Extractive-transesterification of algal lipids under microwave irradiation with hexane as solvent.

This study describes the use of microwaves (MW) for enhanced extractive-transesterification of algal lipids from dry algal biomass (Chlorella sp.). Two different single-step extractive-transesterification methods under MW irradiation were evaluated: (1) with ethanol as solvent/reactant and sodium hydroxide catalyst; and (2) with ethanol as reactant and hexane as solvent (sodium hydroxide catalyst). Biodiesel (fatty-acid-ethyl-esters, FAEE) yields from these two methods were compared with the conventional Bligh and Dyer (BD) method which followed a two-step extraction-transesterification process. The maximum lipid yields for MW, MW with hexane and BD methods were 20.1%, 20.1%, and 13.9%, respectively; while the FAEE conversion of the algal lipids were 96.2%, 94.3%, and 78.1%, respectively. The algae-biomass:ethanol molar ratio of 1:250-500 and 2.0-2.5% catalyst with reaction times around 6min were determined as optimum conditions for both methods. This study confers that the single-step non-conventional methods can contribute to higher algal lipid and FAEE yields.

[1]  H. Oh,et al.  Comparison of several methods for effective lipid extraction from microalgae. , 2010, Bioresource technology.

[2]  Michael J. Haas,et al.  In situ alkaline transesterification: An effective method for the production of fatty acid esters from vegetable oils , 2004 .

[3]  Z. Wen,et al.  Production of Biodiesel Fuel from the Microalga Schizochytrium limacinum by Direct Transesterification of Algal Biomass , 2009 .

[4]  A. Macedo,et al.  A one-pot glycerol-based additive-blended ethyl biodiesel production: a green process. , 2013, Bioresource technology.

[5]  Wei Zhang,et al.  Biodiesel production from algae oil high in free fatty acids by two-step catalytic conversion. , 2012, Bioresource technology.

[6]  Yongli Mi,et al.  Simplifying the Process of Microalgal Biodiesel Production Through In Situ Transesterification Technology , 2011 .

[7]  Shuguang Deng,et al.  Biodiesel production from low cost and renewable feedstock , 2013 .

[8]  Adam Harvey,et al.  Alkaline in situ transesterification of Chlorella vulgaris , 2012 .

[9]  V. Gude,et al.  Optimization of direct conversion of wet algae to biodiesel under supercritical methanol conditions. , 2011, Bioresource technology.

[10]  C. Carrington,et al.  Variables affecting the in situ transesterification of microalgae lipids , 2010 .

[11]  W. J. Dyer,et al.  A rapid method of total lipid extraction and purification. , 1959, Canadian journal of biochemistry and physiology.

[12]  Rafael Hernandez,et al.  Biodiesel production by in situ transesterification of municipal primary and secondary sludges. , 2009, Bioresource technology.

[13]  Y. Chisti.  Biodiesel from microalgae. , 2007, Biotechnology advances.

[14]  D. Boocock,et al.  Fast formation of high-purity methyl esters from vegetable oils , 1998 .

[15]  Y. Ju,et al.  Biodiesel production from rice bran by a two-step in-situ process. , 2010, Bioresource technology.

[16]  Nagamany Nirmalakhandan,et al.  Microwave energy potential for biodiesel production , 2013 .

[17]  Devanand L. Luthria,et al.  Optimization of an Oil Extraction Process for Algae from the Treatment of Manure Effluent , 2009 .

[18]  R. Maceiras,et al.  Influence of n -Hexane on in Situ Transesterification of Marine Macroalgae , 2012 .

[19]  Michael J. Haas,et al.  Simplifying biodiesel production: The direct or in situ transesterification of algal biomass , 2011 .

[20]  S. Papanikolaou,et al.  Lipid synthesized by micro‐algae grown in laboratory‐ and industrial‐scale bioreactors , 2011 .

[21]  Penglin Li,et al.  In Situ Biodiesel Production from Fast-Growing and High Oil Content Chlorella pyrenoidosa in Rice Straw Hydrolysate , 2011, Journal of biomedicine & biotechnology.

[22]  A. A. Refaat,et al.  Different techniques for the production of biodiesel from waste vegetable oil , 2010 .

[23]  Ayhan Demirbas,et al.  Production of biodiesel fuels from linseed oil using methanol and ethanol in non-catalytic SCF conditions , 2009 .

[24]  G. Knothe.  Dependence of biodiesel fuel properties on the structure of fatty acid alkyl esters , 2005 .

[25]  G. Aggelis,et al.  Biochemical activities in Chlorella sp. and Nannochloropsis salina during lipid and sugar synthesis in a lab-scale open pond simulating reactor. , 2013, Journal of biotechnology.

[26]  G. Araújo,et al.  Extraction of lipids from microalgae by ultrasound application: prospection of the optimal extraction method. , 2013, Ultrasonics sonochemistry.

[27]  Michele Aresta,et al.  Production of biodiesel from macroalgae by supercritical CO2 extraction and thermochemical liquefaction , 2005 .

[28]  Fei Wang,et al.  In situ alkaline transesterification of cottonseed oil for production of biodiesel and nontoxic cottonseed meal. , 2008, Bioresource technology.