Characterizing the cyclic variability of ignition timing in a homogeneous charge compression ignition engine fuelled with n-heptane/iso-octane blend fuels

Abstract The cyclic variations of homogeneous charge compression ignition (HCCI) ignition timing is studied for a range of charge properties by varying the equivalence ratio, intake temperature, intake pressure, exhaust gas recirculation (EGR) rate, engine speed, and coolant temperature. Characterization of cyclic variations of ignition timing in HCCI at over 430 operating points on two single-cylinder engines for five different blends of primary reference fuel (PRF), (iso-octane and n-heptane) is performed. Three distinct patterns of cyclic variation for the start of combustion (SOC), combustion peak pressure (Pmax), and indicated mean effective pressure (i.m.e.p.) are observed. These patterns are normal cyclic variations, periodic cyclic variations, and cyclic variations with weak/misfired ignitions. Results also show that the position of SOC plays an important role in cyclic variations of HCCI combustion with less variation observed when SOC occurs immediately after top dead centre (TDC). Higher levels of cyclic variations are observed in the main (second) stage of HCCI combustion compared with that of the first stage for the PRF fuels studied. The sensitivity of SOC to different charge properties varies. Cyclic variation of SOC increases with an increase in the EGR rate, but it decreases with an increase in equivalence ratio, intake temperature, and coolant temperature.

[1]  Lloyd Withrow,et al.  Motion Pictures of Engine Flames Correlated with Pressure Cards , 1938 .

[2]  Takehisa Yamaguchi,et al.  Factors Influencing the Cyclic Variation of Combustion of Spark Ignition Engine , 1971 .

[3]  M. D. Checkel,et al.  Computerized knock detection from engine pressure records , 1986 .

[4]  John B. Heywood,et al.  Internal combustion engine fundamentals , 1988 .

[5]  Volker Beushausen,et al.  A Major Origin of Cyclic Energy Conversion Variations in SI Engines: Cycle-by-Cycle Variations of the Equivalence Ratio and Residual Gas of the Initial Charge , 1994 .

[6]  E. Sher,et al.  Cyclic Variability in Spark Ignition Engines A Literature Survey , 1994 .

[7]  Bengt Johansson,et al.  CYCLE TO CYCLE VARIATIONS IN S.I. ENGINES : THE EFFECTS OF FLUID FLOW AND GAS COMPOSITION IN THE VICINITY OF THE SPARK PLUG ON EARLY COMBUSTION , 1996 .

[8]  Martin Berzins,et al.  End Gas Inhomogeneity, Autoignition and Knock , 1998 .

[9]  Federico Millo,et al.  KNOCK IN S.I. ENGINES : A COMPARISON BETWEEN DIFFERENT TECHNIQUES FOR DETECTION AND CONTROL , 1998 .

[10]  Rudolf H. Stanglmaier,et al.  Homogeneous charge compression ignition (HCCI): Benefits, compromises, and future engine applications , 1999 .

[11]  Bengt Johansson,et al.  A Study of the Homogeneous Charge Compression Ignition Combustion Process by Chemiluminescence Imaging , 1999 .

[12]  Bengt Johansson,et al.  The Influence of Charge Inhomogeneity on the HCCI Combustion Process , 2000 .

[13]  Robert W. Dibble,et al.  Operation of a Four-Cylinder 1.9L Propane Fueled Homogeneous Charge Compression Ignition Engine: Basic Operating Characteristics and Cylinder-to-Cylinder Effects , 2001 .

[14]  N Ladommatos,et al.  Understanding of controlled autoignition combustion in a four-stroke gasoline engine , 2001 .

[15]  Lucien Koopmans,et al.  Cycle to Cycle Variations: Their Influence on Cycle Resolved Gas Temperature and Unburned Hydrocarbons from a Camless Gasoline Compression Ignition Engine , 2002 .

[16]  Scott B. Fiveland,et al.  Compression Ratio Influence on Maximum Load of a Natural Gas Fueled HCCI Engine , 2002 .

[17]  D. Assanis,et al.  Homogeneous Charge Compression Ignition (HCCI) Engines , 2003 .

[18]  John B. Heywood,et al.  Two-stage ignition in HCCI combustion and HCCI control by fuels and additives , 2003 .

[19]  Johan Bengtsson,et al.  Closed-Loop Control of HCCI Engine Dynamics , 2004 .

[20]  Mingfa Yao,et al.  The Effect of PRF Fuel Octane Number on HCCI Operation , 2004 .

[21]  Dennis N. Assanis,et al.  Comparing Enhanced Natural Thermal Stratification Against Retarded Combustion Phasing for Smoothing of HCCI Heat-Release Rates , 2004 .

[22]  Norimasa Iida,et al.  Analysis of the Effect of Charge Inhomogeneity on HCCI Combustion by Chemiluminescence Measurement , 2004 .

[23]  A. Megaritis,et al.  Applying boosting to gasoline HCCI operation with residual gas trapping , 2005 .

[24]  Nicholas P. Cernansky,et al.  Potential of Thermal Stratification and Combustion Retard for Reducing Pressure-Rise Rates in HCCI Engines, Based on Multi-Zone Modeling and Experiments , 2005 .

[25]  Wei Chen,et al.  Study on the Ignition, Combustion and Emissions of HCCI Combustion Engines Fueled With Primary Reference Fuels , 2005 .

[26]  Charles Robert Koch,et al.  The effect of fuel octane and dilutent on homogeneous charge compression ignition combustion , 2005 .

[27]  Zoran Filipi,et al.  Characterizing the thermal sensitivity of a gasoline homogeneous charge compression ignition engine with measurements of instantaneous wall temperature and heat flux , 2005 .

[28]  Robert M. Wagner,et al.  On the Nature of Cyclic Dispersion in Spark Assisted HCCI Combustion , 2006 .

[29]  Yannis Hardalupas,et al.  Autoignition Initiation and Development of n-heptane HCCI Combustion Assisted by Inlet Air Heating, Internal EGR or Spark Discharge: An Optical Investigation , 2006 .

[30]  G. Kalghatgi,et al.  Combustion Limits and Efficiency in a Homogeneous Charge Compression Ignition Engine , 2006 .

[31]  M. A. Ceviz,et al.  Cyclic variations on LPG and gasoline-fuelled lean burn SI engine , 2006 .

[32]  Ocktaeck Lim,et al.  The Research About the Effects of Thermal Stratification on n-Heptane/iso-Octane-Air Mixture HCCI Combustion Using a Rapid Compression Machine , 2006 .

[33]  Harry Lehtiniemi,et al.  Effect of Turbulence and Initial Temperature Inhomogeneity on Homogeneous Charge Compression Ignition Combustion , 2006 .

[34]  G. A. Karim,et al.  HCCI Combustion and Cyclic Variation for Lean Mixture Operation , 2006 .

[35]  J. Christian Gerdes,et al.  Modeling cycle-to-cycle dynamics and mode transition in HCCI engines with variable valve actuation , 2006 .

[36]  Anna G. Stefanopoulou,et al.  Stability Analysis in Homogeneous Charge Compression Ignition (HCCI) Engines With High Dilution , 2007, IEEE Transactions on Control Systems Technology.

[37]  Mahdi Shahbakhti,et al.  A SKELETAL KINETIC MECHANISM FOR PRF COMBUSTION IN HCCI ENGINES , 2007 .

[38]  Mahdi Shahbakhti,et al.  Cyclic Variations of Ignition Timing in an HCCI Engine , 2007 .

[39]  Robert M. Wagner,et al.  Understanding the transition between conventional spark-ignited combustion and HCCI in a gasoline engine , 2007 .

[40]  John E. Dec,et al.  Comparing late-cycle autoignition stability for single- and two-stage ignition fuels in HCCI engines , 2007 .

[41]  Huang Zhen,et al.  Experimental study on the cycle-by-cycle variations of homogeneous charge compression ignition combustion using primary reference fuels and their mixtures , 2007 .