Scalability analysis of diffractive optical element-based free-space photonic circuits for interoptoelectronic chip interconnections.

An interchip free-space optical interconnection module is investigated to solve the pin-input-output bottleneck at the interface of silicon integrated circuits. The scalability of the photonic circuit is theoretically analyzed by use of the minimum feature size requirement of each diffractive element used. The study showed that interconnection densities of 1000-2000 channels/cm is possible for a 40-mm interconnection length with a 3-mm-thick optical substrate. Diffraction-limited imaging capability has been demonstrated using a fabricated prototype, confirming its applicability for interchip free-space interconnections. Photonic circuit insertion losses of -23.4 dB for TE polarization and -25.9 dB for TM polarization as well as a polarization-dependent loss of 2.5 dB are found to be caused primarily by a pair of binary linear gratings used for beam deflections. Design modifications aiming at insertion loss reduction and further improvement of tolerance capabilities are also discussed.

[1]  Frank Sauer,et al.  Refractive-diffractive micro-optics for permutation interconnects , 1994 .

[2]  T. Gaylord,et al.  Diffraction analysis of dielectric surface-relief gratings , 1982 .

[3]  Ashok V. Krishnamoorthy,et al.  Performance comparison between optoelectronic and VLSI multistage interconnection networks , 1991 .

[4]  H. Sasaki,et al.  Wafer bonding technology for optoelectronic integrated devices , 1999 .

[5]  J. P. Crenn,et al.  Changes in the characteristics of a Gaussian beam weakly diffracted by a circular aperture. , 1982, Applied optics.

[6]  J. J. Dudley,et al.  Double‐fused 1.52‐μm vertical‐cavity lasers , 1995 .

[7]  Erich Spitz,et al.  Photolithographic fabrication of thin film lenses , 1972 .

[8]  Long Yang,et al.  Room-temperature continuous-wave operation of 1.54-μm vertical-cavity lasers , 1995, IEEE Photonics Technology Letters.

[9]  T Kamijoh,et al.  Design considerations of stacked multilayers of diffractive optical elements for optical network units in optical subscriber-network applications. , 1998, Applied optics.

[10]  Gary J. Swanson,et al.  Diffractive optical elements for use in infrared systems , 1989 .

[11]  S H Lee,et al.  Cost-effective mass fabrication of multilevel diffractive optical elements by use of a single optical exposure with a gray-scale mask on high-energy beam-sensitive glass. , 1997, Applied optics.

[12]  R.T. Chen,et al.  Si-based surface-relief polygonal gratings for 1-to-many wafer scale optical clock signal distribution , 1996, IEEE Photonics Technology Letters.

[13]  S H Lee,et al.  Tolerancing of board-level-free-space optical interconnects. , 1996, Applied optics.

[14]  Y Li,et al.  Planar-optical mesh-connected tree interconnects: a feasibility study. , 1995, Applied optics.

[15]  R K Kostuk,et al.  Distributed optical data bus for board-level interconnects. , 1993, Applied optics.

[16]  Ashok V. Krishnamoorthy,et al.  Scaling optoelectronic-VLSI circuits into the 21st century: a technology roadmap , 1996 .

[17]  L A Coldren,et al.  Parallel free-space optical interconnect based on arrays of vertical-cavity lasers and detectors with monolithic microlenses. , 1998, Applied optics.

[18]  A. Scherer,et al.  Vertical-cavity surface-emitting lasers: Design, growth, fabrication, characterization , 1991 .

[19]  G. C. Boisset,et al.  Design, implementation, and characterization of a hybrid optical interconnect for a four-stage free-space optical backplane demonstrator. , 1998, Applied optics.

[20]  K. Miyamoto.  The Phase Fresnel Lens , 1961 .

[21]  Jian Ma,et al.  Alignment issues in packaging for free-space optical interconnects , 1994 .

[22]  J Jahns,et al.  Integrated micro-optical imaging system with a high interconnection capacity fabricated in planar optics. , 1997, Applied optics.

[23]  Thomas J. Cloonan.  Comparative study of optical and electronic interconnection technologies for large asynchronous transfer mode packet switching applications , 1994 .

[24]  Jürgen Jahns,et al.  Parallel optical interconnections using surface-emitting microlasers and a hybrid imaging system , 1994 .

[25]  S H Lee,et al.  Diffractive optics applied to free-space optical interconnects. , 1994, Applied optics.

[26]  Yiu-Man Wong,et al.  Hybrid integration of surface-emitting microlaser chip and planar optics substrate for interconnection applications , 1992 .

[27]  Herwig Kogelnik,et al.  Imaging of optical modes — resonators with internal lenses , 1965 .

[28]  R. Magnusson,et al.  Diffraction efficiencies of thin phase gratings with arbitrary grating shape , 1978 .

[29]  S Matsuo,et al.  Board-to-Board Free-Space Optical Interconnections Passing through Boards for a Bookshelf-Assembled Terabit-Per-Second-Class ATM Switch. , 1998, Applied optics.

[30]  M R Feldman,et al.  Guided-wave and free-space optical interconnects for parallel-processing systems: a comparison. , 1994, Applied optics.

[31]  G. Swanson.  Binary Optics Technology: The Theory and Design of Multi-Level Diffractive Optical Elements , 1989 .

[32]  C C Guest,et al.  Interconnect density capabilities of computer generated holograms for optical interconnection of very large scale integrated circuits. , 1989, Applied optics.

[33]  Gary J. Swanson,et al.  Binary Optics Technology: Theoretical Limits on the Diffraction Efficiency of Multilevel Diffractive Optical Elements , 1991 .

[34]  M. Moharam,et al.  Limits of scalar diffraction theory for diffractive phase elements , 1994 .

[35]  H. S. Hinton,et al.  Design and characterization of a microchannel optical interconnect for optical backplanes. , 1997, Applied optics.

[36]  T J Cloonan,et al.  Five-stage free-space optical switching network with field-effect transistor self-electro-optic-effect-device smart-pixel arrays. , 1994, Applied optics.

[37]  H. S. Hinton,et al.  Optical interconnections using microlens arrays , 1992 .

[38]  J. Jahns,et al.  Integrated planar optical imaging systems with high interconnection density. , 1993, Optics letters.

[39]  Adolf W. Lohmann.  Image formation of dilute arrays for optical information processing , 1991 .

[40]  A Huang,et al.  Planar integration of free-space optical components. , 1989, Applied optics.

[41]  Yajun Li,et al.  Focal shift in focused truncated gaussian beams , 1982 .