Laboratory tests of vortex-induced vibrations of a long flexible riser pipe subjected to uniform flow

Abstract Laboratory tests have been conducted on vortex-induced vibration (VIV) of a long flexible riser towed horizontally in a wave basin. The riser model has an external diameter of 16 mm and a total length of 28.0 m giving an aspect ratio of about 1750. Reynolds numbers ranged from about 3000 to 10,000. Fiber optic grating strain gages are adopted to measure the dynamic response in both cross-flow and in-line directions. The cross-flow vibrations were observed to vibrate at modes up to 6 and the in-line reached up to 12. The fundamental response frequencies can be predicted by a Strouhal number of about 0.18. Multi-mode responses and the asymmetry of the bare pipe response in uniform flow were observed and analyzed. The experimental results confirmed that the riser pipe vibrated multi-modally despite it being subject to a uniform current profile and all of the excited modes vibrated at the Strouhal frequency. The asymmetrical distribution of displacement mainly resulted from the modal composition. Higher harmonics of the VIV response such as the third, fourth and fifth harmonics frequencies were found to be steady over the entire duration of the test even if they varied along the length of the riser pipe.

[1]  P. Bearman.  VORTEX SHEDDING FROM OSCILLATING BLUFF BODIES , 1984 .

[2]  Vivek Jaiswal,et al.  Insights on vortex-induced, traveling waves on long risers , 2009 .

[3]  Kostas F. Lambrakos,et al.  Blind predictions of laboratory measurements of vortex-induced vibrations of a tension riser , 2005 .

[4]  Wataru Koterayama,et al.  Experimental study on vortex induced vibrations of highly flexible immersed pipe subjected to top end oscillations , 2004 .

[5]  O. M. Griffin,et al.  Some Recent Studies of Vortex Shedding With Application to Marine Tubulars and Risers , 1982 .

[6]  C. Williamson,et al.  The effect of two degrees of freedom on vortex-induced vibration at low mass and damping , 2004, Journal of Fluid Mechanics.

[7]  Halvor Lie,et al.  Experimental investigation of vortex-induced vibration of long marine risers , 2005 .

[8]  K. E. Kaasen,et al.  Modal analysis of measurements from a large-scale VIV model test of a riser in linearly sheared flow , 2006 .

[9]  Finn Gunnar Nielsen,et al.  Large Scale Model Testing Of Deep Sea Risers , 1998 .

[10]  Peter W. Bearman,et al.  Wake structures and vortex-induced vibrations of a long flexible cylinder—Part 1: Dynamic response , 2009 .

[11]  J. Michael R. Graham,et al.  Multi-modal Vortex-Induced Vibrations of a vertical riser pipe subject to a uniform current profile , 2004 .

[12]  C. Williamson,et al.  Modes of vortex formation and frequency response of a freely vibrating cylinder , 2000, Journal of Fluid Mechanics.

[13]  Vivek Jaiswal,et al.  Fatigue Damage From High Mode Number Vortex-Induced Vibration , 2006 .

[14]  Carl M. Larsen,et al.  Reynolds Number Dependence of Flexible Cylinder VIV Response Data , 2008 .

[15]  G. V. Parkinson,et al.  Phenomena and modelling of flow-induced vibrations of bluff bodies , 1989 .

[16]  Charles H. K. Williamson,et al.  A brief review of recent results in vortex-induced vibrations , 2008 .

[17]  W. G. Price,et al.  A cell boundary element method applied to laminar vortex shedding from circular cylinders , 2001 .

[18]  T. Sarpkaya.  Vortex-Induced Oscillations: A Selective Review , 1979 .

[19]  Stephen P. Timoshenko,et al.  Vibration problems in engineering , 1928 .

[20]  Turgut Sarpkaya,et al.  A critical review of the intrinsic nature of vortex-induced vibrations , 2004 .

[21]  Zhao Rui-hua.  Experimental investigation of suppression of vortex-induced vibration of marine risers by three control rods , 2009 .

[22]  S. T. Slocum,et al.  VIV Response of a Long Flexible Cylinder in Uniform and Linearly Sheared Currents , 2004 .

[23]  Hayden Marcollo,et al.  Phenomena Observed in VIV Bare Riser Field Tests , 2007 .

[24]  J. K. Vandiver,et al.  High-mode-number vortex-induced-vibration field experiments , 2005 .

[25]  C. Williamson,et al.  Vortex-Induced Vibrations , 2004, Wind Effects on Structures.

[26]  Halvor Lie,et al.  VIV Model Test of a Bare- and a Staggered Buoyancy Riser in a Rotating Rig , 1998 .

[27]  J. K. Vandiver,et al.  Dimensionless Parameters Important to the Prediction of Vortex-Induced Vibration of Long, Flexible Cylinders in Ocean Currents , 1993 .

[28]  Li Sun,et al.  Application of Tube-Packaged FBG Strain Sensor in Vibration Experiment of Submarine Pipeline Model , 2006 .

[29]  Wei Jin,et al.  A fibre-optic grating sensor for the study of flow-induced vibrations , 2000 .