Discrete dislocation simulation of plastic deformation in metal thin films

Abstract The plastic deformation of polycrystalline fcc metal thin films with thicknesses of 1 μm and less is investigated by simulating the dynamics of discrete dislocations in a representative columnar grain. The simulations are based on the assumption that dislocation sources or multiplication sites are rare and that every source has to operate several times to generate appreciable plastic deformation. This model is thoroughly tested by calculating the response of randomly distributed dislocation sources to an applied stress and comparing the results with experimental data. Stress–strain curves, dislocation densities, work hardening rates and their dependence on the film thickness are calculated. The agreement between simulation and experiment is good and many aspects of thin film plasticity can be understood with the assumption that small-scale plastic deformation is source controlled rather than mobility controlled.

[1]  Vikram Deshpande,et al.  Dislocation dynamics is chaotic , 2001 .

[2]  L. Freund.  The Stability of a Dislocation Threading a Strained Layer on a Substrate , 1987 .

[3]  W. Brückner,et al.  Dislocation accumulation and strengthening in Cu thin films , 2001 .

[4]  Howard A. Padmore,et al.  Submicron X-ray diffraction and its applications to problems in materials and environmental science. , 2002 .

[5]  O. Kraft,et al.  Deformation behavior of thin copper films on deformable substrates , 2001 .

[6]  E. Arzt,et al.  Influence of film/substrate interface structure on plasticity in metal thin films , 2001 .

[7]  J. Embury,et al.  On dislocation storage and the mechanical response of fine scale microstructures , 1994 .

[8]  Ladislas P. Kubin,et al.  Dislocation Microstructures and Plastic Flow: A 3D Simulation , 1992 .

[9]  Peter Gumbsch,et al.  Dislocation sources in discrete dislocation simulations of thin-film plasticity and the Hall-Petch relation , 2001 .

[10]  Marc Fivel,et al.  Implementing image stresses in a 3D dislocation simulation , 1996 .

[11]  Huajian Gao,et al.  Constrained diffusional creep in UHV-produced copper thin films , 2001 .

[12]  C. Thompson,et al.  Activation volume for inelastic deformation in polycrystalline Ag thin films , 2000 .

[13]  J. Tersoff,et al.  Interaction of threading and misfit dislocations in a strained epitaxial layer , 1996 .

[14]  John Arthur Simmons,et al.  FUNDAMENTAL ASPECTS OF DISLOCATION THEORY. VOLUME II. Conference Held at Gaithersburg, Maryland, April 21--25, 1969. , 1970 .

[15]  Oliver Kraft,et al.  Interface controlled plasticity in metals: dispersion hardening and thin film deformation , 2001 .

[16]  C. Thompson.  The yield stress of polycrystalline thin films , 1993 .

[17]  L. M. Brown.  A proof of lothe's theorem , 1967 .

[18]  D. Read,et al.  Tensile and fracture behavior of free-standing copper films , 1996 .

[19]  William D. Nix,et al.  Mechanical properties of thin films , 1989 .

[20]  Peter Gumbsch,et al.  Dislocation sources and the flow stress of polycrystalline thin metal films , 2003 .

[21]  M. Murakami,et al.  Low temperature strain behavior of Pb thin films on a substrate , 1982 .

[22]  Richard P. Vinci,et al.  Thermal strain and stress in copper thin films , 1995 .

[23]  G. Schoeck,et al.  The Contribution of the Dislocation Forest to the Flow Stress , 1972 .

[24]  Phillips,et al.  Mesoscopic analysis of structure and strength of dislocation junctions in fcc metals , 2000, Physical review letters.

[25]  D. Rodney,et al.  Structure and Strength of Dislocation Junctions: An Atomic Level Analysis , 1999 .

[26]  William D. Nix,et al.  Yielding and strain hardening of thin metal films on substrates , 1998 .

[27]  K. Schwarz,et al.  Simulation of dislocations on the mesoscopic scale. I. Methods and examples , 1999 .

[28]  Eduard Arzt,et al.  In situ transmission electron microscopy study of dislocations in a polycrystalline Cu thin film constrained by a substrate , 2000 .

[29]  A. J. E. Foreman,et al.  The bowing of a dislocation segment , 1967 .

[30]  K. Schwarz,et al.  Dislocation Dynamics Simulations of Dislocation Interactions in Thin Fcc Metal Films , 2001 .

[31]  E. Arzt,et al.  In situ transmission electron microscopy investigation of threading dislocation motion in passivated thin aluminum films , 1999 .

[32]  A NEW METHOD TO STUDY CYCLIC DEFORMATION OF THIN FILMS IN TENSION AND COMPRESSION , 1999 .

[33]  A. Evans,et al.  Stress evolution in passivated thin films of Cu on silica substrates , 1998 .

[34]  J. Stark,et al.  In situ transmission electron microscopy study of plastic deformation in passivated Al-Cu thin films , 1997 .

[35]  M. Murakami.  Thermal strain in thin lead films III: Dependences of the strain on film thickness and on grain size , 1979 .

[36]  F. Ross,et al.  Modeling of Dislocations in an Epitaxial Island Structure , 2001 .

[37]  L. Kubin,et al.  Dislocation dynamics in confined geometry , 1999 .

[38]  E. Arzt,et al.  Plastic Deformation in Thin Copper Films Determined by X-Ray Micro-Tensile Tests , 1996 .

[39]  D. N. Weiss.  Deformation mechanisms in pure and alloyed copper films , 2000 .

[40]  Eduard Arzt,et al.  Quantitative analysis of strengthening mechanisms in thin Cu films: Effects of film thickness, grain size, and passivation , 1998 .

[41]  J. Bravman,et al.  The effect of laser reflow on the variation of stress with thermal cycling in aluminum thin films , 1991 .

[42]  E. Arzt,et al.  Discrete dislocation sim ulation of thin film plasticit y , 2001 .

[43]  Alexander Hartmaier,et al.  Image stresses in a free-standing thin film , 1999 .

[44]  Ramnath Venkatraman,et al.  Separation of film thickness and grain boundary strengthening effects in Al thin films on Si , 1992 .

[45]  Jens Lothe John Price Hirth,et al.  Theory of Dislocations , 1968 .

[46]  B. Devincre,et al.  MODEL VALIDATION OF A 3D SIMULATION OF DISLOCATION DYNAMICS: DISCRETIZATION AND LINE TENSION EFFECTS , 1992 .

[47]  E. Arzt,et al.  Observation of Dislocation DisAppearance in Aluminum Thin Films and Consequences for Thin Film Properties , 1997 .

[48]  Eduard Arzt,et al.  Thermomechanical behavior of different texture components in Cu thin films , 2001 .

[49]  E. Arzt,et al.  Observations of dislocation motion and stress inhomogeneities in a thin copper film , 2001 .

[50]  Oliver Kraft,et al.  X-ray diffraction as a tool to study the mechanical behaviour of thin films , 2000 .