Actuation potentials and capillary forces in electrowetting based microsystems

Abstract The minimum and maximum actuation voltages in electrowetting actuated microsystems are investigated in this paper. The minimum actuation voltage corresponds to the electric potential required to obtain motion of a droplet between two electrodes. Below this threshold, a droplet cannot be displaced due to contact angle hysteresis. The maximum actuation voltage corresponds to the electric potential above which there is no more gain in capillary forces because of the saturation effect. Based on the calculation of the electrocapillary forces on a drop in an EWOD system, and taking into account the contact angle hysteresis, an analytical relation is derived for the minimum actuation potential. On the other hand, the Peykov–Quinn–Ralston–Sedev model produces an approximate value of the maximum actuation voltage. Thus, a range of actuation potentials can be predicted depending on the liquid of the droplet, the surrounding gas or fluid and the nature of the solid substrate. The results of the two models are favorably compared with experimental results obtained using different liquids and substrates.

[1]  P. Sharma,et al.  Analysis of different approaches for evaluation of surface energy of microbial cells by contact angle goniometry. , 2002, Advances in colloid and interface science.

[2]  Neelesh A. Patankar,et al.  On the Modeling of Hydrophobic Contact Angles on Rough Surfaces , 2003 .

[3]  H. Uhm,et al.  Superhydrophobic CFx coating via in-line atmospheric RF plasma of He-CF4-H2. , 2005, Langmuir : the ACS journal of surfaces and colloids.

[4]  E. B. Dussan,et al.  LIQUIDS ON SOLID SURFACES: STATIC AND DYNAMIC CONTACT LINES , 1979 .

[5]  Olivier Raccurt,et al.  Mechanical behavior of micro-drops in EWOD systems: drop extraction, division, motion and constraining , 2005 .

[6]  Andreas G. Boudouvis,et al.  Manifestation of the connection between dielectric breakdown strength and contact angle saturation in electrowetting , 2005 .

[7]  B. Shapiro,et al.  Equilibrium behavior of sessile drops under surface tension, applied external fields, and material variations , 2003 .

[8]  P. Silberzan,et al.  Microfluidics for biotechnology , 2005 .

[9]  J. Baret,et al.  Electrowetting: from basics to applications , 2005 .

[10]  A. W. Neumann,et al.  On the question of rate-dependence of contact angles , 2006 .

[11]  R. Fair,et al.  Electrowetting-based actuation of liquid droplets for microfluidic applications , 2000 .

[12]  R. H. Dettre,et al.  Contact Angle Hysteresis: I. Study of an Idealized Rough Surface , 1964 .

[13]  Jun Zeng,et al.  Principles of droplet electrohydrodynamics for lab-on-a-chip. , 2004, Lab on a chip.

[14]  S. Cho,et al.  Low voltage electrowetting-on-dielectric , 2002 .

[15]  John Ralston,et al.  Electrowetting: a model for contact-angle saturation , 2000 .

[16]  George M. Whitesides,et al.  How to Make Water Run Uphill , 1992, Science.

[17]  W. A. Zisman,et al.  Relation of the Equilibrium Contact Angle to Liquid and Solid Constitution , 1964 .

[18]  Olivier Raccurt,et al.  Computer aided design of an EWOD microdevice , 2006 .

[19]  E. Ruckenstein,et al.  Microscopic interpretation of the dependence of the contact angle on roughness. , 2005, Langmuir.

[20]  T. Cubaud,et al.  Advancing contact lines on chemically patterned surfaces. , 2004, Journal of colloid and interface science.

[21]  W. Zisman,et al.  Contact angle, wettability, and adhesion , 1964 .

[22]  B. Widom.  Capillarity and Wetting Phenomena: Drops, Bubbles, Pearls, Waves , 2003 .

[23]  B. Berge,et al.  Limiting phenomena for the spreading of water on polymer films by electrowetting , 1999 .

[24]  J. McLaughlin,et al.  Motion of a drop on a solid surface due to a wettability gradient. , 2005, Langmuir : the ACS journal of surfaces and colloids.

[25]  M. Fermigier,et al.  An experimental investigation of the dynamic contact angle in liquid-liquid systems , 1991 .

[26]  H. Verheijen,et al.  REVERSIBLE ELECTROWETTING AND TRAPPING OF CHARGE : MODEL AND EXPERIMENTS , 1999, cond-mat/9908328.

[27]  B. Berge,et al.  Electrowetting : a recent outbreak , 2001 .

[28]  John Ralston,et al.  Contact angle saturation in electrowetting. , 2005, The journal of physical chemistry. B.

[29]  Kenneth A. Brakke,et al.  The Surface Evolver , 1992, Exp. Math..

[30]  S. Cho,et al.  Creating, transporting, cutting, and merging liquid droplets by electrowetting-based actuation for digital microfluidic circuits , 2003 .