Thermo-responsive culture dishes allow the intact harvest of multilayered keratinocyte sheets without dispase by reducing temperature.

To develop new technology for harvesting transplantable cultured epithelium without dispase treatment, human keratinocytes were plated on culture dishes grafted with a thermo-responsive polymer, poly(N-isopropylacrylamide). The grafted dish surfaces are slightly hydrophobic above 32 degrees C, but reversibly change to hydrophilic below this temperature. According to the method of Rheinwald and Green, keratinocytes proliferated and made a multilayer on the grafted surfaces at 37 degrees C, as on the nongrafted culture dishes. The multilayered keratinocyte sheets were detached from the grafted surfaces only by reducing temperature to 20 degrees C without need for dispase. No cell remnants were observed on the dishes. Such cell sheet detachment was not observed on nongrafted dishes. Immunoblotting of harvested keratinocyte sheets revealed that dispase treatment disrupted E-cadherin and laminin 5, while these molecules remained intact in the keratinocyte sheets harvested by only reducing temperature from the grafted dishes. Transmission electron microscopy revealed that desmosomes were destroyed in dispase treatment but retained in low-temperature treatment. Use of thermo-responsive dishes was examined as a new tool for tissue engineering to achieve the preparation of artificial epithelium for cell transplantation as well as for the investigation of intact multilayered keratinocyte sheets.

[1]  J. Mulliken,et al.  GRAFTING OF BURNS WITH CULTURED EPITHELIUM PREPARED FROM AUTOLOGOUS EPIDERMAL CELLS , 1981, The Lancet.

[2]  B. Tighe,et al.  Cellular interactions with synthetic polymer surfaces in culture. , 1985, Biomaterials.

[3]  R. Burgeson,et al.  Bone Morphogenetic Protein 1 Is an Extracellular Processing Enzyme of the Laminin 5 γ2 Chain* , 2000, The Journal of Biological Chemistry.

[4]  I. Leigh.  The Keratinocyte handbook , 1994 .

[5]  F. Hirahara,et al.  Wide Distribution of Laminin-5 γ2 Chain in Basement Membranes of Various Human Tissues , 1998, Hormone Research in Paediatrics.

[6]  T. Okano,et al.  Two-dimensional manipulation of confluently cultured vascular endothelial cells using temperature-responsive poly(N-isopropylacrylamide)-grafted surfaces. , 1998, Journal of biomaterials science. Polymer edition.

[7]  T. Okano,et al.  Signal transduction and cytoskeletal reorganization are required for cell detachment from cell culture surfaces grafted with a temperature-responsive polymer. , 1999, Journal of biomedical materials research.

[8]  A S Hoffman,et al.  Influence of the substrate binding characteristics of fibronectin on corneal epithelial cell outgrowth. Student Research Award in the Doctoral Degree Candidate Category, Fourth World Biomaterials Congress (18th annual meeting of the Society for Biomaterials), Berlin, Germany, April 24-28, 1992. , 1992, Journal of biomedical materials research.

[9]  U. K. Laemmli,et al.  Cleavage of Structural Proteins during the Assembly of the Head of Bacteriophage T4 , 1970, Nature.

[10]  J. Paddle-Ledinek,et al.  Skin replacement by cultured keratinocyte grafts: an Australian experience. , 1997, Burns : journal of the International Society for Burn Injuries.

[11]  M. Nagata,et al.  Action of the bacterial neutral protease, dispase, on cultured cells and its application to fluid suspension culture with a review on biomedical application of this protease. , 1986, The Japanese journal of experimental medicine.

[12]  Teruo Okano,et al.  Temperature dependence of swelling of crosslinked poly(N,N′-alkyl substituted acrylamides) in water , 1990 .

[13]  T. Okano,et al.  Thermo‐responsive polymeric surfaces; control of attachment and detachment of cultured cells , 1990 .

[14]  T. Okano,et al.  Release of adsorbed fibronectin from temperature-responsive culture surfaces requires cellular activity. , 2000, Biomaterials.

[15]  F. Grinnell.  Cellular adhesiveness and extracellular substrata. , 1978, International review of cytology.

[16]  T. Okano,et al.  A novel recovery system for cultured cells using plasma-treated polystyrene dishes grafted with poly(N-isopropylacrylamide). , 1993, Journal of biomedical materials research.

[17]  R. Burgeson,et al.  Laminin 5 can promote assembly of the lamina densa in the skin equivalent model. , 1998, Matrix biology : journal of the International Society for Matrix Biology.

[18]  C. Compton,et al.  Permanent Coverage of Large Burn Wounds with Autologous Cultured Human Epithelium , 1984 .

[19]  H. Kowalczyńska,et al.  Adhesion of L1210 cells to modified styrene copolymer surfaces in the presence of serum. , 1991, Journal of cell science.

[20]  H. Green,et al.  Formation of a keratinizing epithelium in culture by a cloned cell line derived from a teratoma , 1975, Cell.

[21]  R. Burgeson,et al.  Kalinin is abnormally expressed in epithelial basement membranes of Herlitz's junctional epidermolysis bullosa patients , 1992, Experimental dermatology.

[22]  R. Burgeson,et al.  Kalinin: an epithelium-specific basement membrane adhesion molecule that is a component of anchoring filaments , 1991, The Journal of cell biology.

[23]  H. Green,et al.  Seria cultivation of strains of human epidemal keratinocytes: the formation keratinizin colonies from single cell is , 1975, Cell.

[24]  C. Compton,et al.  Cultured Epithelial Autografts for Giant Congenital Nevi , 1989, Plastic and reconstructive surgery.

[25]  H Green,et al.  Growth of cultured human epidermal cells into multiple epithelia suitable for grafting. , 1979, Proceedings of the National Academy of Sciences of the United States of America.

[26]  R. Burgeson,et al.  A specific and sensitive ELISA for laminin 5. , 1999, Journal of immunological methods.

[27]  Masayuki Yamato,et al.  Accelerated cell sheet recovery by co-grafting of PEG with PIPAAm onto porous cell culture membranes. , 2003, Biomaterials.

[28]  T. Okano,et al.  Decrease in culture temperature releases monolayer endothelial cell sheets together with deposited fibronectin matrix from temperature-responsive culture surfaces. , 1999, Journal of biomedical materials research.

[29]  A. Kanai,et al.  The functions of exogenous and endogenous laminin-5 on corneal epithelial cells. , 2000, Experimental eye research.

[30]  R. Burgeson,et al.  Pretreatment of human keratinocyte sheets with laminin 5 improves their grafting efficiency. , 1997, The Journal of investigative dermatology.

[31]  K. Bentley,et al.  Adhesive substrates for fibronectin , 1981, Journal of cellular physiology.

[32]  B. Ratner,et al.  Hydrophilic-hydrophobic copolymers as cell substrates: Effect on 3T3 cell growth rates , 1985 .

[33]  M. Heskins,et al.  Solution Properties of Poly(N-isopropylacrylamide) , 1968 .

[34]  T. Okano,et al.  Mechanism of cell detachment from temperature-modulated, hydrophilic-hydrophobic polymer surfaces. , 1995, Biomaterials.

[35]  T. Okano,et al.  Temperature-responsive culture dishes allow nonenzymatic harvest of differentiated Madin-Darby canine kidney (MDCK) cell sheets. , 2000, Journal of biomedical materials research.

[36]  B D Ratner,et al.  Cell adhesion to a series of hydrophilic-hydrophobic copolymers studied with a spinning disc apparatus. , 1988, Journal of biomedical materials research.

[37]  M. Kramer,et al.  Dispase-mediated basal detachment of cultured keratinocytes induces urokinase-type plasminogen activator (uPA) and its receptor (uPA-R, CD87). , 1996, Experimental cell research.

[38]  R E Baier,et al.  Surface properties determine bioadhesive outcomes: methods and results. , 1984, Journal of biomedical materials research.

[39]  M. Raghunath,et al.  Burns (Part 2) , 1997 .

[40]  H. Busscher,et al.  The influence of substratum surface free energy on growth and spreading of human fibroblasts in the presence and absence of serum proteins. , 1986, Journal of biomedical materials research.

[41]  T. Okano,et al.  Intelligent thermoresponsive polymeric stationary phases for aqueous chromatography of biological compounds , 2002 .