A Survey of Research Performed at NASA Langley Research Center's Impact Dynamics Research Facility

The Impact Dynamics Research Facility (IDRF) is a 240-ft.-high gantry structure located at NASA Langley Research Center in Hampton, Virginia. The facility was originally built in 1963 as a lunar landing simulator, allowing the Apollo astronauts to practice lunar landings under realistic conditions. The IDRF was designated a National Historic Landmark in 1985 based on its significant contributions to the Apollo Program. In 1972, the facility was converted to a full-scale crash test facility for light aircraft and rotorcraft. Since that time, the IDRF has been used to perform a wide variety of impact tests on fullscale aircraft and structural components in support of the General Aviation (GA) aircraft industry, the US Department of Defense, the rotorcraft industry, and NASA in-house aeronautics and space research programs. The objective of this paper is to describe most of the major full-scale crash test programs that were performed at this unique, world-class facility since 1974. The past research is divided into six sub-topics: the civil GA aircraft test program, transport aircraft test program, military test programs, space test programs, basic research, and crash modeling and simulation.

[1]  Lisa E. Jones,et al.  Evaluation of Energy Absorption of New Concepts of Aircraft Composite Subfloor Intersections. , 1989 .

[2]  K. H. Lyle,et al.  Full-scale crash test and simulation of a composite helicopter , 2001 .

[3]  Karen E. Jackson,et al.  Simulation of Aircraft Landing Gears with a Nonlinear Dynamic Finite Element Code , 2002 .

[4]  Ted Belytschko,et al.  On Computational Methods for Crashworthiness , 1988 .

[5]  R. J. Hayduk.  COMPARATIVE ANALYSIS OF PA-31-350 CHIEFTAIN (N44LV) ACCIDENT AND NASA CRASH TEST DATA , 1979 .

[6]  Raphael T. Haftka,et al.  Optimal Design of Composite Fuselage Frames for Crashworthiness , 1996 .

[7]  Karen E. Jackson,et al.  Occupant Responses in a Full-Scale Crash Test of the Sikorsky ACAP Helicopter , 2004 .

[8]  M. S. Williams,et al.  Crash tests of four low-wing twin-engine airplanes with truss-reinforced fuselage structure , 1982 .

[9]  Sotiris Kellas,et al.  Design, Fabrication and Testing of a Crushable Energy Absorber for a Passive Earth Entry Vehicle , 2002 .

[10]  L Fasanella Edwin,et al.  Crash Simulation of a Vertical Drop Test of a B737 Fuselage Section With Overhead Bins and Luggage , 2001 .

[11]  H. D. Carden.  Correlation and assessment of structural airplane crash data with flight parameters at impact , 1982 .

[12]  Edwin L. Fasanella,et al.  Behavior of composite/metal aircraft structural elements and components under crash type loads: What are they telling us , 1990 .

[13]  LeRoy T. Burrows.  VERIFICATION TESTING OF A UH-1 WIRE STRIKE PROTECTION SYSTEM WSPS , 1982 .

[14]  Karen E. Jackson,et al.  Development of an ACAP Helicopter Finite Element Impact Model , 2000 .

[15]  R. J. Hayduk,et al.  Vertical drop test of a transport fuselage center section including the wheel wells , 1983 .

[16]  Lisa E. Jones,et al.  Overview of Structural Behavior and Occupant Responses from a Crash Test of a Composite Airplane , 1995 .

[17]  L Burrows,et al.  CH-47 Crash Test (T-40) Structural, Cargo Restraint, and Aircrew Inflatable Restraint Experiments , 1978 .

[18]  R. J. Hayduk.  Full-Scale Transport controlled Impact Demonstration , 1986 .

[19]  E. L. Fasanella,et al.  Comparison of Hard Surface and Soft Soil Impact Performance of a Crashworthy Composite Fuselage Concept , 2002 .

[20]  Robert J. Hayduk,et al.  Impact data from a transport aircraft during a controlled impact demonstration , 1986 .

[21]  George T. Singley,et al.  Full Scale Crash Testing Of A Ch-47C Helicopter , 1976 .

[22]  Louise A. Obergefell,et al.  Articulated Total Body Model Enhancements. Volume 2. User's Guide , 1988 .

[23]  Robert Winter,et al.  Investigation of the Crash-Impact Characteristics of Advanced Airframe Structures. , 1979 .

[24]  E. Alfaro-Bou,et al.  Light airplane crash tests at three flight-path angles , 1978 .

[25]  E Alfaro-Bou,et al.  Light Airplane Crash Tests at Impact Velocities of 13 and 27 m/sec , 1977 .

[26]  James D. Cronkhite,et al.  Special Report on Bell ACAP Full-Scale Aircraft Crash Test , 1987 .

[27]  M. Powers.  Material characterization of polyurethane foam under hydrostatic loading , 2002 .

[28]  E. Alfaro-Bou,et al.  Light airplane crash tests at three roll angles , 1979 .

[29]  Edwin L. Fasanella,et al.  Structural analysis of the controlled impact demonstration of a jet transport airplane , 1987 .

[30]  Ed Hooper,et al.  Beech Starship Occupant Protection Evaluation in Emergency Landing Scenario , 1989 .

[31]  R. J. Hayduk,et al.  Crash tests of four identical high-wing single-engine airplanes , 1980 .

[32]  Kent F Smith.  Full-Scale Crash Test (T-41) of the YAH-63 Attack Helicopter, , 1986 .

[33]  LeRoy T. Burrows.  Investigation of Helicopter Wire Strike Protection Concepts , 1980 .

[34]  J. D. Cronkhite,et al.  Bell ACAP Full-Scale Aircraft Crash Test and KRASH Correlation , 1988 .

[35]  James E. Terry.  Design and Test of an Improved Crashworthiness Small Composite Airframe , 2000 .

[36]  T. C. Obryan.  Flight tests of a manned rocket-powered vehicle utilizing the Langley Lunar Landing Research Facility. , 1966 .

[37]  Sotiris Kellas,et al.  Energy-absorbing-beam design for composite aircraft subfloors , 1993 .

[38]  Ahmed K. Noor,et al.  Computational Methods for Crashworthiness , 1993 .

[39]  Edwin L. Fasanella,et al.  Impact response of composite fuselage frames , 1987 .

[40]  Edwin L. Fasanella,et al.  Full-Scale Crash Test of the Sikorsky Advanced Composite Airframe Program Helicopter , 2000 .

[41]  Karen H. Lyle,et al.  Simulation of X-38 Landing Scenarios With Landing Gear Failures , 2000 .

[42]  E. Alfaro-Bou,et al.  Crash tests of three identical low-wing single-engine airplane , 1983 .

[43]  Edwin L. Fasanella,et al.  Impact Test and Simulation of Energy Absorbing Concepts for Earth Entry Vehicles , 2001 .

[44]  Karen E. Jackson.  Analytical Crash Simulation of Three Composite Fuselage Concepts and Experimental Correlation , 1997 .

[45]  R. J. Hayduk,et al.  Vertical drop test of a transport fuselage section located forward of the wing , 1983 .

[46]  E. Alfaro-Bou,et al.  Light airplane crash tests at three pitch angles , 1979 .

[47]  D. E. Hewes,et al.  Operational features of the Langley Lunar Landing Research Facility , 1967 .

[48]  M Puso,et al.  NIKE3D a nonlinear, implicit, three-dimensional finite element code for solid and structural mechanics user's manual update summary , 1991 .

[49]  Bryan Paul Pilati,et al.  Active Crew Restraint Demonstration , 1994 .

[50]  R A Mitcheltree,et al.  A Passive Earth-Entry Capsule for Mars Sample Return , 1998 .

[51]  Peter R. Payne,et al.  DYNAMIC MODELS OF THE HUMAN BODY , 1969 .

[52]  Alan E. Stockwell.  Simulation of an Impact Test of the All-Composite Lear Fan Aircraft , 2002 .

[53]  K E Jackson,et al.  Impact Testing and Simulation of a Crashworthy Composite Fuselage Section with Energy-Absorbing Seats and Dummies , 2000 .

[54]  Huey D. Carden.  Impulse Analysis of Airplane Crash Data with Consideration Given to Human Tolerance , 1983 .

[55]  Edwin L. Fasanella,et al.  Development of a Crashworthy Composite Fuselage Concept , 2000 .

[56]  Thomas O-Bryan.  FLIGHT TESTS OF A MANNED RCCKET-POWERED VEHICLE UTILIZING , 1966 .

[57]  Edwin L. Fasanella,et al.  Development of a Scale Model Composite Fuselage Concept for Improved Crashworthiness , 2001 .

[58]  E. Alfaro-Bou,et al.  Impact dynamics research facility for full-scale aircraft crash testing , 1976 .

[59]  Edwin L. Fasanella,et al.  Water Impact Test and Simulation of a Composite Energy Absorbing Fuselage Section , 2005 .

[60]  A. Pifko,et al.  DYCAST, A FINITE ELEMENT PROGRAM FOR THE CRASH ANALYSIS OF STRUCTURES , 1987 .

[61]  E. L. Fasanella,et al.  Vertical drop test of a transport fuselage section located aft of the wing , 1986 .

[62]  Whirley.  DYNA3D: A nonlinear, explicit, three-dimensional finite element code for solid and structural mechanics , 1993 .

[63]  Edwin L. Fasanella,et al.  Crash Simulation of Vertical Drop Tests of Two Boeing 737 Fuselage Sections , 2002 .