A comprehensive study of dense-array concentrator photovoltaic system using non-imaging planar concentrator

A special modeling method using Simulink has been developed to analyze the electrical performance of dense-array concentrator photovoltaic (CPV) system. To optimize the performance of CPV system, we have adopted computational modeling method to design the best configuration of dense-array layout specially tailored for flux distribution profile of solar concentrator. It is an expeditious, efficient and cost effective approach to optimize any dense-array configuration for any solar concentrator. A prototype of non-imaging planar concentrator (NIPC) was chosen in this study for verifying the effectiveness of this method. Mismatch effects in dense array solar cells caused by non-uniform irradiance as well as sun-tracking error normally happens at the peripheral of the array. It is a crucial drawback that affects the electrical performance of CPV systems because maximum output power of the array is considerably reduced when a current–voltage (I–V) curve has many mismatch steps and thus leads to lower fill factor (FF) and conversion efficiency. The modeling method is validated by assembling, installing and field testing on an optimized configuration of solar cells with the NIPC prototype to achieve a conversion efficiency of 34.18%. The measured results are in close agreement with simulated results with a less than 3% deviation in maximum output power.

[1]  Kok-Keong Chong,et al.  Application of On-Axis General Sun-Tracking Formula in Open-Loop Sun-Tracking System for Achieving Tracking Accuracy of below 1 mrad , 2012 .

[2]  Kok-Keong Chong,et al.  Study of image quality of mirror via solar flux distribution measurement using a high speed optical scanner , 2011 .

[3]  Kok-Keong Chong,et al.  Study of automotive radiator cooling system for dense-array concentration photovoltaic system , 2012 .

[4]  A. Mette,et al.  A review and comparison of different methods to determine the series resistance of solar cells , 2007 .

[5]  G. Morrison,et al.  Compact Linear Fresnel Reflector solar thermal powerplants , 2000 .

[6]  Kok-Keong Chong,et al.  Novel Optical Scanner Using Photodiodes Array for Two-Dimensional Measurement of Light Flux Distribution , 2011, IEEE Transactions on Instrumentation and Measurement.

[7]  Kok-Keong Chong,et al.  General formula for on-axis sun-tracking system and its application in improving tracking accuracy of solar collector , 2009 .

[8]  M. Mehos,et al.  High concentration tests of a dense PV array using GaInP/GaAs/Ge triple-junction cells in the high flux solar furnace , 2003, 3rd World Conference onPhotovoltaic Energy Conversion, 2003. Proceedings of.

[9]  F. Chenlo,et al.  Experimental study of mismatch and shading effects in the I-V characteristic of a photovoltaic module , 2006 .

[10]  P. Hebert,et al.  Concentrator multijunction solar cell characteristics under variable intensity and temperature , 2008 .

[11]  Gerald Siefer,et al.  A method for using CPV modules as temperature sensors and its application to rating procedures , 2011 .

[12]  Aggelos Zacharopoulos,et al.  Chapter 15. Building Integration of High Concentration Photovoltaic Systems , 2015 .

[13]  J. Coventry.  Performance of a concentrating photovoltaic/thermal solar collector , 2005 .

[14]  P. Hebert,et al.  III–V multijunction solar cells for concentrating photovoltaics , 2009 .

[15]  D. C. Law,et al.  Band gap‐voltage offset and energy production in next‐generation multijunction solar cells , 2011 .

[16]  Kok-Keong Chong,et al.  Solar flux distribution analysis of Non-Imaging Planar Concentrator for the application in concentrator photovoltaic system , 2010, 2010 35th IEEE Photovoltaic Specialists Conference.

[17]  Kok-Keong Chong,et al.  Optical Characterization of Nonimaging Planar Concentrator for the Application in Concentrator Photovoltaic System , 2010 .

[18]  N. D. Kaushika,et al.  An investigation of mismatch losses in solar photovoltaic cell networks , 2007 .

[19]  V. Quaschning,et al.  Numerical simulation of current-voltage characteristics of photovoltaic systems with shaded solar cells , 1996 .

[20]  David Faiman,et al.  PETAL: a research pathway to fossil-competitive solar electricity , 2002, Conference Record of the Twenty-Ninth IEEE Photovoltaic Specialists Conference, 2002..

[21]  Kok-Keong Chong,et al.  Design and construction of non-imaging planar concentrator for concentrator photovoltaic system , 2009 .

[22]  Gilles Flamant,et al.  Very high fluxes for concentrating photovoltaics: Considerations from simple experiments and modeling , 2012 .

[23]  T. Fuyuki,et al.  Annual output estimation of concentrator photovoltaic systems using high-efficiency InGaP/InGaAs/Ge triple-junction solar cells based on experimental solar cell's characteristics and field-test meteorological data , 2006 .

[24]  Kok-Keong Chong,et al.  Study of residual aberration for non-imaging focusing heliostat , 2003 .

[25]  A. Kajihara,et al.  Model of photovoltaic cell circuits under partial shading , 2005, 2005 IEEE International Conference on Industrial Technology.

[26]  Seddik Bacha,et al.  Forecasting photovoltaic array power production subject to mismatch losses , 2010 .

[27]  A.W.R. Leitch,et al.  Investigation on the I-V characteristics of a high concentration, photovoltaic array , 2002, Conference Record of the Twenty-Ninth IEEE Photovoltaic Specialists Conference, 2002..

[28]  Syafaruddin,et al.  A comprehensive MATLAB Simulink PV system simulator with partial shading capability based on two-diode model , 2011 .

[29]  E. E. van Dyk,et al.  Current‐voltage characteristics of high‐concentration, photovoltaic arrays , 2005 .

[30]  Evan Franklin,et al.  Effects of highly non-uniform illumination distribution on electrical performance of solar cells , 2002 .

[31]  V. A. Grilikhes,et al.  Effect of nonuniform light intensity distribution on temperature coefficients of concentrator solar cells , 2003, 3rd World Conference onPhotovoltaic Energy Conversion, 2003. Proceedings of.

[32]  L. C. Chen,et al.  Non-Imaging, Focusing Heliostat , 2001 .

[33]  E. Karatepe,et al.  Development of a suitable model for characterizing photovoltaic arrays with shaded solar cells , 2007 .

[34]  I. Luque-Heredia,et al.  Photovoltaic concentration at the onset of its commercial deployment , 2006 .

[35]  C. R. Sullivan,et al.  Decrease in photovoltaic power output from ripple: Simple general calculation and effect of partial shading , 2011, 2011 Twenty-Sixth Annual IEEE Applied Power Electronics Conference and Exposition (APEC).

[36]  Yukiharu Uraoka,et al.  Evaluation of InGaP/InGaAs/Ge triple-junction solar cell and optimization of solar cell's structure focusing on series resistance for high-efficiency concentrator photovoltaic systems , 2006 .