Theoretical investigation of the diameter effect on flooding in countercurrent flow

Calculations have been performed using the CFDS-FLOW3D computational fluid dynamics code to determine the force exerted on a standing wave by gas flowing over it. It is found that the drag on the wave is mainly due to the pressure variation around it and that it is a strong function of the channel dimensions. Extension of these results to typical flooding conditions in countercurrent flow in vertical tubes shows that the gas velocity required to transport waves upwards increases significantly as the tube diameter increases. It is suggested therefore that the mechanism of flooding depends on the diameter of the tube and that flooding is induced by upward transport of waves from near the bottom of the tube in small diameter tubes whereas in large diameter tubes, it may occur due to entrainment and carryover of droplets near the liquid entry.

[1]  John F. Davidson,et al.  The investigation of a standing wave due to gas blowing upwards over a liquid film; its relation to flooding in wetted-wall columns , 1965, Journal of Fluid Mechanics.

[2]  F. White.  Viscous Fluid Flow , 1974 .

[3]  Tatsuhiro Ueda,et al.  Behaviour of liquid films and flooding in counter-current two-phase flow—Part 1. Flow in circular tubes , 1977 .

[4]  Geoffrey F. Hewitt,et al.  Flooding and churn flow in vertical pipes , 1991 .

[5]  A. E. Dukler,et al.  Modelling flow pattern transitions for steady upward gas‐liquid flow in vertical tubes , 1980 .

[6]  H. Tuomisto,et al.  Air/water countercurrent flow limitation experiments with full-scale fuel bundle structures , 1990 .

[7]  Geoffrey F. Hewitt,et al.  Flooding in vertical two-phase flow , 1985 .

[8]  Sang Chun Lee,et al.  A CRITICAL REVIEW OF THE FLOODING LITERATURE , 1986 .

[9]  P. Bradshaw,et al.  Turbulence Models and Their Application in Hydraulics. By W. RODI. International Association for Hydraulic Research, Delft, 1980. Paperback US $15. , 1983, Journal of Fluid Mechanics.

[10]  Colin Pritchard,et al.  EFFECT OF VISCOSITY ON FLOODING CONDITIONS IN WETTED WALL COLUMNS , 1966 .

[11]  Hideaki Imura,et al.  Flooding velocity in a counter-current annular two-phase flow , 1977 .

[12]  W. Jones,et al.  The prediction of laminarization with a two-equation model of turbulence , 1972 .

[13]  Milton Biage.  Structure de la surface libre d'un film liquide ruisselant sur une plaque plane verticale et soumis à un contre-courant de gaz : transition vers l'écoulement cocourant ascendant , 1989 .

[14]  Alastair Hamilton Govan.  Modelling of vertical annular and dispersed two-phase flows , 1990 .

[15]  A. E. Dukler,et al.  Countercurrent gas‐liquid annular flow, including the flooding state , 1988 .

[16]  W. Nusselt.  Die Oberflachenkondensation des Wasserdampfes , 1916 .

[17]  B. Launder,et al.  Application of the energy-dissipation model of turbulence to the calculation of flow near a spinning disc , 1974 .

[18]  G. B. Wallis,et al.  The Hanging Film Phenomenon in Vertical Annular Two-Phase Flow , 1974 .