Membrane distillation for wastewater reverse osmosis concentrate treatment with water reuse potential

Abstract Membrane distillation (MD) was evaluated as a treatment option of wastewater reverse osmosis concentrate (WWROC) discharged from wastewater reclamation plants (WRPs). A direct contact MD (DCMD), at obtaining 85% water recovery of WWROC showed only 13–15% flux decline and produced good quality permeate (10–15 µS/cm, 99% ion rejection) at moderate feed temperature of 55 °C. Prevalent calcium carbonate (CaCO 3 ) deposition on the MD membrane occurred in treating WWROC at elevated concentrations. The combination of low salinity and loose CaCO 3 adhesion on the membrane did not significantly contribute to DCMD flux decline. Meanwhile, high organic content in WWROC (58–60 mg/L) resulted in a significant membrane hydrophobicity reduction (70% lower water contact angle than virgin membrane) attributed to low molecular weight organic adhesion onto the MD membrane. Granular activated carbon (GAC) pretreatment helped in reducing organic contents of WWROC by 46–50%, and adsorbed a range of hydrophobic and hydrophilic micropollutants. This ensured high quality water production by MD (micropollutants-free) and enhanced its reuse potential. The MD concentrated WWROC was suitable for selective ion precipitation, promising a near zero liquid discharge in WRPs.

[1]  E. Drioli,et al.  Potential of membrane distillation in seawater desalination: Thermal efficiency, sensitivity study and cost estimation , 2008 .

[2]  Enrico Drioli,et al.  Membrane distillation operated at high seawater concentration factors: Role of the membrane on CaCO3 scaling in presence of humic acid , 2010 .

[3]  M. Kitamura.  Strategy for control of crystallization of polymorphs , 2009 .

[4]  Tzahi Y. Cath,et al.  Experimental study of desalination using direct contact membrane distillation: a new approach to flux enhancement , 2004 .

[5]  Eugene R. Reahl,et al.  Case study: Integrating membrane processes with evaporation to achieve economical zero liquid discharge at the Doswell Combined Cycle Facility , 1995 .

[6]  Keshab Sharma,et al.  A pilot study for wastewater reclamation and reuse with MBR/RO and MF/RO systems , 2007 .

[7]  S. Vigneswaran,et al.  Interaction of humic substances on fouling in membrane distillation for seawater desalination , 2015 .

[8]  Tzahi Y. Cath,et al.  A scaling mitigation approach during direct contact membrane distillation , 2011 .

[9]  Tzahi Y. Cath,et al.  High recovery of concentrated RO brines using forward osmosis and membrane distillation , 2009 .

[10]  R. Moreira,et al.  Removal of pharmaceutical compounds in membrane bioreactors (MBR) applying submerged membranes , 2010 .

[11]  Tzahi Y. Cath,et al.  Rejection and fate of trace organic compounds (TrOCs) during membrane distillation , 2014 .

[12]  Enrico Drioli,et al.  Integrated system for recovery of CaCO3, NaCl and MgSO4·7H2O from nanofiltration retentate , 2004 .

[13]  P. Huck,et al.  Adsorption characteristics of selected pharmaceuticals and an endocrine disrupting compound-Naproxen, carbamazepine and nonylphenol-on activated carbon. , 2008, Water research.

[14]  Fawzi Banat,et al.  Economic evaluation of desalination by small-scale autonomous solar-powered membrane distillation units , 2008 .

[15]  W. Pronk,et al.  Interplay of different NOM fouling mechanisms during ultrafiltration for drinking water production. , 2007, Water research.

[16]  J. Drewes,et al.  Quantitative structure property relationships for the adsorption of pharmaceuticals onto activated carbon. , 2010, Water science and technology : a journal of the International Association on Water Pollution Research.

[17]  Peter Fox,et al.  Mineral recovery from inland reverse osmosis concentrate using isothermal evaporation. , 2010, Water research.

[18]  B. Jefferson,et al.  Treatment of municipal wastewater reverse osmosis concentrate using UVC-LED/H2O2 with and without coagulation pre-treatment , 2015 .

[19]  Guangzhi Zuo,et al.  Energy efficiency evaluation and economic analyses of direct contact membrane distillation system using Aspen Plus , 2011 .

[20]  Tzahi Y. Cath,et al.  Sustainable operation of membrane distillation for enhancement of mineral recovery from hypersaline solutions , 2014 .

[21]  E. Chibowski,et al.  Time dependent changes in zeta potential of freshly precipitated calcium carbonate , 2003 .

[22]  S. Rice,et al.  Long-term effect on membrane fouling in a new membrane bioreactor as a pretreatment to seawater desalination. , 2014, Bioresource technology.

[23]  M. Gryta,et al.  The influence of polypropylene degradation on the membrane wettability during membrane distillation , 2009 .

[24]  H. Miedema,et al.  Polymorphic change from vaterite to aragonite under influence of sulfate: The “morning star” habit , 2014 .

[25]  A Pérez-González,et al.  State of the art and review on the treatment technologies of water reverse osmosis concentrates. , 2012, Water research.

[26]  J. Koschikowski,et al.  Membrane distillation: Solar and waste heat driven demonstration plants for desalination , 2013 .

[27]  S Vigneswaran,et al.  Performance of submerged membrane bioreactor (SMBR) with and without the addition of the different particle sizes of GAC as suspended medium. , 2013, Bioresource technology.

[28]  In S. Kim,et al.  Organic fouling behavior in direct contact membrane distillation , 2014 .

[29]  W. F. Langelier.  The Analytical Control of Anti‐Corrosion Water Treatment , 1936, Journal - American Water Works Association.

[30]  Menachem Elimelech,et al.  A forward osmosis-membrane distillation hybrid process for direct sewer mining: system performance and limitations. , 2013, Environmental science & technology.

[31]  A. Al-Rawajfeh,et al.  Assessment of tap water resources quality and its potential of scale formation and corrosivity in Tafila Province, South Jordan , 2007 .

[32]  G. Aiken,et al.  Calcite crystal growth inhibition by humic substances with emphasis on hydrophobic acids from the Florida Everglades , 2000 .

[33]  J. Keller,et al.  Characterisation and removal of recalcitrants in reverse osmosis concentrates from water reclamation plants. , 2011, Water research.

[34]  Yu Liu,et al.  Fouling and wetting in membrane distillation (MD) and MD-bioreactor (MDBR) for wastewater reclamation , 2013 .

[35]  Miss A.O. Penney.  (b) , 1974, The New Yale Book of Quotations.

[36]  Djamel Ghernaout,et al.  The hydrophilic/hydrophobic ratio vs. dissolved organics removal by coagulation – A review , 2014 .

[37]  Julián Blanco,et al.  Experimental analysis of an air gap membrane distillation solar desalination pilot system , 2011 .

[38]  B. Bruggen,et al.  Separation of nutrient ions and organic compounds from salts in RO concentrates by standard and monovalent selective ion-exchange membranes used in electrodialysis , 2009 .

[39]  Tien Vinh Nguyen,et al.  Submerged membrane - (GAC) adsorption hybrid system in reverse osmosis concentrate treatment , 2015 .

[40]  Emmanuel Dialynas,et al.  Advanced treatment of the reverse osmosis concentrate produced during reclamation of municipal wastewater. , 2008, Water research.

[41]  Jaya Kandasamy,et al.  Experimental evaluation of microfiltration–granular activated carbon (MF–GAC)/nano filter hybrid system in high quality water reuse , 2015 .

[42]  K. Sirkar,et al.  Studies on scaling of membranes in desalination by direct contact membrane distillation: CaCO3 and mixed CaCO3/CaSO4 systems , 2009 .

[43]  B. Bruggen,et al.  Electrodialysis on RO concentrate to improve water recovery in wastewater reclamation , 2011 .

[44]  Corinne Cabassud,et al.  Vacuum membrane distillation of seawater reverse osmosis brines. , 2010, Water research.

[45]  S. Rice,et al.  Microbial activity in biofilter used as a pretreatment for seawater desalination , 2013 .