Impact of substrate to inoculum ratio in anaerobic digestion of swine slurry

Abstract Batch tests using swine slurry as substrate were conducted to elucidate the impact on anaerobic digestion of different ratio of substrate (COD)/inoculum (VS). Soluble COD, volatile fatty acids (VFAs) concentration, and pH were periodically analyzed in order to completely understand possible inhibitions. In addition, ammonia concentration was also calculated at the start up and final stage of the test. The results showed that the same methane yield was achieved with the three experimental ratios (COD/VS of 1, 2 and 3), however methane production rates were clearly different. This later parameter decreased with increasing ratios. This behaviour was explained by the accumulation of VFAs (predominantly acetic (HAc) and propionic acid (HPr)), reflected on the soluble COD profile as well. The possible inhibition by free ammonia was null since the values calculated were far below the threshold concentration reported in literature.

[1]  B. Ahring,et al.  Anaerobic digestion of swine manure: Inhibition by ammonia , 1998 .

[2]  Qunhui Wang,et al.  Degradation of volatile fatty acids in highly efficient anaerobic digestion , 1999 .

[3]  W. M. Wiegant,et al.  The mechanism of ammonia inhibition in the thermophilic digestion of livestock wastes , 1986 .

[4]  A. E. Greenberg,et al.  Standard methods for the examination of water and wastewater : supplement to the sixteenth edition , 1988 .

[5]  Liang Meng,et al.  Effects of volatile fatty acid concentrations on methane yield and methanogenic bacteria , 2009 .

[6]  Xavier Flotats Ripoll,et al.  Codigestion of pig slurry and organic wastes from food industry , 1999 .

[7]  Andrew G. Hashimoto,et al.  Effect of inoculum/substrate ratio on methane yield and production rate from straw , 1988 .

[8]  Sonia Heaven,et al.  Influence of inoculum to substrate ratio on the biochemical methane potential of maize in batch tests , 2006 .

[9]  B. Ahring,et al.  Increase of anaerobic degradation of particulate organic matter in full-scale biogas plants by mechanical maceration. , 2000, Water science and technology : a journal of the International Association on Water Pollution Research.

[10]  G. Lettinga,et al.  The influence of ammonium-nitrogen on the specific activity of pelletized methanogenic sludge , 1984 .

[11]  Rafael Borja,et al.  Assessment of process control parameters in the biochemical methane potential of sunflower oil cake , 2008 .

[12]  B. Ahring,et al.  Volatile fatty acids as indicators of process imbalance in anaerobic digestors , 1995, Applied Microbiology and Biotechnology.

[13]  K. Treanton,et al.  Revised 1996 IPCC guidelines for national greenhouse gas inventories. v. 1: Greenhouse gas inventory reporting instructions.- v. 2: Greenhouse gas inventory workbook.- v.3: Greenhouse gas inventory reference manual , 1997 .

[14]  Gatze Lettinga,et al.  Anaerobic digestion at extreme ammonia concentrations. , 1988 .

[15]  Cristina González-Fernández,et al.  Solids and nutrients removals from the liquid fraction of swine slurry through screening and flocculation treatment and influence of these processes on anaerobic biodegradability. , 2008, Bioresource technology.

[16]  B. Ahring,et al.  Methane productivity of manure, straw and solid fractions of manure , 2004 .

[17]  D. T. Hill,et al.  Methane production from low solid concentration liquid swine waste using conventional anaerobic fermentation , 2000 .

[18]  R. Muñoz,et al.  Efficient nutrient removal from swine manure in a tubular biofilm photo-bioreactor using algae-bacteria consortia. , 2008, Water science and technology : a journal of the International Association on Water Pollution Research.

[19]  L. Neves,et al.  Influence of inoculum activity on the bio-methanization of a kitchen waste under different waste/inoculum ratios , 2004 .