Improvement of gas-sensing property by defect engineering in microwave-assisted synthesized 3D ZnO nanostructures

Abstract In this paper, 3D ZnO nanostructures were synthesized by microwave-assisted method, and an improvement of the gas-sensing property of the ZnO nanostructures by defect engineering was reported. The experimental results indicated that the urchin-like and flower-like ZnO nanostructures could be synthesized by tuning the dosage of urea, and the ethanol responses of the flower-like ZnO were higher than those of the urchin-like ones. Defect engineering in the flower-like ZnO nanostructures was used to further enhance the sensing responses, which was accomplished by post-treatment of the flower-like ZnO nanostructures with different calcination temperatures and atmospheres. Defect structures were characterized by PL, Raman, XPS and EPR techniques. Moreover, the possible sensing mechanism and the relationship between the sensing response and the content of defect were proposed. The flower-like ZnO annealed at 500 °C in N 2 had the most donor defects (zinc interstitial and oxygen vacancy) which were beneficial to the formation of active oxygen and ethoxy. The active oxygen would further interact with the ethoxy, and released electrons which resulted in the decrease of the resistance of sensor. Therefore, ZnO–N 2 had the highest response to ethanol.

[1]  Jun Zhang,et al.  Hierarchically Porous ZnO Architectures for Gas Sensor Application , 2009 .

[2]  Zili Wu,et al.  Surface structure dependence of selective oxidation of ethanol on faceted CeO2 nanocrystals , 2013 .

[3]  J. Lombardi,et al.  Multiphonon Resonant Raman Scattering and Photoinduced Charge-Transfer Effects at ZnO–Molecule Interfaces , 2012 .

[4]  F. Güell,et al.  Influence of the Annealing Atmosphere on the Performance of ZnO Nanowire Dye-Sensitized Solar Cells , 2013 .

[5]  C. Liu,et al.  Intrinsic sensing properties of the flower-like ZnO nanostructures , 2013 .

[6]  Xintai Su,et al.  Synthesis of flower-like 3D ZnO microstructures and their size-dependent ethanol sensing properties , 2012 .

[7]  Jun Wang,et al.  Fabrication of spindle-like ZnO architectures for highly sensitive gas sensors , 2013 .

[8]  P. Patil,et al.  Surfactant assisted low temperature synthesis of nanocrystalline ZnO and its gas sensing properties , 2010 .

[9]  Zhongchang Wang,et al.  Hollow, porous, and yttrium functionalized ZnO nanospheres with enhanced gas-sensing performances , 2013 .

[10]  M. Schubert,et al.  Infrared dielectric functions and phonon modes of high-quality ZnO films , 2003 .

[11]  Y. Ozaki,et al.  Cu, Mn doping effect to optical behavior and electronic structure of ZnO ceramic , 2013 .

[12]  A. Ng,et al.  Native Defects in ZnO: Effect on Dye Adsorption and Photocatalytic Degradation , 2013 .

[13]  J. Vohs,et al.  Reaction of ethanol on oxidized and metallic cobalt surfaces , 2011 .

[14]  C. Xie,et al.  Processing–microstructure–property correlations of gas sensors based on ZnO nanotetrapods , 2013 .

[15]  Wei Wang,et al.  Cr2O3-sensitized ZnO electrospun nanofibers based ethanol detectors , 2010 .

[16]  Ning Han,et al.  Evaluating the doping effect of Fe, Ti and Sn on gas sensing property of ZnO , 2010 .

[17]  Ning Han,et al.  Counterintuitive sensing mechanism of ZnO nanoparticle based gas sensors , 2010 .

[18]  Fa-min Liu,et al.  Effect of ammonia/zinc nitrate molar ratio on structural and optical properties of Al and Sb codoped ZnO nanorod ordered array thin films , 2012 .

[19]  Shoumin Zhang,et al.  ZnO nanorod gas sensor for ethanol detection , 2012 .

[20]  Jinhuai Liu,et al.  Large-scale synthesis of flowerlike ZnO nanostructure by a simple chemical solution route and its gas-sensing property , 2010 .

[21]  B. Wei,et al.  Photocatalytic properties of hierarchical ZnO flowers synthesized by a sucrose-assisted hydrothermal method , 2012 .

[22]  G. Fan,et al.  Theoretical study of BexZn1-xOBexZn1-xO alloys , 2007 .

[23]  M. S. Akhtar,et al.  Influence of seed layer treatment on low temperature grown ZnO nanotubes: Performances in dye sensitized solar cells , 2011 .

[24]  Zhong Lin Wang,et al.  One-dimensional ZnO nanostructures: Solution growth and functional properties , 2011 .

[25]  Guangsheng Guo,et al.  Synthesis, characterization and alcohol-sensing properties of rare earth doped In2O3 hollow spheres , 2013 .

[26]  Chandrakant D. Lokhande,et al.  LPG sensing properties of ZnO films prepared by spray pyrolysis method : Effect of molarity of precursor solution , 2007 .

[27]  Xianghong Liu,et al.  One-pot synthesis of Au-supported ZnO nanoplates with enhanced gas sensor performance , 2012 .

[28]  Jun Wang,et al.  Self-assembly of ZnO nanosheets into flower-like architectures and their gas sensing properties , 2013 .

[29]  Jin-Ming Wu,et al.  Gas-sensing property of a nitrogen-doped zinc oxide fabricated by combustion synthesis , 2013 .

[30]  Mintang Liu.  Synthesis of ZnO nanowires and applications as gas sensors , 2010 .

[31]  Zheng Lou,et al.  Controllable and enhanced HCHO sensing performances of different-shelled ZnO hollow microspheres , 2013 .

[32]  Jihuai Wu,et al.  Synthesis of hierarchically structured ZnO spheres by facile methods and their photocatalytic deNOx properties. , 2013, Journal of hazardous materials.

[33]  Dong Liu,et al.  Enhanced acetone gas-sensing performance of La2O3-doped flowerlike ZnO structure composed of nanorods , 2013 .

[34]  R. Ruffo,et al.  Macroporous WO3 thin films active in NH3 sensing: role of the hosted Cr isolated centers and Pt nanoclusters. , 2011, Journal of the American Chemical Society.

[35]  Mashkoor Ahmad,et al.  Morphology-controlled synthesis of ZnO 3D hierarchical structures and their photocatalytic performance , 2012 .

[36]  Mei Chen,et al.  Porous ZnO Polygonal Nanoflakes: Synthesis, Use in High-Sensitivity NO2 Gas Sensor, and Proposed Mechanism of Gas Sensing , 2011 .

[37]  Haijiao Zhang,et al.  Self-assembly fabrication of 3D flower-like ZnO hierarchical nanostructures and their gas sensing properties , 2012 .

[38]  A. Teplyakov,et al.  Surface species formed during thermal transformation of ethanol on ZnO powder , 2013 .

[39]  Jyhfu Lee,et al.  Strong metal-support interactions between gold nanoparticles and ZnO nanorods in CO oxidation. , 2012, Journal of the American Chemical Society.

[40]  K. Latham,et al.  Interaction of hydrogen with ZnO nanopowders—evidence of hydroxyl group formation , 2012, Nanotechnology.

[41]  Wei Liu,et al.  One-pot synthesis and gas sensing properties of ZnO mesoporous architectures , 2013 .

[42]  C. L. Cheung,et al.  Defect engineering in cubic cerium oxide nanostructures for catalytic oxidation. , 2011, Nano letters.

[43]  Jin Chang,et al.  Self-Assembled 3D ZnO Porous Structures with Exposed Reactive {0001} Facets and Their Enhanced Gas Sensitivity , 2013, Sensors.