Modeling and Analysis of Coupled Inductors in Power Converters

This paper describes a new approach to the analysis of switched mode power converters utilizing coupled inductors and presents a novel canonical circuit model for N-winding coupled inductors. Waveform and ripple of the winding current in a coupled inductor converter can be easily determined using the developed model similar to those obtained in an uncoupled inductor converter. Influence of coupling coefficient on converter steady state and transient performances is readily predicted by the proposed model and a comparison of coupled and uncoupled inductor converters is provided. It is found that coupling among windings effectively alters the phase node voltage waveforms driving the coupled inductors. Through coupling, a converter is capable of responding faster to load transient depending on the coupling coefficient and control mechanism, and this dependency is analytically revealed in the paper. Some design constraints regarding coupling coefficient are also discussed for two-winding and multi-winding coupled inductors in power converter applications. Finally, a two-phase buck regulator is experimentally tested to verify the proposed model.

[1]  P.-L. Wong,et al.  A novel modeling concept for multi-coupling core structures , 2001, APEC 2001. Sixteenth Annual IEEE Applied Power Electronics Conference and Exposition (Cat. No.01CH37181).

[2]  H. Visairo,et al.  DC-DC transformer multiphase converter with transformer coupling for two-stage architecture , 2010, 2010 Twenty-Fifth Annual IEEE Applied Power Electronics Conference and Exposition (APEC).

[3]  Wenkai Wu,et al.  Multi-phase buck converter design with two-phase coupled inductors , 2006, Twenty-First Annual IEEE Applied Power Electronics Conference and Exposition, 2006. APEC '06..

[4]  Robert W. Erickson,et al.  Modeling of cross-regulation in converters containing coupled inductors , 1998, APEC '98 Thirteenth Annual Applied Power Electronics Conference and Exposition.

[5]  H.-W. Lee,et al.  Small-signal analysis of multiphase interleaved boost converter with coupled inductors , 2005 .

[6]  M. Cousineau,et al.  Multiphase coupled converter models dedicated to transient response and output voltage regulation studies , 2008, 2008 13th International Power Electronics and Motion Control Conference.

[7]  Fred C. Lee,et al.  A new model for multiple-winding transformer , 1994, Proceedings of 1994 Power Electronics Specialist Conference - PESC'94.

[8]  Charles R. Sullivan,et al.  Coupled-inductor design optimization for fast-response low-voltage DC-DC converters , 2002, APEC. Seventeenth Annual IEEE Applied Power Electronics Conference and Exposition (Cat. No.02CH37335).

[9]  Peng Xu,et al.  Investigating coupling inductors in the interleaving QSW VRM , 2000, APEC 2000. Fifteenth Annual IEEE Applied Power Electronics Conference and Exposition (Cat. No.00CH37058).

[10]  F.C. Lee,et al.  The short winding path coupled inductor voltage regulators , 2008, 2008 Twenty-Third Annual IEEE Applied Power Electronics Conference and Exposition.

[11]  I. Batarseh,et al.  Investigating effects of magnetizing inductance on coupled-inductor voltage regulators , 2008, 2008 Twenty-Third Annual IEEE Applied Power Electronics Conference and Exposition.

[12]  A.V. Peterchev,et al.  Load-Line Regulation With Estimated Load-Current Feedforward: Application to Microprocessor Voltage Regulators , 2006, IEEE Transactions on Power Electronics.

[13]  C.R. Sullivan,et al.  Using coupled inductors to enhance transient performance of multi-phase buck converters , 2004, Nineteenth Annual IEEE Applied Power Electronics Conference and Exposition, 2004. APEC '04..

[14]  Guangyong Zhu,et al.  Modeling and design considerations of coupled inductor converters , 2010, 2010 Twenty-Fifth Annual IEEE Applied Power Electronics Conference and Exposition (APEC).

[15]  Peng Xu,et al.  Performance improvements of interleaving VRMs with coupling inductors , 2001 .

[16]  H.-W. Lee,et al.  Generalised steady-state analysis of multiphase interleaved boost converter with coupled inductors , 2005 .

[17]  F.C. Lee,et al.  Evaluation of coupled inductor Voltage Regulators , 2008, 2008 Twenty-Third Annual IEEE Applied Power Electronics Conference and Exposition.