Effect of biodiesel fuels on diesel engine emissions

The call for the use of biofuels which is being made by most governments following international energy policies is presently finding some resistance from car and components manufacturing companies, private users and local administrations. This opposition makes it more difficult to reach the targets of increased shares of use of biofuels in internal combustion engines. One of the reasons for this resistance is a certain lack of knowledge about the effect of biofuels on engine emissions. This paper collects and analyzes the body of work written mainly in scientific journals about diesel engine emissions when using biodiesel fuels as opposed to conventional diesel fuels. Since the basis for comparison is to maintain engine performance, the first section is dedicated to the effect of biodiesel fuel on engine power, fuel consumption and thermal efficiency. The highest consensus lies in an increase in fuel consumption in approximate proportion to the loss of heating value. In the subsequent sections, the engine emissions from biodiesel and diesel fuels are compared, paying special attention to the most concerning emissions: nitric oxides and particulate matter, the latter not only in mass and composition but also in size distributions. In this case the highest consensus was found in the sharp reduction in particulate emissions.

[1]  C. D. Rakopoulos,et al.  Performance and emissions of bus engine using blends of diesel fuel with bio-diesel of sunflower or cottonseed oils derived from Greek feedstock , 2008 .

[2]  Susan T. Bagley,et al.  EFFECTS OF AN OXIDATION CATALYTIC CONVERTER AND A BIODIESEL FUEL ON THE CHEMICAL, MUTAGENIC, AND PARTICLE SIZE CHARACTERISTICS OF EMISSIONS FROM A DIESEL ENGINE , 1998 .

[3]  L. G. Schumacher,et al.  Biodiesel emissions data from Series 60 DDC engines. , 2001 .

[4]  S. Jayaraj,et al.  Performance and emission evaluation of a diesel engine fueled with methyl esters of rubber seed oil , 2005 .

[5]  Magín Lapuerta,et al.  Composition and size of diesel particulate emissions from a commercial European engine tested with present and future fuels , 2003 .

[6]  N. Clark,et al.  Emissions from nine heavy trucks fueled by diesel and biodiesel blend without engine modification , 2000 .

[7]  M Canakci,et al.  Performance and emissions characteristics of biodiesel from soybean oil , 2005 .

[8]  Michael Krüger,et al.  Emissions and Performance Characteristics of a 4-Stroke, Direct Injected Diesel Engine Fueled with Blends of Biodiesel and Low Sulfur Diesel Fuel , 1995 .

[9]  Jon H. Van Gerpen,et al.  The Effect of Biodiesel Fuel Composition on Diesel Combustion and Emissions , 1996 .

[10]  N. Vedaraman,et al.  Performance and emission study of Mahua oil (madhuca indica oil) ethyl ester in a 4-stroke natural aspirated direct injection diesel engine , 2005 .

[11]  Arántzazu Gómez,et al.  Uncertainties in the determination of particle size distributions using a mini tunnel–SMPS system during Diesel engine testing , 2007 .

[12]  Rsg Rik Baert,et al.  Oxygenated fuels for clean heavy duty engines , 2004 .

[13]  B. Buchholz,et al.  A Numerical Investigation into the Anomalous Slight NOx Increase when Burning Biodiesel: A New (Old) Theory , 2007 .

[14]  C. Westbrook,et al.  Diesel combustion: an integrated view combining laser diagnostics, chemical kinetics, and empirical validation , 1999 .

[15]  Juhun Song,et al.  Combustion and emissions performance of low sulfur, ultra low sulfur and biodiesel blends in a DI diesel engine , 2004 .

[16]  J. H. Van Gerpen,et al.  The effect of timing and oxidation on emissions from biodiesel-fueled engines. , 2001 .

[17]  H. A. Soliman,et al.  Effects of diluent admissions and intake air temperature in exhaust gas recirculation on the emissions of an indirect injection dual fuel engine , 2001 .

[18]  D. Kittelson.  Engines and nanoparticles: a review , 1998 .

[19]  Cherng-Yuan Lin,et al.  Effects of emulsification variables on fuel properties of two- and three-phase biodiesel emulsions , 2007 .

[20]  Cole Boulevard,et al.  Measurement of Biodiesel Speed of Sound and Its Impact on Injection Timing , 2003 .

[21]  Mhia Md. Zaglul Shahadat,et al.  Behavior of Diesel Combustion and Exhaust Emission with Neat Diesel Fuel and Diesel-Biodiesel Blends , 2004 .

[22]  Chung-Hsing Wu,et al.  EMISSIONS OF SUBMICRON PARTICLES FROM A DIRECT INJECTION DIESEL ENGINE BY USING BIODIESEL , 2002, Journal of environmental science and health. Part A, Toxic/hazardous substances & environmental engineering.

[23]  S. Alfuso,et al.  The Effect of Methyl-Ester of Rapeseed Oil on Combustion and Emissions of DI Diesel Engines , 1993 .

[24]  Ridvan Arslan,et al.  Performance Characteristics of Sunflower Methyl Esters as Biodiesel , 2006 .

[25]  Mustafa Ertunc Tat,et al.  Physical Properties and Composition Detection of Biodiesel-diesel Fuel Blends , 2002 .

[26]  Mahabubul Alam,et al.  Fuel Formulation Effects on Diesel Fuel Injection, Combustion, Emissions and Emission Control , 2003 .

[27]  L. G. Schumacher,et al.  Engine Exhaust Emissions Evaluation of a Cummins L10E When Fueled with a Biodiesel Blend , 1995 .

[28]  O. Armas,et al.  Fuel Formulation Effects on Passenger Car Diesel Engine Particulate Emissions and Composition , 2000 .

[29]  Kazunori Hamasaki,et al.  (3-09) Combustion Characteristics of Diesel Engines with Waste Vegetable Oil Methyl Ester((AF-3)Alternative Fuels 3-Biomass Fuels and Fuel Design) , 2001 .

[30]  Rolf D. Reitz,et al.  Effects of Biodiesel Blended Fuels and Multiple Injections on D. I. Diesel Engines , 1997 .

[31]  Vicente R. Bermudez Tamarit,et al.  Efecto de la composición del gas-oil sobre las emisiones contaminantes , 2003 .

[32]  Christopher A. Sharp,et al.  The Effect of Biodiesel Fuels on Transient Emissions from Modern Diesel Engines, Part II Unregulated Emissions and Chemical Characterization , 2000 .

[33]  Juhun Song,et al.  Impact of Biodiesel Blending on Diesel Soot and the Regeneration of Particulate Filters , 2005 .

[34]  Mustafa Ertunc Tat,et al.  Investigation of oxides of nitrogen emissions from biodiesel-fueled engines , 2003 .

[35]  A. Spataru,et al.  Emissions and engine performance from blends of soya and canola methyl esters with ARB #2 diesel in a DDC 6V92TA MUI engine , 1996 .

[36]  Dennis L. Siebers,et al.  Effects of Oxygenates on Soot Processes in DI Diesel Engines: Experiments and Numerical Simulations , 2003 .

[37]  David B Kittelson,et al.  Characteristics of SME biodiesel-fueled diesel particle emissions and the kinetics of oxidation. , 2006, Environmental science & technology.

[38]  Vittorio Rocco,et al.  A Comparative Analysis of Combustion Process in D.I. Diesel Engine Fueled with Biodiesel and Diesel Fuel , 2000 .

[39]  Koji Yamane,et al.  Influence of physical and chemical properties of biodiesel fuels on injection, combustin and exhaust emission characteristics in a direct injection compression ignition engine , 2001 .

[40]  Cumali İlkılıç,et al.  Effect of Cotton Seed Oil Methyl Ester on the Performance and Exhaust Emission of a Diesel Engine , 2006 .

[41]  M. Gambino,et al.  Emission comparison of urban bus engine fueled with diesel oil and 'biodiesel' blend. , 2004, The Science of the total environment.

[42]  A. Charlet,et al.  Etude comparative des émissions d'un moteur diesel fonctionnant au gazole et différentes huiles végétales , 1993 .

[43]  M. Gürü,et al.  Alternative fuel properties of tall oil fatty acid methyl ester-diesel fuel blends. , 2007, Bioresource technology.

[44]  Athanasios Tsolakis,et al.  Effects on Particle Size Distribution from the Diesel Engine Operating on RME-Biodiesel with EGR , 2006 .

[45]  J. V. Gerpen,et al.  The effect of biodiesel oxidation on engine performance and emissions , 2001 .

[46]  C. Peterson,et al.  Emissions Testing with Blends of Esters of Rapeseed Oil Fuel With and Without a Catalytic Converter , 1996 .

[47]  Robert L. McCormick,et al.  Transient Emissions from No. 2 Diesel and Biodiesel Blends in a DDC Series 60 Engine , 1996 .

[48]  A. S. Cheng,et al.  Investigation of the impact of biodiesel fuelling on NO x emissions using an optical direct injection diesel engine , 2006 .

[49]  Thomas D Durbin,et al.  Effects of biodiesel blends and Arco EC-diesel on emissions from light heavy-duty diesel vehicles. , 2001, Environmental science & technology.

[50]  Rolf D. Reitz,et al.  A Numerical Analysis of the Emissions Characteristics of Biodiesel Blended Fuels , 1999 .

[51]  T. W. Ryan,et al.  Exhaust Emissions of Biodiesel, Petrodiesel, Neat Methyl Esters, and Alkanes in a New Technology Engine† , 2006 .

[52]  Konstantinos Boulouchos,et al.  Influence of diesel engine combustion parameters on primary soot particle diameter. , 2005, Environmental science & technology.

[53]  Jon H. Van Gerpen,et al.  Determination of particulate and unburned hydrocarbon emissions from diesel engines fueled with biodiesel , 1998 .

[54]  Vittorio Rocco,et al.  Brassica carinata as an alternative oil crop for the production of biodiesel in Italy: engine performance and regulated and unregulated exhaust emissions. , 2002, Environmental science & technology.

[55]  Dimitrios T. Hountalas,et al.  Operational and Environmental Evaluation of Diesel Engines Burning Oxygen-Enriched Intake Air or Oxygen-Enriched Fuels: A Review , 2004 .

[56]  J. Krahl,et al.  Cytotoxic and mutagenic effects, particle size and concentration analysis of diesel engine emissions using biodiesel and petrol diesel as fuel , 2000, Archives of Toxicology.

[57]  Mustafa Ertunc Tat,et al.  SPRAY, IGNITION, AND COMBUSTION MODELING OF BIODIESEL FUELS FOR INVESTIGATING NOX EMISSIONS , 2005 .

[58]  Walker Kc.  Biodiesel from rapeseed. , 1994 .

[59]  J. C. Thompson,et al.  The effect of biodiesel feedstock on regulated emissions in chassis dynamometer tests of a pickup truck. , 1999 .

[60]  Avinash Kumar Agarwal,et al.  Biofuels (alcohols and biodiesel) applications as fuels for internal combustion engines , 2007 .

[61]  Jim O. Olsson,et al.  Oxidation of rapeseed oil, rapeseed methyl ester (RME) and diesel fuel studied with GC/MS , 1999 .

[62]  Thomas D. Durbin,et al.  Effects of Biodiesel, Biodiesel Blends, and a Synthetic Diesel on Emissions from Light Heavy-Duty Diesel Vehicles , 2000 .

[63]  Juhun Song,et al.  Comparison of the Impact of Intake Oxygen Enrichment and Fuel Oxygenation on Diesel Combustion and Emissions , 2004 .

[64]  André L. Boehman,et al.  NOx emissions of alternative diesel fuels: A comparative analysis of biodiesel and FT diesel , 2005 .

[65]  K. F. Hansen,et al.  Chemical and Biological Characteristics of Exhaust Emissions from a DI Diesel Engine Fuelled With Rapeseed Oil Methyl Ester (RME) , 1997 .

[66]  Evripidis Lois,et al.  Definition of biodiesel , 2007 .

[67]  N. Usta.  An experimental study on performance and exhaust emissions of a diesel engine fuelled with tobacco seed oil methyl ester , 2005 .

[68]  E. Torres,et al.  Biodiesel: an overview , 2005 .

[69]  A. Shaheed,et al.  Combustion analysis of coconut oil and its methyl esters in a diesel engine , 1999 .

[70]  Norman Y. Kado,et al.  Chemical and Bioassay Analyses of Diesel and Biodiesel Particulate Matter: Pilot Study , 1996 .

[71]  Juhun Song,et al.  Spray and combustion visualization of a direct-injection diesel engine operated with oxygenated fuel blends , 2006 .

[72]  Juhun Song,et al.  Examination of the oxidation behavior of biodiesel soot , 2006 .

[73]  Robert L. Mason,et al.  Effects of Cetane Number, Cetane Improver, Aromatics, and Oxygenates on 1994 Heavy-Duty Diesel Engine Emissions , 1994 .

[74]  P. Gateau,et al.  The Effects of Rapeseed Oil Methyl Ester on Diesel Engine Performance, Exhaust Emissions and Long-Term Behavior - A Summary of Three Years of Experimentation , 1995 .

[75]  G. Labeckas,et al.  THE EFFECT OF RAPESEED OIL METHYL ESTER ON DIRECT INJECTION DIESEL ENGINE PERFORMANCE AND EXHAUST EMISSIONS , 2006 .

[76]  Hua Zhao,et al.  Soot generation of diesel fuels with substantial amounts of oxygen-bearing compounds added , 2007 .

[77]  Cristian Carraretto,et al.  Biodiesel as alternative fuel: Experimental analysis and energetic evaluations , 2004 .

[78]  Axel Munack,et al.  Influence of Biodiesel and Different Designed Diesel Fuels on the Exhaust Gas Emissions and Health Effects , 2003 .

[79]  Y. Lue,et al.  THE EMISSION CHARACTERISTICS OF A SMALL D.I. DIESEL ENGINE USING BIODIESEL BLENDED FUELS , 2001, Journal of environmental science and health. Part A, Toxic/hazardous substances & environmental engineering.

[80]  Cole Boulevard.  The Effect of Biodiesel Composition on Engine Emissions from a DDC Series 60 Diesel Engine , 2003 .

[81]  Md. Nurun Nabi,et al.  Improvement of engine emissions with conventional diesel fuel and diesel-biodiesel blends. , 2006, Bioresource technology.

[82]  Dennis Y.C. Leung,et al.  Optimization of Exhaust Emissions of a Diesel Engine Fuelled with Biodiesel , 2006 .

[83]  Vincent Mahieu,et al.  Well-to-wheels analysis of future automotive fuels and powertrains in the european context , 2004 .

[84]  Jon H. Van Gerpen,et al.  Fuel Properties and Engine Performance for Biodiesel Prepared from Modified Feedstocks , 1997 .

[85]  T. Foglia,et al.  Fuel properties and nitrogen oxide emission levels of biodiesel produced from animal fats , 2005 .

[86]  D. Haworth,et al.  Premixed ignition behavior of alternative diesel fuel-relevant compounds in a motored engine experiment , 2007 .

[87]  J. H. Van Gerpen,et al.  COMPARISON OF ENGINE PERFORMANCE AND EMISSIONS FOR PETROLEUM DIESEL FUEL, YELLOW GREASE BIODIESEL, AND SOYBEAN OIL BIODIESEL , 2003 .

[88]  Evripidis Lois,et al.  Effect of Biodiesel Addition to Diesel Fuel on Engine Performance and Emissions , 1999 .

[89]  Fernando Neto da Silva,et al.  Technical feasibility assessment of oleic sunflower methyl ester utilisation in Diesel bus engines. , 2003 .

[90]  M. D. Cardenas,et al.  Reduction of diesel smoke opacity from vegetable oil methyl esters during transient operation , 2006 .

[91]  Tser-Son Wu,et al.  Comparison of PAH and regulated harmful matter emissions from biodiesel blends and paraffinic fuel blends on engine accumulated mileage test , 2006 .

[92]  Charles J. Mueller,et al.  Using Carbon-14 Isotope Tracing to Investigate Molecular Structure Effects of the Oxygenate Dibutyl Maleate on Soot Emissions from a DI Diesel Engine , 2004 .

[93]  Peter Tritthart,et al.  Diesel fuel derived from vegetable oils, III. Emission tests using methyl esters of used frying oil , 1988 .

[94]  L. G. Schumacher,et al.  Review: Utilization of Rapeseed Oil, Rapeseed Oil Methyl Ester or Diesel Fuel: Exhaust Gas Emissions and Estimation of Environmental Effects , 1996 .

[95]  Robert L. McCormick,et al.  Regulated Emissions from Biodiesel Tested in Heavy-Duty Engines Meeting 2004 Emission Standards , 2005 .

[96]  Octavio Armas,et al.  Diesel emissions from biofuels derived from Spanish potential vegetable oils , 2005 .

[97]  Avinash Kumar Agarwal,et al.  Biodiesel Development and Characterization for Use as a Fuel in Compression Ignition Engines , 2001 .

[98]  José Luis Míguez,et al.  Performance and exhaust emissions in the use of biodiesel in outboard diesel engines , 2007 .

[99]  M. Babu,et al.  Biodiesel development from high acid value polanga seed oil and performance evaluation in a CI engine , 2007 .

[100]  Cole Boulevard,et al.  Bioassay Analyses of Particulate Matter From a Diesel Bus Engine Using Various Biodiesel Feedstock Fuels , 2003 .

[101]  Octavio Armas,et al.  Diesel Particulate Emissions from Biofuels Derived from Spanish Vegetable Oils , 2002 .

[102]  Octavio Armas,et al.  Scrubbing effect on diesel particulate matter from transesterified waste oils blends , 2006 .

[103]  Filiz Karaosmanoglu,et al.  Engine and winter road test performances of used cooking oil originated biodiesel. , 2005 .

[104]  J. Dec.  A Conceptual Model of DI Diesel Combustion Based on Laser-Sheet Imaging* , 1997 .

[105]  M. Muñoz,et al.  Emissions of an automobile diesel engine fueled with sunflower methyl ester , 2004 .

[106]  Robert L. McCormick,et al.  Evaluation of formulation strategies to eliminate the biodiesel NOx effect , 2005 .

[107]  Magín Lapuerta,et al.  Diesel particulate emissions from used cooking oil biodiesel. , 2008, Bioresource technology.

[108]  T. Alleman,et al.  Engine Performance of Biodiesel Fuel Prepared from Soybean Soapstock: A High Quality Renewable Fuel Produced from a Waste Feedstock‖ , 2001 .

[109]  Xianming Shi,et al.  Emission characteristics using methyl soyate-ethanol-diesel fuel blends on a diesel engine , 2005 .

[110]  Robert L. McCormick,et al.  Combustion of fat and vegetable oil derived fuels in diesel engines , 1998 .

[111]  O. M. I. Nwafor,et al.  Emission characteristics of diesel engine operating on rapeseed methyl ester , 2004 .

[112]  M. P. Dorado,et al.  EXHAUST EMISSIONS FROM A DIESEL ENGINE FUELED WITH TRANSESTERIFIED WASTE OLIVE OIL , 2003 .

[113]  Michael J. Haas,et al.  Effect of Antioxidant Addition on NOx Emissions from Biodiesel , 2005 .