Thermochromic smart window technologies for building application: A review

Abstract Thermochromic window technologies promise pioneering architectural windows with energy-saving capabilities through the intelligent regulation of indoor solar irradiation and modulation of window optical properties in response to real-time temperature. Thermochromic glazing has been thoroughly advanced from a materials perspective, with many kinds of thermochromic coating techniques developed thus far, however, a far smaller body of work exists to investigate how these kinds of glazing would perform within buildings. This paper presents a systematic review of these thermochromic films, coatings and glazings that have been used to analyse primarily energy saving capability in buildings, using computer simulation as well as full-scale models. Research from 2009 to 2019 was obtained from architecture and engineering databases, identifying window types modelled, energy savings found, and comfort analyses conducted. Thermochromic windows were reported to have the potential to save heating and cooling energy demand from 5.0 to 84.7%, in comparison to plain glass and dependent on climatic conditions. Differences in energy saving capability were analysed based on location and glazing type. Thermochromic window energy performance was found to vary significantly between different cities using the same film type (up to 73.4%), but far less so between different films types used in the same city (up to 21.6%). Few studies were shown to have explored thermochromic windows from a visual and thermal comfort performance perspective. This paper highlights areas of guidance for future studies of thermochromic glazing for energy-efficient building applications to better forecast energy saving performance of thermochromic windows for real building application.

[1]  Xiao Hu,et al.  Temperature-responsive hydrogel with ultra-large solar modulation and high luminous transmission for “smart window” applications , 2014 .

[2]  Gunnar A. Niklasson,et al.  Thermochromic VO2‐based multilayer films with enhanced luminous transmittance and solar modulation , 2009 .

[3]  Dong Li,et al.  Experimental investigation of optical and thermal performance of a PCM-glazed unit for building applications , 2018 .

[4]  Ibrahim Abdulhalim,et al.  Vanadium dioxide nanogrid films for high transparency smart architectural window applications. , 2015, Optics express.

[5]  Robin Wilson,et al.  A Review of Transparent Insulation Material (TIM) for building energy saving and daylight comfort , 2018, Applied Energy.

[6]  Stephen Wittkopf,et al.  Accordance of Light Scattering from Design and De-Facto Variants of a Daylight Redirecting Component , 2016 .

[7]  Hong Ye,et al.  The demonstration and simulation of the application performance of the vanadium dioxide single glazing , 2013 .

[8]  Zongtao Zhang,et al.  Nanoceramic VO2 thermochromic smart glass: A review on progress in solution processing , 2012 .

[9]  Hong Ye,et al.  Performance demonstration and evaluation of the synergetic application of vanadium dioxide glazing and phase change material in passive buildings , 2014 .

[10]  Wang Ning,et al.  Formation of VO2 zero-dimensional/nanoporous layers with large supercooling effects and enhanced thermochromic properties , 2013 .

[11]  Italo Meroni,et al.  Energy efficiency of a dynamic glazing system , 2010 .

[12]  Bin Li,et al.  Tungsten doped M-phase VO2 mesoporous nanocrystals with enhanced comprehensive thermochromic properties for smart windows , 2019, Ceramics International.

[13]  Claes-Göran Granqvist,et al.  Thermochromic vanadium oxide thin films: Electronic and optical properties , 2014 .

[14]  Ning Wang,et al.  Multifunctional overcoats on vanadium dioxide thermochromic thin films with enhanced luminous transmission and solar modulation, hydrophobicity and anti-oxidation , 2013 .

[15]  Michael E. A. Warwick,et al.  The effect of variation in the transition hysteresis width and gradient in thermochromic glazing systems , 2015 .

[16]  Muhammad Aslam Uqaili,et al.  Simulation tools application for artificial lighting in buildings , 2018 .

[17]  Xiao Hu,et al.  VO2/hydrogel hybrid nanothermochromic material with ultra-high solar modulation and luminous transmission , 2015 .

[18]  Gang Xu,et al.  A VO2-Based Multifunctional Window with Highly Improved Luminous Transmittance , 2002 .

[19]  Ivan P. Parkin,et al.  Doped and un-doped vanadium dioxide thin films prepared by atmospheric pressure chemical vapour deposition from vanadyl acetylacetonate and tungsten hexachloride: the effects of thickness and crystallographic orientation on thermochromic properties , 2007 .

[20]  Robin Wilson,et al.  Evaluation of the thermal and optical performance of thermochromic windows for office buildings in China , 2018, Energy and Buildings.

[21]  Tianzhen Hong,et al.  Building simulation: an overview of developments and information sources , 2000 .

[22]  Chor Yong Tay,et al.  Index-tunable anti-reflection coatings: Maximizing solar modulation ability for vanadium dioxide-based smart thermochromic glazing , 2018 .

[23]  John Mardaljevic,et al.  Useful daylight illuminance: a new paradigm for assessing daylight in buildings , 2005 .

[24]  Hong Ye,et al.  Theoretical discussions of perfect window, ideal near infrared solar spectrum regulating window and current thermochromic window , 2012 .

[25]  Yu Lei,et al.  Design and development of a reflective membrane for a novel Building Integrated Concentrating Photovoltaic (BICPV) ‘Smart Window’ system , 2016 .

[26]  Vladimir I Minkin,et al.  Photo-, thermo-, solvato-, and electrochromic spiroheterocyclic compounds. , 2004, Chemical reviews.

[27]  Cheng Xu,et al.  Sunlight‐Driven Photo‐Thermochromic Smart Windows , 2018 .

[28]  Michael E. A. Warwick,et al.  Variation of Thermochromic Glazing Systems Transition Temperature, Hysteresis Gradient and Width Effect on Energy Efficiency , 2016 .

[29]  Sabine Hoffmann,et al.  An empirical study of a full-scale polymer thermochromic window and its implications on material science development objectives , 2013 .

[30]  Arild Gustavsen,et al.  Fenestration of Today and Tomorrow: A State-of-the-Art Review and Future Research Opportunities , 2013 .

[31]  Sabine Hoffmann,et al.  Examination of the technical potential of near-infrared switching thermochromic windows for commercial building applications , 2014 .

[32]  R. O. Ocaya,et al.  Electrical, optical and structural properties of pure and gold-coated VO2 thin films on quartz substrate , 2010 .

[33]  Gang Xu,et al.  Design, formation and characterization of a novel multifunctional window with VO2 and TiO2 coatings , 2003 .

[34]  Yanfeng Gao,et al.  Thermochromic VO2 thin films: solution-based processing, improved optical properties, and lowered phase transformation temperature. , 2010, Langmuir : the ACS journal of surfaces and colloids.

[35]  Ivan P. Parkin,et al.  Atmospheric pressure chemical vapour deposition of thermochromic tungsten doped vanadium dioxide thin films for use in architectural glazing , 2009 .

[36]  Claes G. Granqvist.  Smart windows and intelligent glass façades , 2002 .

[37]  Claes-Göran Granqvist,et al.  Thermochromic Oxide-Based Thin Films and Nanoparticle Composites for Energy-Efficient Glazings , 2016 .

[38]  Hong Ye,et al.  The energy saving index and the performance evaluation of thermochromic windows in passive buildings , 2014 .

[39]  Lin Yao,et al.  Surface and interface engineering for VO2 coatings with excellent optical performance: From theory to practice , 2019, Materials Research Bulletin.

[40]  Ivan P. Parkin,et al.  Nano-composite thermochromic thin films and their application in energy-efficient glazing , 2010 .

[41]  Michael E. A. Warwick,et al.  Advances in thermochromic vanadium dioxide films , 2014 .

[42]  Huiqun Zhu,et al.  Microstructures and thermochromic characteristics of low-cost vanadium–tungsten co-sputtered thin films , 2012 .

[43]  Ping Jin,et al.  Highly Enhanced Thermochromic Performance of VO2 Film Using "Movable" Antireflective Coatings. , 2019, ACS applied materials & interfaces.

[44]  Rene Lopez,et al.  Designing Plasmon‐Enhanced Thermochromic Films Using a Vanadium Dioxide Nanoparticle Elastomeric Composite , 2016 .

[45]  Concettina Marino,et al.  Energy performance of an electrochromic switchable glazing: Experimental and computational assessments , 2017 .

[46]  Jongbeom Na,et al.  Energy saving electrochromic windows from bistable low-HOMO level conjugated polymers , 2016 .

[47]  Georgios Kokogiannakis,et al.  Simulating thermochromic and heat mirror glazing systems in hot and cold climates , 2014 .

[48]  Paolo Principi,et al.  Thermal Conductivity of Clay Bricks , 2004 .

[49]  Kaufui Wong,et al.  Smart glass and its potential in energy savings , 2014 .

[50]  Sung-Hwan Bae,et al.  The Effect of CeO2 Antireflection Layer on the Optical Properties of Thermochromic VO2 Film for Smart Window System , 2014, Journal of Materials Engineering and Performance.

[51]  Rangika Halwatura,et al.  Effect of building shape, orientation, window to wall ratios and zones on energy efficiency and thermal comfort of naturally ventilated houses in tropical climate , 2019, International Journal of Energy and Environmental Engineering.

[52]  Francesco Martellotta,et al.  Energy savings due to building integration of innovative solid-state electrochromic devices , 2018, Applied Energy.

[53]  Yang Zhou,et al.  Vanadium dioxide for energy conservation and energy storage applications: Synthesis and performance improvement , 2018 .

[54]  Michael E. A. Warwick,et al.  The effect of transition gradient in thermochromic glazing systems , 2014 .

[55]  George A. Sawatzky,et al.  The metal-non-metal transition in VO2: X-ray photoemission and resistivity measurements , 1975 .

[56]  Nicholas DeForest,et al.  A comparative energy analysis of three electrochromic glazing technologies in commercial and residential buildings , 2017 .

[57]  F. J. Morin,et al.  Oxides Which Show a Metal-to-Insulator Transition at the Neel Temperature , 1959 .

[58]  Robin Wilson,et al.  Development of experimental methods for quantifying the human response to chromatic glazing , 2019, Building and Environment.

[59]  Xu Xiaojie,et al.  Simulation and improvement of energy consumption on intelligent glasses in typical cities of China , 2012 .

[60]  Gunnar A. Niklasson,et al.  Thermochromic VO2 Films for Energy-Efficient Windows , 1987, Optics & Photonics.

[61]  Ping Jin,et al.  Vanadium Dioxide Nanoparticle-based Thermochromic Smart Coating: High Luminous Transmittance, Excellent Solar Regulation Efficiency, and Near Room Temperature Phase Transition. , 2015, ACS applied materials & interfaces.

[62]  Ivan P. Parkin,et al.  Intelligent thermochromic windows , 2006 .

[63]  Luigi Marletta,et al.  Thermal and visual performance of real and theoretical thermochromic glazing solutions for office buildings , 2016 .

[64]  Shlomo Magdassi,et al.  Ionic strength induced electrodeposition: a universal approach for nanomaterial deposition at selective areas. , 2017, Nanoscale.

[65]  Jan Hensen,et al.  Integrated building performance simulation: Progress, prospects and requirements , 2015 .

[66]  Michael E. A. Warwick,et al.  Thermochromic vanadium dioxide thin films prepared by electric field assisted atmospheric pressure chemical vapour deposition for intelligent glazing application and their energy demand reduction properties , 2016 .

[67]  J. C. Lam,et al.  An analysis of daylighting and solar heat for cooling-dominated office buildings , 1999 .

[68]  Yanfeng Gao,et al.  Pure Single-Crystal Rutile Vanadium Dioxide Powders: Synthesis, Mechanism and Phase-Transformation Property , 2008 .

[69]  Hong Ye,et al.  How to be smart and energy efficient: A general discussion on thermochromic windows , 2014, Scientific Reports.

[70]  J. Rezek,et al.  Significant improvement of the performance of ZrO2/V1-W O2/ZrO2 thermochromic coatings by utilizing a second-order interference , 2019, Solar Energy Materials and Solar Cells.

[71]  Hong Ye,et al.  Smart or not? A theoretical discussion on the smart regulation capacity of vanadium dioxide glazing , 2014 .

[72]  Yang Zhou,et al.  Tungsten doped VO2/microgels hybrid thermochromic material and its smart window application , 2017 .

[73]  Ivan P. Parkin,et al.  Hybrid Aerosol Assisted Atmospheric Pressure Chemical Vapour Deposition: A Facile Route Toward Nano-Composite Thin Films? , 2009 .

[74]  Ping Jin,et al.  Review on thermochromic vanadium dioxide based smart coatings: from lab to commercial application , 2018, Advances in Manufacturing.

[75]  Ping Jin,et al.  Recent advances in VO2-based thermochromic composites for smart windows , 2018 .

[76]  Yang Wang,et al.  Switchable Materials for Smart Windows. , 2016, Annual review of chemical and biomolecular engineering.

[77]  Hong Ye,et al.  Nano-based chromogenic technologies for building energy efficiency , 2016 .

[78]  Ning Wang,et al.  Nanoporous thermochromic VO₂ (M) thin films: controlled porosity, largely enhanced luminous transmittance and solar modulating ability. , 2014, Langmuir : the ACS journal of surfaces and colloids.

[79]  A. Synnefa,et al.  Development and testing of thermochromic coatings for buildings and urban structures , 2009 .

[80]  Armando C. Oliveira,et al.  Effect of louver shading devices on building energy requirements , 2010 .

[81]  John Chilton,et al.  Optical aspects and energy performance of switchable ethylene-tetrafluoroethylene (ETFE) foil cushions , 2018, Applied Energy.

[82]  Brian Norton,et al.  Behaviour of a SPD switchable glazing in an outdoor test cell with heat removal under varying weather conditions , 2016 .

[83]  Hong Ye,et al.  Discussion of the performance improvement of thermochromic smart glazing applied in passive buildings , 2014 .

[84]  S. Magdassi,et al.  VO₂/Si-Al gel nanocomposite thermochromic smart foils: largely enhanced luminous transmittance and solar modulation. , 2014, Journal of colloid and interface science.

[85]  Hong Ye,et al.  Dual-intelligent windows regulating both solar and long-wave radiations dynamically , 2017 .

[86]  Ning Wang,et al.  Periodic micro-patterned VO2 thermochromic films by mesh printing , 2016 .

[87]  Runqi Liang.  Development of an adaptive façade for visual comfort, daylight and thermal control element , 2018 .

[88]  Elvira Fortunato,et al.  Smart optically active VO2 nanostructured layers applied in roof-type ceramic tiles for energy efficiency , 2016 .

[89]  Ning Wang,et al.  Thermochromic VO2 for Energy-Efficient Smart Windows , 2018, Joule.

[90]  Claes-Göran Granqvist,et al.  Thermochromics for Energy Efficient Buildings: Thin Surface Coatings and Nanoparticle Composites , 2016 .

[91]  Zhiqiang Zhai,et al.  Advances in building simulation and computational techniques: A review between 1987 and 2014 , 2016 .

[92]  Hui Yang,et al.  Preparation of thermochromic coatings and their energy saving analysis , 2015 .

[93]  Christian Koch,et al.  Building information modelling based building energy modelling: A review , 2019, Applied Energy.

[94]  Ping Jin,et al.  Hybrid films of VO2 nanoparticles and a nickel(II)-based ligand exchange thermochromic system: excellent optical performance with a temperature responsive colour change , 2017 .

[95]  Claes-Göran Granqvist,et al.  Nanothermochromics: Calculations for VO2 nanoparticles in dielectric hosts show much improved luminous transmittance and solar energy transmittance modulation , 2010 .

[96]  Gunnar A. Niklasson,et al.  Progress in chromogenics: New results for electrochromic and thermochromic materials and devices , 2009 .

[97]  Michael E. A. Warwick,et al.  The Effect of Transition Hysteresis Width in Thermochromic Glazing Systems , 2013 .

[98]  Francesco Goia,et al.  Advanced transparent facades: market available products and associated challenges in building performance simulation , 2017 .

[99]  Fabio Sciurpi,et al.  The Energy Upgrading of Existing Buildings: Window and Shading Device Typologies for Energy Efficiency Refurbishment , 2014 .

[100]  Ivan P. Parkin,et al.  Energy modelling studies of thermochromic glazing , 2010 .

[101]  Svend Svendsen,et al.  Impact of façade window design on energy, daylighting and thermal comfort in nearly zero-energy houses , 2015 .

[102]  Dongyuan Zhao,et al.  Controllable Fabrication of Two-Dimensional Patterned VO2 Nanoparticle, Nanodome, and Nanonet Arrays with Tunable Temperature-Dependent Localized Surface Plasmon Resonance. , 2017, ACS nano.

[103]  Robin Wilson,et al.  An exploration of the combined effects of NIR and VIS spectrally selective thermochromic materials on building performance , 2019, Energy and Buildings.

[104]  Hong Ye,et al.  Performance analyses of building energy on phase transition processes of VO2 windows with an improved model , 2015 .

[105]  Marco Casini,et al.  Active dynamic windows for buildings: A review , 2018 .

[106]  Hong Ye,et al.  Performance demonstration and simulation of thermochromic double glazing in building applications , 2015 .

[107]  Ana Paula Melo,et al.  The effect of window opening ventilation control on residential building energy consumption , 2016 .