Photosynthetic productivity of conical helical tubular photobioreactor incorporating Chlorella sorokiniana under field conditions.

The photosynthetic performance of a conical, helical tubular photobioreactor (HTP) incorporating Chlorella sorokiniana was investigated under conditions of high temperature and light intensity during midsummer in an outdoor environment. Although the culture medium temperature exceeded 40 degrees C for approximately 5 h each day, peaking at 47.5 degrees C under sunny conditions, a photosynthetic productivity of 30.0 g x m(-2) (installation area) x day(-1) and a photosynthetic efficiency of 8.66% [photosynthetically active radiation (PAR), 400-700 nm] were achieved. A maximum photosynthetic productivity of 33.2 g x m(-2) x day(-1) was achieved on a sunny day, when solar energy input was also maximal (11.5 MJ x m(-2) x day(-1) [PAR]). On the other hand, a maximum photosynthetic efficiency of 9.54% was obtained on a day that was rainy in the morning and cloudy in the afternoon, and there was relatively little solar energy input. The average daily photosynthetic efficiency over the two culture periods (August 4 to 7 and August 10 to 13, 1999) was 7.25%. Thus, a high level of photosynthetic performance was achieved in the conical HTP incorporating Chlorella sorokiniana despite the fact that culture medium temperature was not controlled. The use of Chlorella sorokiniana in the conical HTP should be a good choice to produce microalgal biomass during the summer under field conditions.

[1]  A. Vonshak,et al.  Photoadaptation, photoinhibition and productivity in the blue‐green alga, Spirulina platensis grown outdoors , 1992 .

[2]  B. Irwin,et al.  Caloric content of phytoplankton , 1973 .

[3]  A. Richmond,et al.  A new tubular reactor for mass production of microalgae outdoors , 1993, Journal of Applied Phycology.

[4]  Yuan-Kun Lee.  Enclosed bioreactors for the mass cultivation of photosynthetic microorganisms: the future trend , 1986 .

[5]  D. O. Hall,et al.  Photosynthetic production of the filamentous cyanobacteriumSpirulina platensis in a cone-shaped helical tubular photobioreactor , 1996, Applied Microbiology and Biotechnology.

[6]  G. Torzillo,et al.  A two‐plane tubular photobioreactor for outdoor culture of Spirulina , 1993, Biotechnology and bioengineering.

[7]  H. Saiki,et al.  Investigation of photobioreactor design for enhancing the photosynthetic productivity of microalgae. , 2000, Biotechnology and bioengineering.

[8]  Hiroshi Saiki,et al.  Development of a photobioreactor incorporating Chlorella sp. for removal of CO2 in stack gas , 1997 .

[9]  Yoshitomo Watanabe,et al.  High photosynthetic productivity of green microalga Chlorella sorokiniana , 2000, Applied biochemistry and biotechnology.

[10]  M. Tredici,et al.  From open ponds to vertical alveolar panels: the Italian experience in the development of reactors for the mass cultivation of phototrophic microorganisms , 1992, Journal of Applied Phycology.

[11]  T. Matsunaga,et al.  CO2 removal by high-density culture of a marine cyanobacterium synechococcus sp. using an improved photobioreactor employing light-diffusing optical fibers , 1992 .

[12]  C. Low,et al.  Productivity of outdoor algal cultures in enclosed tubular photobioreactor. , 1992, Biotechnology and bioengineering.

[13]  G. C. Zittelli,et al.  Efficiency of sunlight utilization: tubular versus flat photobioreactors , 1998, Biotechnology and bioengineering.

[14]  E. Laws,et al.  A study of the energetics and economics of microalgal mass culture with the marine chlorophyte Tetraselmis suecica: Implications for use of power plant stack gases , 1991, Biotechnology and bioengineering.

[15]  N. Ohmura,et al.  Isolation and determination of cultural characteristics of microalgae which functions under CO2 enriched atmosphere , 1992 .

[16]  H Saiki,et al.  Photosynthetic productivity of conical helical tubular photobioreactors incorporating Chlorella sp. under various culture medium flow conditions. , 2001, Biotechnology and bioengineering.