Reverse osmosis desalination powered by photovoltaic and solar Rankine cycle power systems: A review

In this work, reverse osmosis water desalination plants powered by PV and solar RC cycle systems are reviewed in detail. This review focused on the display of different designs and software used to improve productivity of the desalination plants as well as the types of solar collectors used, membrane, heat transfer fluid and working fluid of the Rankine cycle. The specific energy consumption and cost of fresh water production are also of great interest in this work. According to the results presented in this review it is not recommended to use batteries with PV to drive RO desalination plants because of the high capital and replacement cost of batteries. It is also found that when the energy recovery devices are used, the pre-heating of feed water is not required, especially in the case of PV-RO systems. Currently most of working RO plants are driven by PV, whereas solar thermal power systems (usually using PTC with ORC) are still at the stage of theoretical research. Although, the PTC-ORC-RO desalination system is recommended, it has not yet been implemented on a large scale.

[1]  A. M. Helal,et al.  Economic feasibility of alternative designs of a PV-RO desalination unit for remote areas in the United Arab Emirates , 2008 .

[2]  A. A. El-Sebaii,et al.  An experimental investigation of a v-corrugated absorber single-basin solar still using PCM , 2016 .

[3]  P. Poovanaesvaran,et al.  Design and experimental performance of brackish water reverse osmosis desalination unit powered by 2 kW photovoltaic system , 2016 .

[4]  A. S. Nafey,et al.  Theoretical and experimental study of a small unit for solar desalination using flashing process , 2007 .

[5]  A. S. Nafey,et al.  Combined solar organic Rankine cycle with reverse osmosis desalination process: Energy, exergy, and cost evaluations , 2010 .

[6]  Alberto Coronas,et al.  Modelling and optimisation of solar organic rankine cycle engines for reverse osmosis desalination , 2008 .

[7]  G. Angelino,et al.  Organic Rankine cycles (ORCs) for energy recovery from molten carbonate fuel cells , 2000, Collection of Technical Papers. 35th Intersociety Energy Conversion Engineering Conference and Exhibit (IECEC) (Cat. No.00CH37022).

[8]  Hassan E.S. Fath,et al.  A comprehensive techno-economical review of indirect solar desalination , 2011 .

[9]  George Papadakis,et al.  Simulation of an autonomous, two-stage solar organic Rankine cycle system for reverse osmosis desalination , 2009 .

[10]  Jason C. Quinn,et al.  Economic analysis of photovoltaic (PV) powered water pumping and desalination without energy storage for agriculture , 2016 .

[11]  S. K. Wang,et al.  A Review of Organic Rankine Cycles (ORCs) for the Recovery of Low-grade Waste Heat , 1997 .

[12]  George Papadakis,et al.  Comparative thermodynamic study of refrigerants to select the best for use in the high-temperature stage of a two-stage organic Rankine cycle for RO desalination , 2009 .

[13]  Thomas K. Sherwood,et al.  Salt Concentration at Phase Boundaries in Desalination by Reverse Osmosis , 1965 .

[14]  E. von Münch,et al.  Impact of solar energy cost on water production cost of seawater desalination plants in Egypt , 2008 .

[15]  George Papadakis,et al.  Design of an autonomous low-temperature solar Rankine cycle system for reverse osmosis desalination , 2005 .

[16]  A. E. Kabeel,et al.  Theoretical and experimental parametric study of modified stepped solar still , 2012 .

[17]  S. D. Probert,et al.  Selecting a working fluid for a Rankine-cycle engine , 1985 .

[18]  M. Chandrashekara,et al.  Water desalination system using solar heat: A review , 2017 .

[19]  Julián Blanco,et al.  Performance of a 5 kWe Solar-only Organic Rankine Unit Coupled to a Reverse Osmosis Plant☆ , 2014 .

[20]  George Papadakis,et al.  Design of a two stage Organic Rankine Cycle system for reverse osmosis desalination supplied from a steady thermal source , 2010 .

[21]  Lourdes García-Rodríguez,et al.  Design recommendations for solar organic Rankine cycle (ORC)–powered reverse osmosis (RO) desalination , 2012 .

[22]  G. N. Tiwari,et al.  Analytical study of multi-effect solar still , 1989 .

[23]  Krunal Suthar,et al.  Modus operandi for maximizing energy efficiency and increasing permeate flux of community scale solar powered reverse osmosis systems , 2015 .

[24]  Guo Xie,et al.  Experimental and numerical study on a new multi-effect solar still with enhanced condensation surface , 2013 .

[25]  A. A. El-Sebaii,et al.  Thermal performance of a triple-basin solar still , 2005 .

[26]  Ali M. El-Nashar,et al.  The economic feasibility of small solar MED seawater desalination plants for remote arid areas , 2001 .

[27]  Chi-Chuan Wang,et al.  Effect of working fluids on organic Rankine cycle for waste heat recovery , 2004 .

[28]  George Papadakis,et al.  Low­grade heat conversion into power using organic Rankine cycles - A review of various applications , 2011 .

[29]  A. A. El-Sebaii,et al.  Advanced designs of solar desalination systems: A review , 2015 .

[30]  V. Maizza,et al.  Unconventional working fluids in organic Rankine-cycles for waste energy recovery systems , 2001 .

[31]  W. Beckman,et al.  Solar Engineering of Thermal Processes , 1985 .

[32]  Gonzalo Guillén-Gosálbez,et al.  Multi-objective optimization of solar Rankine cycles coupled with reverse osmosis desalination considering economic and life cycle environmental concerns , 2012 .

[33]  Saffa Riffat,et al.  Development of a prototype low-temperature Rankine cycle electricity generation system , 2001 .

[34]  Vincent Lemort,et al.  Testing and modeling a scroll expander integrated into an Organic Rankine Cycle , 2009 .

[35]  Lourdes García-Rodríguez,et al.  Thermoeconomic analysis of a solar parabolic trough collector distillation plant , 1999 .

[36]  Lourdes García-Rodríguez,et al.  Preliminary design of a solar thermal-powered seawater reverse osmosis system , 2007 .

[37]  N. Lai,et al.  Working fluids for high-temperature organic Rankine cycles , 2007 .

[38]  L. Suganthi,et al.  Solar stills: A comprehensive review of designs, performance and material advances , 2016 .

[39]  Steven Dubowsky,et al.  Thermal control to maximize photovoltaic powered reverse osmosis desalination systems productivity , 2013 .

[40]  K. Srithar,et al.  SINGLE BASIN SOLAR STILL WITH FIN FOR ENHANCING PRODUCTIVITY , 2008 .

[41]  Franco Evangelista.  A short cut method for the design of reverse osmosis desalination plants , 1985 .

[42]  Ali M. El-Nashar,et al.  The solar desalination plant in Abu Dhabi : 13 years of performance and operation history , 1998 .

[43]  A. E. Kabeel,et al.  Performance of finned and corrugated absorbers solar stills under Egyptian conditions , 2011 .

[44]  Hussein A. Abdullah,et al.  VARI-RO solar-powered desalting technology , 1999 .

[45]  Elias K. Stefanakos,et al.  Solar assisted sea water desalination: A review , 2013 .

[46]  Baltasar Peñate,et al.  Seawater reverse osmosis desalination driven by a solar Organic Rankine Cycle: Design and technology assessment for medium capacity range , 2012 .

[47]  H. Price,et al.  Modular Trough Power Plant Cycle and Systems Analysis , 2002 .

[48]  G. Kosmadakis,et al.  On site experimental evaluation of a low-temperature solar organic Rankine cycle system for RO desalination , 2009 .

[49]  A. Borsukiewicz-Gozdur,et al.  Comparative analysis of natural and synthetic refrigerants in application to low temperature Clausius–Rankine cycle , 2007 .

[50]  K. Srithar,et al.  Desalination of effluent using fin type solar still , 2008 .

[51]  Shahid Rabbani,et al.  Design and Cost Analysis of a Solar Photovoltaic Powered Reverse Osmosis Plant for Masdar Institute , 2015 .

[52]  Baltasar Peñate,et al.  Reverse osmosis hybrid membrane inter-stage design: A comparative performance assessment , 2011 .

[53]  Ruiliang Yang,et al.  Performance analysis of an organic Rankine cycle for a reverse osmosis desalination system using zeotropic mixtures , 2016 .

[54]  George Papadakis,et al.  Technical and economic comparison between PV-RO system and RO-Solar Rankine system. Case study: Thirasia island , 2008 .

[55]  T. Hung.  Waste heat recovery of organic Rankine cycle using dry fluids , 2001 .

[56]  Lourdes García-Rodríguez,et al.  Conditions for economical benefits of the use of solar energy in multi-stage flash distillation , 1999 .

[57]  D. Zarzo,et al.  Desalination techniques — A review of the opportunities for desalination in agriculture , 2015 .

[58]  Moh'd S. Abu-Jabal,et al.  Proving test for a solar-powered desalination system in Gaza-Palestine☆ , 2001 .

[59]  Richard Morris,et al.  Renewable energy sources for desalination , 2003 .

[60]  Saffa Riffat,et al.  Opportunities for solar water desalination worldwide: Review , 2013 .

[61]  A. E. Kabeel,et al.  Enhancing the stepped solar still performance using internal reflectors , 2013 .

[62]  George Kosmadakis,et al.  Parametric theoretical study of a two-stage solar organic Rankine cycle for RO desalination , 2010 .

[63]  George Papadakis,et al.  Experimental evaluation of an autonomous low-temperature solar Rankine cycle system for reverse osmosis desalination , 2007 .

[64]  Pichai Namprakai,et al.  The thermal performance of an ethanol solar still with fin plate to increase productivity , 2011 .

[65]  Lourdes García-Rodríguez,et al.  Preliminary design of seawater and brackish water reverse osmosis desalination systems driven by low-temperature solar organic Rankine cycles (ORC). , 2010 .

[66]  A. Alaudeen,et al.  Study on stepped type basin in a solar still , 2014 .

[67]  Lourdes García-Rodríguez,et al.  Preliminary assessment of solar organic Rankine cycles for driving a desalination system , 2007 .

[68]  G. Angelino,et al.  Multicomponent Working Fluids For Organic Rankine Cycles (ORCs) , 1998 .

[69]  M. A. Farwati.  Theoretical study of multi-stage flash distillation using solar energy , 1997 .

[70]  Badawi W. Tleimat.  Optimal water cost from solar-powered multieffect distillation , 1983 .

[71]  David Infield,et al.  A photovoltaic-powered seawater reverse-osmosis system without batteries , 2003 .

[72]  Abul Fazal M. Arif,et al.  On the feasibility of community-scale photovoltaic-powered reverse osmosis desalination systems for remote locations , 2011 .

[73]  David Infield,et al.  A small-scale seawater reverse-osmosis system with excellent energy efficiency over a wide operating range , 2003 .

[74]  Sridharakumar Narasimhan,et al.  Optimal operation of battery-less solar powered reverse osmosis plant for desalination , 2015 .

[75]  Philippe Moulin,et al.  Eausmose project: Desalination by reverse osmosis and batteryless solar energy: design for a 1m3 per day delivery , 2012 .

[76]  Mingxian Cui,et al.  Proof of concept study of an integrated solar desalination system , 2009 .

[77]  Lourdes García-Rodríguez,et al.  Solar-powered Rankine cycles for fresh water production , 2007 .

[78]  K. Srithar,et al.  Performance analysis in stepped solar still for effluent desalination , 2009 .

[79]  Chris T. Kiranoudis,et al.  Solar energy exploitation for reverse osmosis desalination plants , 1997 .

[80]  Eli Feinerman,et al.  Potential of solar desalination in Israel and in its close vicinity , 2001 .

[81]  Takahisa Yamamoto,et al.  Design and testing of the Organic Rankine Cycle , 2001 .

[82]  Dirk Herold,et al.  A small PV-driven reverse osmosis desalination plant on the island of Gran Canaria , 2001 .

[83]  A. S. Abdullah.  Improving the performance of stepped solar still , 2013 .

[84]  George Papadakis,et al.  A direct coupled photovoltaic seawater reverse osmosis desalination system toward battery based systems — a technical and economical experimental comparative study , 2008 .