiO2 particles: differential responses related to surface properties. , 2007, Toxicology.

[50]  D. Dionysiou,et al.  TiO2 photocatalytic films on stainless steel: The role of Degussa P-25 in modified sol–gel methods , 2006 .

[51]  N. Yao,et al.  Investigation of the performance of TiO2 photocatalytic coatings , 2010, Chemical Engineering Journal.

[52]  M. Swaminathan,et al.  The influence of inorganic oxidants and metal ions on semiconductor sensitized photodegradation of 4-fluorophenol , 2007 .

[53]  Pengyi Zhang,et al.  Influence of Pretreatment of Titanium Substrate on Long-Term Stability of TiO2 Film , 2007 .

[54]  Chunzhong Wang,et al.  Comparison of the photocatalytic activity of TiO2 powder with different particle size , 2002 .

[55]  Richard D Handy,et al.  Dietary exposure to titanium dioxide nanoparticles in rainbow trout, (Oncorhynchus mykiss): no effect on growth, but subtle biochemical disturbances in the brain , 2009, Ecotoxicology.

[56]  L. Reijnders.  The release of TiO2 and SiO2 nanoparticles from nanocomposites , 2009 .

[57]  J. Chovelon,et al.  Naphthalene degradation in water by heterogeneous photocatalysis: An investigation of the influence of inorganic anions , 2008 .

[58]  Jackie Y. Ying,et al.  Role of Particle Size in Nanocrystalline TiO2-Based Photocatalysts , 1998 .

[59]  Nathalie Tufenkji,et al.  Aggregation of titanium dioxide nanoparticles: role of a fulvic acid. , 2009, Environmental science & technology.

[60]  James A. Anderson,et al.  Photocatalytic nitrate reduction over metal modified TiO2 , 2009 .

[61]  I. Parkin,et al.  Characterisation of the photocatalyst Pilkington Activ (TM): a reference film photocatalyst? , 2003 .

[62]  Cesar Pulgarin,et al.  Effect of pH, inorganic ions, organic matter and H2O2 on E. coli K12 photocatalytic inactivation by TiO2: Implications in solar water disinfection , 2004 .

[63]  Frank von der Kammer,et al.  Assessment of the physico-chemical behavior of titanium dioxide nanoparticles in aquatic environments using multi-dimensional parameter testing. , 2010, Environmental pollution.

[64]  Pratim Biswas,et al.  Role of Synthesis Method and Particle Size of Nanostructured TiO2 on Its Photoactivity , 2002 .

[65]  W. M. Haynes.  CRC Handbook of Chemistry and Physics , 1990 .