Thermal hydraulic behavior in the deteriorated turbulent heat transfer regime for a gas-cooled reactor

One of the key issues in a gas-cooled system with a passive heat removal measure is the correct prediction of thermal hydraulic behavior in the deteriorated turbulent heat transfer (DTHT) regime. Here, a simple one-dimensional analysis of a gas-cooled reactor system was performed to show its strong potential for operation in the DTHT regime. A numerical calculation using computational fluid dynamics (CFD) was done to verify the capability of the Launder–Sharma (LS) turbulence model to predict wall and bulk temperatures while a gas system is operating in the DTHT regime. The results by the LS model are compared to those by the high Reynolds turbulent model, a newly proposed correlation, and recently obtained experimental data. The comparison shows that the LS turbulence model can provide a reasonable prediction in the buoyancy-induced DTHT regime. Additionally, it was found that the LS model predicted strong laminarization near the entrance which deteriorated turbulent heat transfer further compared to the measurements, but re-turbulization took place much earlier than in the experiment which recovered the heat transfer to a normal turbulent heat transfer.

[1]  J. Whitelaw,et al.  Convective heat and mass transfer , 1966 .

[2]  M. Kazimi,et al.  Deteriorated turbulent heat transfer (DTHT) of gas up-flow in a circular tube: Experimental data , 2008 .

[3]  Akira Nakayama,et al.  PC-aided numerical heat transfer and convective flow , 1995 .

[4]  J. Laufer,et al.  The Structure of Turbulence in Fully Developed Pipe Flow , 1953 .

[5]  M. Kazimi,et al.  Deteriorated turbulent heat transfer (DTHT) of gas up-flow in a circular tube: Heat transfer correlations , 2008 .

[6]  D. B. Spalding,et al.  Turbulent flow and heat transfer in pipes with buoyancy effects , 1979, Journal of Fluid Mechanics.

[7]  T. Horton.  Influence of differences in thermochemistry data upon high-temperature gas composition , 1971 .

[8]  D. Wilcox.  Turbulence modeling for CFD , 1993 .

[9]  Joel H. Ferziger,et al.  Computational methods for fluid dynamics , 1996 .

[10]  Donald M. McEligot,et al.  Mean structure in the viscous layer of strongly-heated internal gas flows. Measurements , 1998 .

[11]  Jeongik Lee.  Gas heat transfer in a heated vertical channel under deteriorated turbulent heat transfer regime , 2007 .

[12]  A. M. Shehata,et al.  Temperature, velocity and mean turbulence structure in strongly heated internal gas flows: Comparison of numerical predictions with data , 2002 .

[13]  B. Launder,et al.  Application of the energy-dissipation model of turbulence to the calculation of flow near a spinning disc , 1974 .

[14]  P. Poskas,et al.  Local heat transfer in a vertical gas-cooled tube with turbulent mixed convection and different heat fluxes , 1992 .

[15]  P. Roache.  Perspective: A Method for Uniform Reporting of Grid Refinement Studies , 1994 .

[16]  Mujid S. Kazimi,et al.  Studies of the Deteriorated Turbulent Heat Transfer Regime for the Gas-Cooled Fast Reactor Decay Heat Removal System , 2007 .

[17]  M. Connor,et al.  Velocity, Temperature, and Turbulence Measurements in Air for Pipe Flow With Combined Free and Forced Convection , 1973 .

[18]  Xavier Ficquet,et al.  International Congress on Advances in Nuclear Power Plants (ICAPP) , 2011 .

[19]  V. Gnielinski.  New equations for heat and mass transfer in turbulent pipe and channel flow , 1976 .

[20]  S. Patankar.  Numerical Heat Transfer and Fluid Flow , 2018, Lecture Notes in Mechanical Engineering.

[21]  Haecheon Choi,et al.  Direct numerical simulation of heated vertical air flows in fully developed turbulent mixed convection , 2003 .

[22]  W. Jones,et al.  The prediction of laminarization with a two-equation model of turbulence , 1972 .

[23]  Donald M. McEligot,et al.  Relaminarization in tubes , 1970 .

[24]  John Derek Jackson,et al.  Vertical tube air flows in the turbulent mixed convection regime calculated using a low-Reynolds-number k ~ ϵ model , 1990 .

[25]  M. Driscoll,et al.  Thermal Hydraulic Challenges of Gas Cooled Fast Reactors with Passive Safety Features , 2009 .

[26]  B. Launder,et al.  The numerical computation of turbulent flows , 1990 .

[27]  Donald M. McEligot,et al.  “Deterioration” criteria for convective heat transfer in gas flow through non-circular ducts , 2004 .

[28]  Mark Cotton,et al.  A variant of the low-Reynolds-number two-equation turbulence model applied to variable property mixed convection flows. , 1995 .

[29]  Shuisheng He,et al.  Assessment by comparison with DNS data of turbulence models used in simulations of mixed convection , 2008 .

[30]  A. Polyakov,et al.  Development of turbulent heat transfer over the length of vertical tubes in the presence of mixed air convection , 1988 .

[31]  Brian Axcell,et al.  STUDIES OF MIXED CONVECTION IN VERTICAL TUBES , 1989 .

[32]  C F Colebrook,et al.  TURBULENT FLOW IN PIPES, WITH PARTICULAR REFERENCE TO THE TRANSITION REGION BETWEEN THE SMOOTH AND ROUGH PIPE LAWS. , 1939 .

[33]  U. S. Doe.  A Technology Roadmap for Generation IV Nuclear Energy Systems , 2002 .

[34]  W. Jones,et al.  The calculation of low-Reynolds-number phenomena with a two-equation model of turbulence , 1973 .

[35]  V. C. Patel,et al.  Turbulence models for near-wall and low Reynolds number flows - A review , 1985 .

[36]  B. Launder,et al.  Lectures in mathematical models of turbulence , 1972 .

[37]  Tanaka Hiroaki,et al.  Combined forced and natural convection heat transfer for upward flow in a uniformly heated, vertical pipe , 1987 .

[38]  C. A. Bankston.  The Transition From Turbulent to Laminar Gas Flow in a Heated Pipe , 1970 .

[39]  Robert E. Spall,et al.  AN ASSESSMENT OF k–ω AND v 2–f TURBULENCE MODELS FOR STRONGLY HEATED INTERNAL GAS FLOWS , 2004 .

[40]  A. F. Poli︠a︡kov,et al.  Heat transfer in turbulent mixed convection , 1988 .

[41]  A. Steiner.  On the reverse transition of a turbulent flow under the action of buoyancy forces , 1971, Journal of Fluid Mechanics.