Distribution of volatile organic compounds over a semiconductor Industrial Park in Taiwan.

This study examined volatile organic compounds (VOC) concentration in ambient air collected during the years 2000--2003 at several different locations of Hsinchu Science-based Industrial Park (HSIP) in Taiwan. A canister automated GC-MS system analyzed the volatile organics in ambient air grasp samples according to T0-15 method. Oxygenated volatiles were the most abundant VOC detected in HSIP followed by aromatics that are commonly used as solvents in the semiconductor industries. The major components measured in the ambient air are 2-propanol (29-135 ppbv), acetone (12-164 ppbv), benzene (0.7-1.7 ppbv), and toluene (13-20 ppbv). At some of the sampling locations, odorous compounds such as carbon disulfide and dimethyl sulfide levels exceed threshold values. The estimated toluene/benzene ratio is very high at most of the sites. However, the total amount of VOC is reduced over the years from 2000 to 2003 due to strict implementation on use and discharge of solvents in industries. There exists no definite seasonal pattern for sporadic occurrence of high levels of some of the volatile organics. Stagnant weather conditions with low wind speeds aid accumulation of toxic species at ground level. The results entail that hi-tech semiconductor industries are still a potential source for harmful organic substances to surrounding microenvironment.

[1]  P. Doskey,et al.  Automated sampler for the measurement of non-methane organic compounds. , 2001, Environmental science & technology.

[2]  G. Samanta,et al.  Determination of Benzene, Toluene and Xylene in Ambient Air of Calcutta for Three Years During Winter , 1997 .

[3]  W. M. Li,et al.  Risk assessment of exposure to volatile organic compounds in different indoor environments. , 2004, Environmental research.

[4]  Wen-Chin Wang,et al.  Exposure to volatile organic compounds while commuting in Taichung, Taiwan , 2000 .

[5]  Garry D. Hayman,et al.  Photochemical ozone creation potentials for oxygenated volatile organic compounds: sensitivity to variations in kinetic and mechanistic parameters , 1999 .

[6]  David E Stikkers.  Octane and the environment. , 2002, The Science of the total environment.

[7]  A proportionate cancer morbidity ratio study of workers exposed to chlorinated organic solvents in Taiwan. , 2003, Industrial health.

[8]  Chi‐Wen Lin.  Hazardous Air Pollutant Source Emissions for a Chemical Fiber Manufacturing Facility in Taiwan , 2001 .

[9]  HungMin Chein,et al.  Emission Characteristics of Volatile Organic Compounds from Semiconductor Manufacturing , 2003, Journal of the Air & Waste Management Association.

[10]  H. Singh,et al.  Distribution of aromatic hydrocarbons in the ambient air , 1985 .

[11]  J. Lo,et al.  Analysis of volatile organic compounds in wastewater during various stages of treatment for high-tech industries , 2002 .

[12]  Chih-Chung Chang,et al.  Assessment of reducing ozone forming potential for vehicles using liquefied petroleum gas as an alternative fuel , 2001 .

[13]  J. Dewulf,et al.  Anthropogenic volatile organic compounds in ambient air and natural waters: a review on recent developments of analytical methodology, performance and interpretation of field measurements , 1999 .

[14]  Measurement of toxic volatile organic compounds in indoor air of semiconductor foundries using multisorbent adsorption/thermal desorption coupled with gas chromatography-mass spectrometry. , 2003, Journal of chromatography. A.

[15]  C. Tsai,et al.  Concentration variability of halocarbons over an electronics industrial park and its implication in compliance with the Montreal protocol. , 2001, Environmental science & technology.

[16]  J. Lo,et al.  Assessment Of The Environmental Air In ASemiconductor Industrial Area By FTIR AndGC/MS , 2000 .

[17]  Aysen Muezzinoglu,et al.  A study of volatile organic sulfur emissions causing urban odors. , 2003, Chemosphere.

[18]  Pasquale Avino,et al.  Monoaromatic compounds in ambient air of various cities: a focus on correlations between the xylenes and ethylbenzene , 2001 .

[19]  HungMin Chein,et al.  Emission characteristics and control efficiency of acidic and basic gases and aerosols from packed towers , 2004 .

[20]  P. Crutzen,et al.  High concentrations and photochemical fate of oxygenated hydrocarbons in the global troposphere , 1995, Nature.

[21]  R. Perry,et al.  The sources and behaviour of tropospheric anthropogenic volatile hydrocarbons , 1992 .

[22]  H. Langenhove,et al.  Abatement of volatile organic sulfur compounds in odorous emissions from the bio-industry , 2004, Biodegradation.

[23]  P. Nelson,et al.  The m,p-xylenes:ethylbenzene ratio. A technique for estimating hydrocarbon age in ambient atmospheres , 1983 .

[24]  Tsai-Yin Lin,et al.  Volatile organic compound concentrations in ambient air of Kaohsiung petroleum refinery in Taiwan , 2004 .

[25]  G. Nickless,et al.  NON-C02 GREENHOUSE GASES: SCIENTIFIC UNDERSTANDING, CONTROL OPTIONS AND POLICY ASPECTS , 2002 .

[26]  T. Tso,et al.  Determination in Situ of Chemical Solvent Vapors in a Semiconductor Workplace with an Open Path FTIR Spectrometer , 1994 .