Moisture sorption characteristics and modeling of energy sorghum (Sorghum bicolor (L.) Moench).

Abstract Long-term low cost storage of whole-stalk lignocellulosic energy sorghum biomass (specialized forage varieties of Sorghum bicolor (L.) Moench) is essential for the feedstock's successful role as a dedicated energy crop for ethanol production. As an alternative to expensive ensiling methods, aerobic storage of S. bicolor (L.) Moench biomass in traditional rectangular bale formats could alleviate feedstock supply costs if material deterioration in storage could be minimized. Moisture desorption and adsorption isotherms for S. bicolor (L.) Moench were created at 15 °C, 20 °C, 30 °C, and 40 °C with water activities from 0.1 to 0.9 using the dynamic dew-point method. Sorption isotherms were modeled using four temperature dependent and three temperature independent equations. The relationship between equilibrium moisture content and water activity was found to decrease with increasing temperatures. GAB (Guggenheim–Anderson–de Boer) monolayer moisture content and the moisture content at which microbial activity becomes limited were found to range from 5.6% db to 10.4% dry basis (db) and 12.0% db to 18.4% db, respectively. The net isosteric heat of sorption was calculated using the Clausius–Clapeyron equation and determined to be higher for desorption than adsorption with both trends decreasing exponentially at increasing levels of moisture content. The differential entropy of S. bicolor (L.) Moench was shown to exhibit a log normal relationship with moisture; peaking near the monolayer moisture content. The results of the study indicate that aerobic storage of energy sorghum biomass may be similar to other herbaceous feedstocks should extensive drying occur before entering storage.

[1]  J. E. Clayton,et al.  Losses of fermentable sugars in sweet sorghum during storage. , 1982 .

[2]  Joachim Müller,et al.  Modeling of the equilibrium moisture content (EMC) of Miscanthus (Miscanthus × giganteus) , 2010 .

[3]  J. Chirife,et al.  On the Temperature Dependence of Isosteric Heats of Water Sorption in Dehydrated Foods , 1989 .

[4]  G. G. McBee,et al.  Sorghum improvement for energy production , 1984 .

[5]  N. Kechaou,et al.  Moisture desorption–adsorption isotherms and isosteric heats of sorption of Tunisian olive leaves (Olea europaea L.) , 2008 .

[6]  P. S. Madamba,et al.  Enthalpy-entropy compensation models for sorption and browning of garlic , 1996 .

[7]  Albert S Bennett,et al.  Production, transportation and milling costs of sweet sorghum as a feedstock for centralized bioethanol production in the upper Midwest. , 2009, Bioresource technology.

[8]  Larry R. Beuchat,et al.  Microbial stability as affected by water activity. , 1981 .

[9]  Thomas C. Bridges,et al.  Equilibrium Moisture Properties of Corn Cobs , 1985 .

[10]  R. V. Morey,et al.  Comparison of four EMC/ERH equations , 1989 .

[11]  Alvin R. Womac,et al.  SORPTION EQUILIBRIUM MOISTURE CHARACTERISTICS OF SELECTED CORN STOVER COMPONENTS , 2005 .

[12]  Jürg M. Blumenthal,et al.  Designing sorghum as a dedicated bioenergy feedstock , 2007 .

[13]  R. Hill,et al.  Factors determining the microflora of stored barley grain , 1983 .

[14]  F. Miller,et al.  Genetics and management of physiologic systems of sorghum for biomass production , 1993 .

[15]  G. Halsey,et al.  Physical Adsorption on Non‐Uniform Surfaces , 1948 .

[16]  S. Schmidt,et al.  Comparison Between Water Vapor Sorption Isotherms Obtained Using The New Dynamic Dewpoint Isotherm Method and those Obtained Using The Standard Saturated Salt Slurry Method , 2012 .

[17]  Charlie G. Coble,et al.  Dry matter losses during hay production and storage of sweet sorghum used for methane production , 1986 .

[18]  W. Rooney,et al.  Evaluation of bioethanol production from five different varieties of sweet and forage sorghums (Sorghum bicolor (L) Moench) , 2011 .

[19]  Chris T. Kiranoudis,et al.  Equilibrium moisture content and heat of desorption of some vegetables , 1993 .

[20]  M. Peleg.  Assessment of a semi-empirical four parameter general model for sigmoid moisture sorption isotherms , 1993 .

[21]  E. Berlin,et al.  Changes in state of water in proteinaceous systems. , 1970, Journal of colloid and interface science.

[22]  A. Almodares,et al.  Production of bioethanol from sweet sorghum: A review , 2009 .

[23]  J. Chirife,et al.  Prediction of the effect of temperature on water sorption isotherms of food material , 1976 .

[24]  R. Anderson,et al.  Preservation of sweet sorghum biomass , 1983 .

[25]  S. Henderson.  A basic concept of equilibrium moisture , 1952 .

[26]  Daniel Nilsson,et al.  Adsorption Equilibrium Moisture Contents of Flax Straw, Hemp Stalks and Reed Canary Grass , 2005 .

[27]  G. H. Foster,et al.  Mathematical Simulation of Corn Drying — A New Model , 1968 .

[28]  S. Bruin,et al.  Water activity and its estimation in food systems: theoretical aspects , 1978 .

[29]  M Cerofolini,et al.  Heterogeneity, allostericity, and hysteresis in adsorption of water by proteins , 1980 .

[30]  T. Labuza.  The effect of water activity on reaction kinetics of food deterioration , 1980 .

[31]  D. Chung,et al.  Adsorption and Desorption of Water Vapor by Cereal Grains and Their Products Part II: Development of the General Isotherm Equation , 1967 .

[32]  C. Igathinathane,et al.  MOISTURE SORPTION THERMODYNAMIC PROPERTIES OF CORN STOVER FRACTIONS , 2007 .

[33]  N. Magan,et al.  Microbial changes during the on-farm storage of canola (oilseed rape) straw bales and pellets , 2011 .

[34]  R. Tyler,et al.  THERMODYNAMICS OF MOISTURE SORPTION IN ALFALFA PELLETS , 1997 .

[35]  Theodore P. Labuza,et al.  Moisture Sorption: Practical Aspects of Isotherm Measurement and Use , 2000 .

[36]  C. R. Oswin.  The kinetics of package life. III. The isotherm , 1946 .

[37]  Andrea Monti,et al.  Are we ready to cultivate sweet sorghum as a bioenergy feedstock? A review on field management practices , 2012 .

[38]  W. Mcminn,et al.  Thermodynamic properties of moisture sorption of potato , 2003 .

[39]  Qiyan Feng,et al.  Equilibrium moisture content and sorption isosteric heats of five wheat varieties in China , 2011 .

[40]  S. Schmidt,et al.  Determining the critical relative humidity at which the glassy to rubbery transition occurs in polydextrose using an automatic water vapor sorption instrument. , 2011, Journal of food science.

[41]  J. Chirife,et al.  Isosteric heats of water vapor sorption on dehydrated foods. I. analysis of the differential heat curves , 1976 .