Hierarchical approach for simulating fluid flow in normal fault zones

Two-phase flow in faults is complex and difficult to predict. To analyse the effect of fault zones on fluid flow, this article presents a hierarchical geological/numerical framework aimed at simulating two-phase flow. The starting point is that fault zones consist of structures at several length scales, with each scale represented by suitable techniques within the same numerical model. A series of two-phase flow simulation experiments was conducted on four geological cases: one reference case with undeformed host rock and three cases with increasingly more complexity added to them. All the structures consist of lower permeability fault rocks in a high permeability host rock. The simulations were performed using an in-house flow simulator. The fault core (large scale) was modelled explicitly through local grid refinement, the subsidiary faults (intermediate scale) were represented in a discrete manner, while an upscaling procedure captured the effect of the deformation bands (fine scale). The simulation results show that each scale has a significant effect on the saturation, pressure drop and oil production, and that capillary pressure and anisotropic permeability are important parameters. The results emphasize the importance of the scale-dependent approach for analysing the effect of faults on two-phase flow.

[1]  L. Durlofsky.  Numerical calculation of equivalent grid block permeability tensors for heterogeneous porous media , 1991 .

[2]  Hilde Reme,et al.  Parallelization of a Compositional Simulator with a Galerkin Coarse/Fine Method , 1999, Euro-Par.

[3]  I. Aavatsmark,et al.  An Introduction to Multipoint Flux Approximations for Quadrilateral Grids , 2002 .

[4]  A. Beach,et al.  Reservoir damage around faults; outcrop examples from the Suez Rift , 1999, Petroleum Geoscience.

[5]  Robert J. Knipe,et al.  Empirical estimation of fault rock properties , 2002 .

[6]  L. Durlofsky,et al.  An Efficient Discrete-Fracture Model Applicable for General-Purpose Reservoir Simulators , 2004 .

[7]  D. Wiltschko,et al.  Microfracturing, paleostress and the growth of faults , 1994 .

[8]  S. Berg,et al.  Controls on damage zone asymmetry of a normal fault zone: outcrop analyses of a segment of the Moab fault, SE Utah , 2005 .

[9]  J. Walsh,et al.  Complexity in fault zone structure and implications for fault seal prediction , 1997 .

[10]  Louis J. Durlofsky,et al.  Upscaled models of flow and transport in faulted sandstone: boundary condition effects and explicit fracture modelling , 2004, Petroleum Geoscience.

[11]  D. Pollard,et al.  Estimation of in situ permeability of deformation bands in porous sandstone, Valley of Fire, Nevada , 2000 .

[12]  Louis J. Durlofsky,et al.  Representation of Fault Zone Permeability in Reservoir Flow Models , 2001 .

[13]  M. Antonellini,et al.  Effect of Faulting on Fluid Flow in Porous Sandstones: Geometry and Spatial Distribution , 1995 .

[14]  B. Larsen,et al.  An experimental study of the texture of deformation bands: effects on the porosity and permeability of sandstones , 2002, Petroleum Geoscience.

[15]  E. Sverdrup,et al.  Sealing properties of faults and their influence on water-alternating-gas injection efficiency in the Snorre field, northern North Sea , 2003 .

[16]  J. Hesthammer,et al.  Spatial relationships within fault damage zones in sandstone , 2000 .

[17]  R. Schlische,et al.  The geometric and statistical evolution of normal fault systems: an experimental study of the effects of mechanical layer thickness on scaling laws , 2001 .

[18]  Gareth O'Brien,et al.  A numerical study of passive transport through fault zones , 2003 .

[19]  Magne S. Espedal,et al.  Modeling fractured and faulted regions: Local grid refinement methods for implicit solvers , 2004 .

[20]  J. Walsh,et al.  A model for the structure and development of fault zones , 1996, Journal of the Geological Society.

[21]  Leslie Smith,et al.  Fluid flow in fault zones: Influence of hydraulic anisotropy and heterogeneity on the fluid flow and heat transfer regime , 1996 .

[22]  J. Walsh,et al.  Geological implications of a large pressure difference across a small fault in the Viking Graben , 2002 .

[23]  Tom Manzocchi,et al.  The representation of two phase fault-rock properties in flow simulation models , 2002, Petroleum Geoscience.

[24]  James P. Evans,et al.  Mesoscopic structure of the Punchbowl Fault, Southern California and the geologic and geophysical structure of active strike-slip faults , 2000 .

[25]  Arvid M. Johnson,et al.  Development of faults as zones of deformation bands and as slip surfaces in sandstone , 1978 .

[26]  James P. Evans,et al.  Internal structure and weakening mechanisms of the San Andreas Fault , 1993 .

[27]  Frederick M. Chester,et al.  Implications for mechanical properties of brittle faults from observations of the Punchbowl fault zone, California , 1986 .

[28]  N. Morrow.  Wettability and Its Effect on Oil Recovery , 1990 .

[29]  H. Reme,et al.  Use of local grid refinement and a Galerkin technique to study secondary migration in fractured and faulted regions , 1999 .

[30]  P. Renard,et al.  Calculating equivalent permeability: a review , 1997 .

[31]  Z. Shipton,et al.  Damage zone and slip-surface evolution over μm to km scales in high-porosity Navajo sandstone, Utah , 2001 .

[32]  W. T. Parry,et al.  Fracturing and hydrothermal alteration in normal fault zones , 1994 .

[33]  Magne S. Espedal,et al.  Implicit Treatment of Compositional Flow , 2004 .

[34]  J. Caine,et al.  Fault Zone Architecture and Fluid Flow: Insights from Field Data and Numerical Modeling , 2013 .

[35]  A. Aydin.  Small faults formed as deformation bands in sandstone , 1978 .

[36]  Arvid M. Johnson,et al.  Analysis of faulting in porous sandstones , 1983 .

[37]  C. Dart,et al.  Reservoir compartmentalisation by water-saturated faults — Is evaluation possible with today's tools? , 2002 .

[38]  Z. Shipton,et al.  Fault tip displacement gradients and process zone dimensions , 1998 .

[39]  M. F. Lough,et al.  Hierarchical modeling of flow in naturally fractured formations with multiple length scales , 2001 .

[40]  N. L. Watts,et al.  Theoretical aspects of cap-rock and fault seals for single- and two-phase hydrocarbon columns , 1987 .

[41]  Joe Cartwright,et al.  Fault growth by linkage: observations and implications from analogue models , 2001 .

[42]  Agust Gudmundsson,et al.  Effects of Young's modulus on fault displacement , 2004 .

[43]  Louis J. Durlofsky,et al.  An Efficient Discrete Fracture Model Applicable for General Purpose Reservoir Simulators , 2003 .

[44]  E. Pittman.  Effect of Fault-Related Granulation on Porosity and Permeability of Quartz Sandstones, Simpson Group (Ordovician), Oklahoma , 1981 .

[45]  T. Hou,et al.  Analysis of upscaling absolute permeability , 2002 .

[46]  Magne S. Espedal,et al.  Implicit treatment of molar mass equations in secondary oil migration , 2002 .

[47]  Haakon Fossen,et al.  Experimental modeling of extensional fault systems by use of plaster , 1996 .

[48]  Alton A. Brown.  Capillary effects on fault-fill sealing , 2003 .

[49]  R. Helmig.  Multiphase Flow and Transport Processes in the Subsurface: A Contribution to the Modeling of Hydrosystems , 2011 .

[50]  Tom Manzocchi,et al.  Fault transmissibility multipliers for flow simulation models , 1999, Petroleum Geoscience.

[51]  James P. Evans,et al.  Fault zone architecture and permeability structure , 1996 .

[52]  Kenneth Stuart Sorbie,et al.  Immiscible flow behaviour in laminated and cross-bedded sandstones , 1993 .

[53]  M. Antonellini,et al.  Effect of Faulting on Fluid Flow in Porous Sandstones: Petrophysical Properties , 1994 .

[54]  Magne S. Espedal,et al.  Parallelization of a Compositional Reservoir Simulator , 2000 .

[55]  B. Crawford,et al.  Experimental fault sealing: shear band permeability dependency on cataclastic fault gouge characteristics , 1998, Geological Society, London, Special Publications.

[56]  B. Freeman,et al.  Quantitative Fault Seal Prediction , 1997 .

[57]  Robert J. Knipe,et al.  The permeability of faults within siliciclastic petroleum reservoirs of the North Sea and Norwegian Continental Shelf , 2001 .

[58]  L. Durlofsky,et al.  Permeability effects of deformation band arrays in sandstone , 2004 .

[59]  R. G. Gibson.  Physical character and fluid-flow properties of sandstone-derived fault zones , 1998, Geological Society, London, Special Publications.

[60]  M. C. Leverett,et al.  Capillary Behavior in Porous Solids , 1941 .

[61]  Q. Fisher,et al.  The importance of incorporating the multi-phase flow properties of fault rocks into production simulation models , 2005 .