Strain and damage monitoring in carbon-nanotube-based composite under cyclic strain

Abstract The resistive behavior of multi-walled carbon nanotube (MWCNT)/epoxy resins, tested under mechanical cycles and different levels of applied strain, was investigated for specimens loaded in axial tension. The surface normalized resistivity is linear with the strain for volume fraction of MWCNTs between 2.96 × 10 −4 and 2.97 × 10 −3 (0.05 and 0.5% wt/wt). For values lower than 0.05% wt/wt, close to the electrical percolation threshold (EPT) a non-linear behavior was observed. The strain sensitivity, in the range between 0.67 and 4.45, may be specifically modified by controlling the nanotube loading, in fact the sensor sensitivity decreases with increasing the carbon nanotubes amount. Microscale damages resulted directly related to the resistance changes and hence easily detectable in a non-destructive way by means of electrical measurements. In the fatigue tests, the damage is expressed through the presence of a residual resistivity, which increases with the amount of plastic strain accumulated in the matrix.

[1]  Colette Lacabanne,et al.  DC and AC conductivity of carbon nanotubes-polyepoxy composites , 2003 .

[2]  Christian A. Martin,et al.  Electric field-induced aligned multi-wall carbon nanotube networks in epoxy composites , 2005 .

[3]  Eugene M. Terentjev,et al.  Photomechanical actuation in polymer–nanotube composites , 2005, Nature materials.

[4]  Mark J. Schulz,et al.  A carbon nanotube strain sensor for structural health monitoring , 2006 .

[5]  Karl Schulte,et al.  Load and failure analyses of CFRP laminates by means of electrical resistivity measurements , 1989 .

[6]  Tsu-Wei Chou,et al.  Microstructural design of fiber composites , 1992 .

[7]  F. Avilés,et al.  Electrical and piezoresistive properties of multi-walled carbon nanotube/polymer composite films aligned by an electric field , 2011 .

[8]  Akira Todoroki,et al.  Electrical Resistance Change under Strain of CNF/Flexible-Epoxy Composite , 2007 .

[9]  Chunyu Li,et al.  Atomistic Modeling of Carbon Nanotube-based Mechanical Sensors , 2006 .

[10]  K. Schulte,et al.  Piezoresistive response of epoxy composites with carbon nanoparticles under tensile load , 2009 .

[11]  Seunghee Park,et al.  Wireless impedance sensor nodes for functions of structural damage identification and sensor self-diagnosis , 2009 .

[12]  Chunyu Li,et al.  Mass detection using carbon nanotube-based nanomechanical resonators , 2004 .

[13]  E. Kymakis,et al.  Electrical properties of single-wall carbon nanotube-polymer composite films , 2006 .

[14]  M. Knite,et al.  Polyisoprene-carbon black nanocomposites as tensile strain and pressure sensor materials , 2004 .

[15]  Prasad K. Yarlagadda,et al.  Sandwiched carbon nanotube film as strain sensor , 2012 .

[16]  Bodo Fiedler,et al.  Evaluation and identification of electrical and thermal conduction mechanisms in carbon nanotube/epoxy composites , 2006 .

[17]  Milo S. P. Shaffer,et al.  Development of a dispersion process for carbon nanotubes in an epoxy matrix and the resulting electrical properties , 1999 .

[18]  N. Hu,et al.  Tunneling effect in a polymer/carbon nanotube nanocompositestrain sensor , 2008 .

[19]  D.D.L. Chung,et al.  Electrical behavior of carbon fiber polymer-matrix composites in the through-thickness direction , 2000 .

[20]  Satish Nagarajaiah,et al.  Nanotube film based on single-wall carbon nanotubes for strain sensing , 2004 .

[21]  Ning Hu,et al.  Piezoresistive Strain Sensors Made from Carbon Nanotubes Based Polymer Nanocomposites , 2011, Sensors.

[22]  David Cebon,et al.  Materials Selection in Mechanical Design , 1992 .

[23]  J. M. Kikkawa,et al.  Very Low Conductivity Threshold in Bulk Isotropic Single‐Walled Carbon Nanotube–Epoxy Composites , 2005 .

[24]  A. K. Jonscher,et al.  The ‘universal’ dielectric response , 1977, Nature.

[25]  Peter Schwartz,et al.  Monitoring bending fatigue in carbon-fibre/epoxy composite strands: a comparison between mechanical and resistance techniques , 2001 .

[26]  Wieslaw J. Staszewski,et al.  Health Monitoring Of Aerospace Structures: Smart Sensor Technologies And Signal Processing , 2017 .

[27]  Yoshinobu Shimamura,et al.  Cyclic Behavior of Electrical Resistance Type Low Stiffness, Large Strain Sensor by Using Carbon Nanofiber/Flexible Epoxy Composite , 2011 .

[28]  Wolfgang Bauhofer,et al.  A review and analysis of electrical percolation in carbon nanotube polymer composites , 2009 .

[29]  Tunneling-percolation origin of nonuniversality: Theory and experiments , 2005, cond-mat/0503647.

[30]  D.D.L. Chung,et al.  TECHNICAL NOTE: A piezoresistive carbon filament polymer-matrix composite strain sensor , 1996 .

[31]  I. Kinloch,et al.  Ultra-low electrical percolation threshold in carbon-nanotube-epoxy composites , 2003 .

[32]  J. Fischer,et al.  Effect of nanotube alignment on percolation conductivity in carbon nanotube/polymer composites , 2005 .

[33]  C. Naddeo,et al.  Mechanical and barrier properties of epoxy resin filled with multi-walled carbon nanotubes , 2009 .

[34]  Ping Sheng,et al.  Fluctuation-Induced Tunneling Conduction in Carbon-Polyvinylchloride Composites , 1978 .

[35]  Vahid Mottaghitalab,et al.  Carbon‐Nanotube‐Reinforced Polyaniline Fibers for High‐Strength Artificial Muscles , 2006 .

[36]  T. Chou,et al.  Carbon Nanotube Networks: Sensing of Distributed Strain and Damage for Life Prediction and Self Healing , 2006 .

[37]  A. Di Bartolomeo,et al.  Influence of multiwall carbon nanotubes on morphological and structural changes during UV irradiation of syndiotactic polypropylene films. , 2012 .

[38]  J. Aneli,et al.  Effects of mechanical deformations on the structurization and electric conductivity of electric conducting polymer composites , 1999 .

[39]  P. Lamberti,et al.  Cure behavior and physical properties of epoxy resin-filled with multiwalled carbon nanotubes. , 2010, Journal of nanoscience and nanotechnology.

[40]  Karl Schulte,et al.  Non-destructive testing of FRP by d.c. and a.c. electrical methods , 2001 .

[41]  Ho Gyu Yoon,et al.  Electrical conductivity of chemically modified multiwalled carbon nanotube/epoxy composites , 2005 .

[42]  Myounggu Park,et al.  Strain-dependent electrical resistance of multi-walled carbon nanotube/polymer composite films , 2008, Nanotechnology.

[43]  P. Su,et al.  Humidity sensors based on TiO2 nanoparticles/polypyrrole composite thin films , 2007 .

[44]  Alan H. Windle,et al.  Thermal and electrical conductivity of single- and multi-walled carbon nanotube-epoxy composites , 2006 .

[45]  Shiv P. Joshi,et al.  Damage detection in CFRP by electrical conductivity mapping , 2001 .

[46]  Paolo Ciambelli,et al.  Incorporation of Carbon Nanotubes into Polyethylene by High Energy Ball Milling: Morphology anf Physical Properties , 2007 .

[47]  J. Xue,et al.  Ultrasensitive strain sensors made from metal-coated carbon nanofiller/epoxy composites , 2013 .

[48]  Patrizia Lamberti,et al.  Simulation and experimental characterization of polymer/carbon nanotubes composites for strain sensor applications , 2014 .

[49]  J. Simmons.  Generalized Formula for the Electric Tunnel Effect between Similar Electrodes Separated by a Thin Insulating Film , 1963 .

[50]  C. Galiotis,et al.  Effect of oxidation treatment of multiwalled carbon nanotubes on the mechanical and electrical properties of their epoxy composites , 2009 .

[51]  Chuck Zhang,et al.  Processing and modeling of conductive thermoplastic/carbon nanotube films for strain sensing , 2008 .

[52]  N. Hu,et al.  Investigation on sensitivity of a polymer/carbon nanotube composite strain sensor , 2010 .

[53]  M. S. Sarto,et al.  Electromagnetic properties of Carbon NanoTube/epoxy nanocomposites , 2009, 2009 International Symposium on Electromagnetic Compatibility - EMC Europe.

[54]  Karl Schulte,et al.  Load and health monitoring in glass fibre reinforced composites with an electrically conductive nanocomposite epoxy matrix , 2008 .

[55]  H. Fukunaga,et al.  A carbon nanotube/polymer strain sensor with linear and anti-symmetric piezoresistivity , 2011 .

[56]  K. Schulte,et al.  Two percolation thresholds in carbon nanotube epoxy composites , 2007 .

[57]  T. K. Chaki,et al.  Effect of axial stretching on electrical resistivity of short carbon fibre and carbon black filled conductive rubber composites , 2002 .

[58]  A. Rinzler,et al.  Carbon nanotube actuators , 1999, Science.

[59]  C. Brosseau,et al.  Direct current electrical and microwave properties of polymer-multiwalled carbon nanotubes composites , 2008 .

[60]  Jae Ryoun Youn,et al.  Influence of dispersion states of carbon nanotubes on physical properties of epoxy nanocomposites , 2005 .

[61]  P. Lamberti,et al.  Effect of functionalization on the thermo-mechanical and electrical behavior of multi-wall carbon nanotube/epoxy composites , 2011 .

[62]  F. Avilés,et al.  Cyclic tension and compression piezoresistivity of carbon nanotube/vinyl ester composites in the elastic and plastic regimes , 2012 .

[63]  D. Chung,et al.  Piezoresistivity in unidirectional continuous carbon fiber polymer-matrix composites: single-lamina composite versus two-lamina composite , 2004 .