Performance study about biodiesel impact on buses engines using dynamometer tests and fleet consumption data

Abstract The problem of reducing harmful emissions, mainly particulate matter (PM) and nitrogen oxides (NOxs) originated in compression ignition combustion engines, and also the mandatory intention of lowering the CO2 impacts of road transportation define the need to improve our knowledge on biodiesel use in engines. A 6 in line cylinders Volvo engine was submitted to a 100 min cycle with 27 stabilized steps for seven different fuel blends from pure fossil diesel (B0) to pure biodiesel (B100), considering also B10, B15, B20, B30, B50 fuel blends. The cycle imposed tries to simulate a normal use of a bus in an urban and extra-urban circuit, considering different engine rotation and loads applied. An analysis on consumption data obtained of a fleet was made. The fleet had near 200 buses, used different fuel blends, and operated in the north of Portugal. Results reveal that the cycle imposed reflects very well the tendency of consumption, allowing to confirm the methodology and also to check influences on consumption, mainly associated with possibilities to decrease CO2 emissions by using some biodiesel blends on buses. This allows increasing the quality of data in vehicle real use and tightening the uncertainties on the actual effects of using biodiesel.

[1]  Dimitrios C. Rakopoulos,et al.  Cylinder wall temperature effects on the transient performance of a turbocharged Diesel engine , 2004 .

[2]  John Sheehan,et al.  An Overview of Biodiesel and Petroleum Diesel Life Cycles , 2000 .

[3]  Dimitrios C. Rakopoulos,et al.  Multi-zone modeling of Diesel engine fuel spray development with vegetable oil, bio-diesel or Diesel fuels , 2006 .

[4]  Qin Zhang,et al.  Ethanol-diesel fuel blends -- a review. , 2005, Bioresource technology.

[5]  C. D. Rakopoulos,et al.  Investigation of the performance and emissions of bus engine operating on butanol/diesel fuel blends , 2010 .

[6]  Breda Kegl,et al.  Influence of biodiesel on injection, fuel spray, and engine characteristics , 2008 .

[7]  F. Convery,et al.  Stimulating the use of biofuels in the European Union: Implications for climate change policy , 2006 .

[8]  G. Labeckas,et al.  THE EFFECT OF RAPESEED OIL METHYL ESTER ON DIRECT INJECTION DIESEL ENGINE PERFORMANCE AND EXHAUST EMISSIONS , 2006 .

[9]  Irshad Ahmed,et al.  Oxygenated Diesel: Emissions and Performance Characteristics of Ethanol-Diesel Blends in CI Engines , 2001 .

[10]  Robert Joumard,et al.  Real-world European driving cycles, for measuring pollutant emissions from high- and low-powered cars , 2006 .

[11]  Mustafa Canakci,et al.  Effect of injection timing on the exhaust emissions of a diesel engine using diesel–methanol blends , 2009 .

[12]  L. Ntziachristos,et al.  Effects of biodiesel on passenger car fuel consumption, regulated and non-regulated pollutant emissions over legislated and real-world driving cycles , 2009 .

[13]  Kahraman Bozbas,et al.  Biodiesel as an alternative motor fuel: Production and policies in the European Union , 2008 .

[14]  Dimitrios C. Rakopoulos,et al.  Effects of ethanol-diesel fuel blends on the performance and exhaust emissions of heavy duty DI diesel engine , 2008 .

[15]  V. Golovitchev,et al.  Construction of combustion models for rapeseed methyl ester bio-diesel fuel for internal combustion engine applications. , 2009, Biotechnology advances.

[16]  Dimitrios C. Rakopoulos,et al.  Evaluation of the effect of engine, load and turbocharger parameters on transient emissions of diesel engine , 2009 .

[17]  Dimitrios C. Rakopoulos,et al.  Investigating the emissions during acceleration of a turbocharged diesel engine operating with bio-d , 2010 .

[18]  Dimitrios T. Hountalas,et al.  Analysis of combustion and pollutants formation in a direct injection diesel engine using a multi-zone model , 1995 .

[19]  A. Demirbas,et al.  Importance of biodiesel as transportation fuel , 2007 .

[20]  Joe Biluck,et al.  The Medford Twp., New Jersey Biodiesel School Bus Project , 2002 .

[21]  Y.zh. Bian,et al.  Experimental studies on the combustion characteristics and performance of a direct injection engine fueled with biodiesel/diesel blends , 2010 .

[22]  S. Aggarwal.  A review of spray ignition phenomena: Present status and future research , 1998 .

[23]  A. N. Ozsezen,et al.  Determination of performance and combustion characteristics of a diesel engine fueled with canola and waste palm oil methyl esters , 2011 .

[24]  Manuel Gameiro da Silva,et al.  Impact of Advances on Computing and Communication Systems in Automotive Testing , 2011 .

[25]  M. D. Cardenas,et al.  Reduction of diesel smoke opacity from vegetable oil methyl esters during transient operation , 2006 .

[26]  F. J. Salvador,et al.  Comparative analysis of a DI diesel engine fuelled with biodiesel blends during the European MVEG-A cycle: Preliminary study (I) , 2009 .

[27]  Robert L. McCormick,et al.  Effect of biodiesel blends on North American heavy-duty diesel engine emissions. , 2009 .

[28]  Robert Joumard,et al.  Influence of driving cycles on unit emissions from passenger cars , 2000 .

[29]  B. Kegl,et al.  Experimental Analysis of Injection Characteristics Using Biodiesel Fuel , 2006 .