Theoretical and Numerical Investigation of Liquid-Gas Interface Location of Capillary Driven Flow During the Time Throughout Circular Microchannels

The main aim of this study is to find the best, most rapid, and the most accurate numerical method to find the liquid-gas interface of capillary driven flow during the time in circular Microchannels by using COMSOL Multiphysics software. Capillary driven flow by eliminating micropumps or any physical pressure gradient generators can make the microfluidic devices cheaper and more usable. Hence, by using this two-phase flow, the final costs of lots of microfluidic devices and lab-on-a-chip can significantly be decreased and help them to be commercialized. The first step to employing the capillary flow in these devices is the simulation of this flow inside the microchannels. One of the most common and valid software for this work is COMSOL Multiphysics; this fact reveals the importance of this study. In this research study, simulation results obtained by using two possible numerical methods in this software, for capillary flows of water and ethanol in two different circular micro channels, verified and compared with four other methods, which verified experimentally before. Finally, the most accurate and time-saving numerical method of this software will be specified. This appropriate technique can contribute to simulate microfluidic and lab-on-a-chip devices, which are made of different mechanical and electrical parts, in COMSOL Multiphysics software by choosing the best method.

[1]  J. Li,et al.  Numerical simulation of moving contact line problems using a volume-of-fluid method , 2001 .

[2]  B. Kirby.  Micro- and nanoscale fluid mechanics : transport in microfluidic devices , 2010 .

[3]  J. E. Hilliard,et al.  Free Energy of a Nonuniform System. I. Interfacial Free Energy , 1958 .

[4]  Gunilla Kreiss,et al.  A hybrid level-set Cahn–Hilliard model for two-phase flow , 2008 .

[5]  Catherine Xuereb,et al.  Modeling of Microfluidic Devices , 2013 .

[6]  B. Engquist,et al.  Discretization of Dirac delta functions in level set methods , 2005 .

[7]  S. Terry,et al.  A gas chromatographic air analyzer fabricated on a silicon wafer , 1979, IEEE Transactions on Electron Devices.

[8]  Marley Becerra,et al.  Simulation of microbubbles during the initial stages of breakdown in cyclohexane , 2013, 2013 Annual Report Conference on Electrical Insulation and Dielectric Phenomena.

[9]  J. Szekely,et al.  The rate of capillary penetration and the applicability of the washburn equation , 1971 .

[10]  Sara Zahedi,et al.  Delta function approximations in level set methods by distance function extension , 2010, J. Comput. Phys..

[11]  S. Herminghaus,et al.  Wetting: Statics and dynamics , 1997 .

[12]  G. Whitesides.  The origins and the future of microfluidics , 2006, Nature.

[13]  Junseok Kim.  Phase-Field Models for Multi-Component Fluid Flows , 2012 .

[14]  George L Batten.  Liquid imbibition in capillaries and packed beds , 1984 .

[15]  S. Cito.  Numerical and experimental study of flow and wall mass transfer rates in capillary driven flows in microfluidic channels , 2009 .

[16]  Zhmud,et al.  Dynamics of Capillary Rise. , 2000, Journal of colloid and interface science.

[17]  C. Patrick,et al.  Flash imprint lithography using a mask aligner: a method for printing nanostructures in photosensitive hydrogels , 2008 .

[18]  E. W. Washburn.  The Dynamics of Capillary Flow , 1921 .

[19]  N. Ichikawa,et al.  Interface Dynamics of Capillary Flow in a Tube under Negligible Gravity Condition , 1994 .

[20]  D. Bonn,et al.  Wetting and Spreading , 2009 .

[21]  K. Hosokawa,et al.  Interface motion of capillary-driven flow in rectangular microchannel. , 2004, Journal of colloid and interface science.

[22]  Hongrui Jiang,et al.  Liquid tunable microlenses based on MEMS techniques , 2013, Journal of physics D: Applied physics.

[23]  J. Sethian,et al.  FRONTS PROPAGATING WITH CURVATURE DEPENDENT SPEED: ALGORITHMS BASED ON HAMILTON-JACOB1 FORMULATIONS , 2003 .

[24]  G. Karniadakis,et al.  Microflows and Nanoflows: Fundamentals and Simulation , 2001 .

[25]  S. Osher,et al.  Algorithms Based on Hamilton-Jacobi Formulations , 1988 .

[26]  Wei Shyy,et al.  Simulation of Spacecraft Fuel Tank Self-pressurization Using Eulerian-Lagrangian Method , 2011 .