Ice growth on the cooling surface in a jacketed and stirred eutectic freeze crystallizer of aqueous Na2SO4 solutions

Abstract Eutectic freeze crystallization (EFC) has been pronounced a promising separation technique to recover ice and salt simultaneously in an energy-efficient manner. Alike other freeze concentration methods, the accumulation of an ice layer, commonly known as ice-scaling, on the heat exchanger surface during operation thwarts the commercial application of EFC as the advantage of low energy requirement is outstripped by high investment cost, scaling up and operational complexities associated with the use of a scraper blade to remove the ice-scaling. Therefore, the aim of this research work is to investigate the ice-scaling phenomenon on a subcooled heat exchanger surface in the absence of mechanical scrapping. For a continuous EFC system, the influence of temperature driving force (ΔT) and the degree of agitation on the onset/induction time (t ind ) of ice-scaling are considered while keeping the other parameters, e.g., solution concentration (4 wt% Na 2 SO 4 (aq) solution), the level of initial undercooling (0.28 °C) and the residence time (30 min) constant. The experimental results show that at a certain level of agitation, t ind is inverse proportional to ΔT. At a low level of ΔT (i.e., ind declines. Contrary to this, at a high level of ΔT (>6.0 °C), the effect of the degree of agitation on t ind becomes substantial. At the eutectic condition, the heat transfer coefficient of the solution (h sol ) in the crystallizer prevails over that of mass transfer ( k l ). In the experimental setup, the overall heat transfer coefficient for a jacketed vessel type crystallizer is restricted by the heat transfer coefficient of the jacket side coolant (h j ). The power number (N p ) and pumping number (N q ) for a two-blade paddle type impeller and a crystallizer of specific dimensions and orientation are estimated by means of computational fluid dynamics (CFD) modeling and are used to calculate the specific power input (e) and impeller pumping capacity (Q) at different levels of agitation. Furthermore, CFD simulations of heat transfer from the coolant to the bulk solution are performed to investigate the effect of the agitation level on solution cooling in the non-crystallizing condition.

[1]  Kozo Nakamura,et al.  Progressive Freeze-Concentration of Model Liquid Food , 1997 .

[2]  M. Louhi-Kultanen,et al.  Ice growth kinetics modeling of air-cooled layer crystallization from sodium sulfate solutions , 2015 .

[3]  Hiromoto Usui,et al.  Effects of paddle dimensions and baffle conditions on the interrelations among discharge flow rate, mixing power and mixing time in mixing vessels. , 1987 .

[4]  Shigeru Sakashita,et al.  Ice crystallization in a pilot-scale freeze wastewater treatment system , 2001 .

[5]  M. Farid,et al.  Freeze concentration of milk and saline solutions in a liquid–solid fluidized bed: Part II. Modelling of ice removal , 2007 .

[6]  A. Lewis,et al.  Heat and Mass Transfer Effects on Ice Growth Mechanisms in Pure Water and Aqueous Solutions , 2014 .

[7]  R. D. Goede,et al.  Heat transfer properties of a scraped-surface heat exchanger in the turbulent flow regime , 1993 .

[8]  F. Qin,et al.  Ice fouling on a subcooled metal surface examined by thermo-response and electrical conductivity , 2003 .

[9]  G. Witkamp,et al.  Prevention of crystallization fouling during eutectic freeze crystallization in fluidized bed heat exchangers , 2008 .

[10]  O. Miyawaki.  Analysis and Control of Ice Crystal Structure in Frozen Food and Their Application to Food Processing , 2001 .

[11]  Masahiro Kawaji,et al.  Ice slurry generation involving moving parts , 2005 .

[12]  Z. Nagy,et al.  Dynamic Modeling of Encrust Formation and Mitigation Strategy in a Continuous Plug Flow Crystallizer , 2015 .

[13]  Y. Shirai,et al.  On the kinetics of ice crystallization in batch crystallizers , 1985 .

[14]  D. G. Randall,et al.  SEEDING FOR SELECTIVE SALT RECOVERY DURING EUTECTIC FREEZE CRYSTALLIZATION , 2009 .

[15]  F. A. Fernandes,et al.  Applications of Ozone in Fruit Processing , 2012 .

[16]  Mohammed M. Farid,et al.  Heat transfer and operating conditions for freeze concentration in a liquid–solid fluidized bed heat exchanger , 2006 .

[17]  G. Witkamp,et al.  Eutectic freeze crystallization simultaneous formation and separation of two solid phases , 1999 .

[18]  S. T. Reddy,et al.  Design of a Eutectic Freeze Crystallization process for multicomponent waste water stream , 2010 .

[19]  Mostafa M. Awad.  Fouling of Heat Transfer Surfaces , 2011 .

[20]  W. Augustin,et al.  Induction Time in Crystallization Fouling on Heat Transfer Surfaces , 2011 .

[21]  John J. McKetta,et al.  Heat transfer design methods , 1991 .

[22]  R. Johnson,et al.  Development of a eutectic freezing process for brine disposal , 1974 .

[23]  C. J. King,et al.  Kinetics of ice crystallization in sugar solutions and fruit juices , 1974 .

[24]  N. S. Osborne.  Heat of fusion of ice. A revision , 1939 .

[25]  Alison Lewis,et al.  A case study for treating a reverse osmosis brine using Eutectic Freeze Crystallization—Approaching a zero waste process , 2011 .

[26]  I. Sekoulov,et al.  Waste Water Reuse by Freeze Concentration with a Falling Film Reactor , 1992 .

[27]  C. J. King,et al.  Secondary nucleation of ice in sugar solutions and fruit juices , 1976 .

[28]  P. Pronk,et al.  Fluidized bed heat exchangers to prevent fouling in ice slurry systems and industrial crystallizers , 2006 .

[29]  H. Thijssen,et al.  Production of large crystals by continuous ripening in a stirrer tank , 1972 .

[30]  Geert-Jan Witkamp,et al.  Influence of solute type and concentration on ice scaling in fluidized bed ice crystallizers , 2006 .

[31]  M. Farid,et al.  Freeze concentration of milk and saline solutions in a liquid–solid fluidized bed: Part I. Experimental , 2007 .

[32]  Cherng-Yuan Lin,et al.  The effects of sodium sulfate on the emissions characteristics of an emulsified marine diesel oil-fired furnace , 2001 .

[33]  Crystallization kinetics of MgSO4·12H2O from different scales of batch cooling scraped crystallizers , 2006 .

[34]  Signe Kjelstrup Ratkje,et al.  Modelling the Freeze Concentration Process by Irreversible Thermodynamics , 1995 .

[35]  M. Rahman,et al.  Freezing-Melting Desalination Process , 2014 .

[36]  D. Garrett.  Sodium Sulfate: Handbook of Deposits, Processing, Properties, and Use , 2001 .

[37]  A. Lewis,et al.  Effect of Operating Conditions on Ice Characteristics in Continuous Eutectic Freeze Crystallization , 2014 .