On the influence of wind on cavity receivers for solar power towers: An experimental analysis

Abstract The influence of wind on the convective losses of cavity receivers for solar power towers was analyzed experimentally in a cryogenic wind tunnel. At an ambient temperature of −173 °C a Grashof number of Gr = 3.9·1010 can be reached. Six different wind directions ranging from head-on to rearward flow, five wind speeds up to Re = 5.2·105 and four inclination angles of the cavity in the range of ϕ = 0°…90° were analyzed. With a similarity approach the results can be transferred to a receiver in normal ambient conditions with an inner diameter of 2.4 m and a wall temperature of approximately 730 °C. The methodology and its restrictions are discussed in detail. The experiments show that the influence of wind on large horizontal receivers is small. However, with increasing inclination angle the receiver becomes more susceptible to wind, although the convective losses never exceed those of the horizontal cavity. In some cases a reduction of the convective losses under the level of natural convection was observed if wind is present. Additionally, local information about the heat losses of different heater sections are presented, which are used to analyze the heat loss mechanisms inside the cavity. A shrinking of the stagnant zone is found to be the main reason for the increasing losses.

[1]  Sawat Paitoonsurikarn,et al.  Experimental Investigation of Natural Convection Heat Loss From a Model Solar Concentrator Cavity Receiver , 2004 .

[2]  Petar Liovic,et al.  Wind dependence of energy losses from a solar gas reformer , 2014 .

[3]  A. M. Clausing,et al.  Natural Convection From Isothermal Cubical Cavities With a Variety of Side-Facing Apertures , 1987 .

[4]  Nathan P. Siegel,et al.  Wind effect on the performance of solid particle solar receivers with and without the protection of an aerowindow , 2009 .

[5]  Lan Xiao,et al.  Numerical study on combined free-forced convection heat loss of solar cavity receiver under wind environments , 2012 .

[6]  Jinjia Wei,et al.  Thermal performance simulation of a solar cavity receiver under windy conditions , 2011 .

[7]  L. L. Eyler.  Predictions of convective losses from a solar cavity receiver , 1979 .

[8]  Lan Xiao,et al.  Effect of aperture position and size on natural convection heat loss of a solar heat-pipe receiver , 2011 .

[9]  Roland Span,et al.  A Reference Equation of State for the Thermodynamic Properties of Nitrogen for Temperatures from 63.151 to 1000 K and Pressures to 2200 MPa , 2000 .

[10]  Shuang-Ying Wu,et al.  Numerical investigation on combined natural convection and radiation heat losses in one side open cylindrical cavity with constant heat flux , 2014 .

[11]  C. F. Hess,et al.  Experimental Investigation of Natural Convection Losses From Open Cavities , 1984 .

[12]  E. Lemmon,et al.  Viscosity and Thermal Conductivity Equations for Nitrogen, Oxygen, Argon, and Air , 2004 .

[13]  Lan Xiao,et al.  Experimental study on combined convective heat loss of a fully open cylindrical cavity under wind conditions , 2015 .

[14]  R. K. McMordie.  Convection heat loss from a cavity receiver , 1984 .

[15]  R. Y. Ma.  Wind effects on convective heat loss from a cavity receiver for a parabolic concentrating solar collector , 1993 .

[16]  Robert Pitz-Paal,et al.  On the influence of rotation on thermal convection in a rotating cavity for solar receiver applications , 2014 .

[17]  Joshua M. Christian,et al.  Numerical Simulation of Natural Convection in Solar Cavity Receivers , 2012 .

[18]  Shireesh B. Kedare,et al.  Investigations on heat losses from a solar cavity receiver , 2009 .

[19]  John Pye,et al.  Numerical Investigation of Natural Convection Loss From Cavity Receivers in Solar Dish Applications , 2011 .

[20]  A. M. Clausing,et al.  An analysis of convective losses from cavity solar central receivers , 1981 .

[21]  Sawat Paitoonsurikarn,et al.  Estimation of Convection Loss from Paraboloidal Dish Cavity Receivers , 2004 .

[22]  Robert Pitz-Paal,et al.  Numerical analysis of the influence of inclination angle and wind on the heat losses of cavity receivers for solar thermal power towers , 2014 .