Review of hydrodynamics instabilities in Francis turbine during off-design and transient operations

Electricity generation from solar and wind has raised a significant concern about the stability of grid networks. Hydroelectricity plays an important role to balance the stability of grid network. In order to improve the stability of presently high loaded grids, hydropower plants are being operated over a wide range of operations and experiencing frequent start-stop, load variation, and emergency shutdown. The power generating unit including turbine needs to sustain sudden change in its operating condition to balance the grid frequency. The objective of this paper is to present the operating problems of Francis turbine in the present energy generation scenario. The turbine suffers from several dynamic instabilities during off-design and transient operations. Several low and high-frequency pressure fluctuations are observed during both, steady state and transient operating conditions. The off-design operations such as part load and high load cause pressure fluctuations due to RSI, RVR and cavitation. The transient operations lead to heavy cyclic loading of its moving and stationary parts. Francis turbine also experiences asymmetric loading on the runner, cyclic stress, wear and tear; all of which reduce operating life of the components. Sometimes these rapid transient may cause failure of the unit and decouple it from the system.

[1]  Wenxin Huai,et al.  Analysis of pressure oscillations in a Francis hydraulic turbine with misaligned guide vanes , 2010 .

[2]  Chirag Trivedi,et al.  Investigation of a High Head Francis Turbine at Runaway Operating Conditions , 2016 .

[3]  Nicholas C. Davy,et al.  Contorted Hexabenzocoronenes with Extended Heterocyclic Moieties Improve Visible-Light Absorption and Performance in Organic Solar Cells , 2016 .

[4]  Ole Gunnar Dahlhaug,et al.  Empirical modelling of sediment erosion in Francis turbines , 2012 .

[5]  Torbjørn K. Nielsen,et al.  Francis-99 Workshop 1 : steady operation of Francis turbines , 2015 .

[6]  Young-Ho Lee,et al.  Transient numerical analysis of rotor–stator interaction in a Francis turbine , 2014 .

[7]  Mirjam Sick,et al.  Thirty years of numerical flow simulation in hydraulic turbomachines , 2008 .

[8]  Ole Gunnar Dahlhaug,et al.  Experimental investigation on a high head model Francis turbine during load rejection , 2016 .

[9]  Ole Gunnar Dahlhaug,et al.  Transient Pressure Measurements on a High Head Model Francis Turbine During Emergency Shutdown, Total Load Rejection, and Runaway , 2014 .

[10]  Ole Gunnar Dahlhaug,et al.  Experimental and Numerical Studies for a High Head Francis Turbine at Several Operating Points , 2013 .

[11]  François Avellan,et al.  Unstable Operation of Francis Pump-Turbine at Runaway: Rigid and Elastic Water Column Oscillation Modes , 2008 .

[12]  Bernd Nennemann,et al.  Challenges in Dynamic Pressure and Stress Predictions at No-Load Operation in Hydraulic Turbines , 2014 .

[13]  Peter Dörfler,et al.  Flow-Induced Pulsation and Vibration in Hydroelectric Machinery: Engineer’s Guidebook for Planning, Design and Troubleshooting , 2012 .

[14]  Susanne B. Jones,et al.  Hydrothermal liquefaction of biomass: developments from batch to continuous process. , 2015, Bioresource technology.

[15]  Xin Lin,et al.  Pairing of near-ultraviolet solar cells with electrochromic windows for smart management of the solar spectrum , 2017, Nature Energy.

[16]  Ingunn Saur Modahl,et al.  The life-cycle water footprint of two hydropower projects in Norway , 2016 .

[17]  Anton Bergant,et al.  Simulation of unsteady flow and runner rotation during shut-down of an axial water turbine , 2006 .

[18]  Paolo Pennacchi,et al.  Modeling of the dynamic response of a Francis turbine , 2012 .

[19]  Daniel Marjavaara.  CFD driven optimization of hydraulic turbine draft tubes using surrogate models , 2006 .

[20]  Sebastian Muntean,et al.  Failure analysis of a Francis turbine runner , 2010 .

[21]  Christophe Nicolet,et al.  Stability Study of Francis Pump-Turbine at Runaway , 2009 .

[22]  S Liu,et al.  Runaway transient simulation of a model Kaplan turbine , 2010 .

[23]  Einar Kobro.  Measurement of Pressure Pulsations in Francis Turbines , 2010 .

[24]  Chirag Trivedi,et al.  Experimental and Numerical Studies of a High-Head Francis Turbine: A Review of the Francis-99 Test Case , 2016 .

[25]  S. L. Dixon,et al.  Fluid mechanics, thermodynamics of turbomachinery , 1966 .

[26]  T. Zhu,et al.  Phonons, Localization, and Thermal Conductivity of Diamond Nanothreads and Amorphous Graphene. , 2016, Nano letters.

[27]  Gabriel Dan Ciocan,et al.  Experimental analysis of the swirling flow in a Francis turbine draft tube: Focus on radial velocity component determination , 2010 .

[28]  Michel Cervantes,et al.  Numerical Simulation and Validation of a High Head Model Francis Turbine at Part Load Operating Condition , 2018 .

[29]  Liang Zhang,et al.  Simulations of unsteady cavitating turbulent flow in a Francis turbine using the RANS method and the improved mixture model of two-phase flows , 2011, Engineering with Computers.

[30]  X Huang,et al.  Static and dynamic stress analyses of the prototype high head Francis runner based on site measurement , 2014 .

[31]  Elif Ertekin,et al.  Resolving anomalous strain effects on two-dimensional phonon flows: The cases of graphene, boron nitride, and planar superlattices , 2015 .

[32]  Alf Gunnar Backman,et al.  CFD Validation of Pressure Fluctuations in a Pump Turbine , 2008 .

[33]  P. Karnøe,et al.  System and market integration of wind power in Denmark , 2013 .

[34]  Michel Cervantes,et al.  PIV measurements in Francis turbine – A review and application to transient operations , 2018 .

[35]  Ole Gunnar Dahlhaug,et al.  Experimental investigations of a model Francis turbine during shutdown at synchronous speed , 2015 .

[36]  Elif Ertekin,et al.  Phonon transport on two-dimensional graphene/boron nitride superlattices , 2014 .

[37]  Manfred Sallaberger,et al.  Starting pump-turbines with unstable characteristics , 2010 .

[38]  Mohamed Farhat,et al.  Pump-Turbine Rotor-Stator Interactions in Generating Mode: Pressure Fluctuation in Distributor Channel , 2006 .

[39]  Hari Prasad Neopane,et al.  A methodology for designing Francis runner blade to find minimum sediment erosion using CFD , 2016 .

[40]  Michel Cervantes,et al.  Transient pressure measurements at part load operating condition of a high head model Francis turbine , 2016 .

[41]  Øyvind Antonsen,et al.  Unsteady flow in wicket gate and runner with focus on static and dynamic load on runner , 2007 .

[42]  David Jarry-Bolduc,et al.  Hydro energy generation and instrumentation & measurement: hydropower plant efficiency testing , 2014, IEEE Instrumentation & Measurement Magazine.

[43]  Chirag Trivedi,et al.  Experimental investigations of transient pressure variations in a high head model Francis turbine during start-up and shutdown , 2014 .

[44]  Bartłomiej Igliński,et al.  Wind energy in Poland – History, current state, surveys, Renewable Energy Sources Act, SWOT analysis , 2016 .

[45]  François Avellan,et al.  High-speed flow visualization in a pump-turbine under off-design operating conditions , 2010 .

[46]  Helena M. Ramos,et al.  Dynamic orifice model on waterhammer analysis of high or medium heads of small hydropower schemes , 2001 .

[47]  Thomas Staubli,et al.  Unstable Characteristics and Rotating Stall in Turbine Brake Operation of Pump-Turbines , 2011 .

[48]  Shuhong Liu,et al.  Experimental Investigation on the Characteristics of Hydrodynamic Stabilities in Francis Hydroturbine Models , 2014 .

[49]  Ruofu Xiao,et al.  Dynamic stresses in a francis turbine runner based on fluid-structure interaction analysis , 2008 .

[50]  Roberto Parra,et al.  Renewable energy research progress in Mexico: A review , 2014 .

[51]  J Nicolle,et al.  Transient CFD simulation of a Francis turbine startup , 2012 .

[52]  R. P. Saini,et al.  A review on silt erosion in hydro turbines , 2008 .

[53]  Helena M. Ramos,et al.  Parametric Analysis of Water-Hammer Effects in Small Hydro Schemes , 2002 .

[54]  A. N. Andersen,et al.  Market integration of wind power in electricity system balancing , 2013 .

[55]  N Ruchonnet,et al.  Fatigue analyses of the prototype Francis runners based on site measurements and simulations , 2014 .

[56]  T. Gjengedal.  Integration of wind power and the impact on power system operation , 2003, Large Engineering Systems Conference on Power Engineering, 2003.

[57]  Rahul Goyal,et al.  Vortex Rope Formation in a High Head Model Francis Turbine , 2017 .

[58]  A. Lyutov,et al.  Modelling of a Francis Turbine Runner Fatigue Failure Process Caused by Fluid-Structure Interaction , 2016 .

[59]  Michel J. Cervantes,et al.  Pressure measurements on a high-head Francis turbine during load acceptance and rejection , 2014 .

[60]  Ole Gunnar Dahlhaug,et al.  Study of the simultaneous effects of secondary flow and sediment erosion in Francis turbines , 2016 .

[61]  Roger Bérubé.  Maintaining Power Grid Reliability Through Individual Unit Stability , 2008 .

[62]  M J Cervantes,et al.  Turbine-99 unsteady simulations - Validation , 2010 .

[63]  F. Avellan,et al.  Experimental Study and Numerical Simulation of the Flindt Draft Tube Rotating Vortex , 2007 .

[64]  Christophe Nicolet,et al.  Hydroacoustic modelling and numerical simulation of unsteady operation of hydroelectric systems , 2007 .

[65]  F. Avellan,et al.  Analysis of the Cavitating Draft Tube Vortex in a Francis Turbine Using Particle Image Velocimetry Measurements in Two-Phase Flow , 2008 .

[66]  Yasir Dawood Siwani.  Dynamic stress assessment in high head Francis runners , 2008 .

[67]  A. A. Sotnikov,et al.  Problems of creating high-capacity hydraulic turbines , 1994 .

[68]  Bhupendra K. Gandhi,et al.  Effect of transients on Francis turbine runner life: a review , 2013 .

[69]  Hugh Byrd,et al.  Blackouts: a sociology of electrical power failure , 2013 .

[70]  Ole Gunnar Dahlhaug,et al.  Experimental Investigation of a High Head Model Francis Turbine During Steady-State Operation at Off-Design Conditions , 2016 .