Load-following mode control of a standalone renewable/fuel cell hybrid power source

Abstract A hybrid power source (HPS), fed by renewable energy sources (RESs) and fuel cell (FC) sources, with an energy storage device (ESS) to be suitable for distributed generation (DG) applications, is proposed herein. The RESs could be a combination of photovoltaic (PV) panels and wind turbines (WT) based on common DC-bus, which are used as the primary DC source. The FC operates as a backup, feeding only the insufficiency power from the RESs based on the load-following strategy. The battery/ultracapacitor hybrid ESS operates as an auxiliary source for supplying the power deficit based on dynamic power balance strategy (the transient power – mainly via the ultracapacitors stack, and the steady-state power – mainly via the FC and batteries stack). If the FC stack is designed and operates based on average load-following strategy, then the ESS will operate in charge-sustaining mode during a load cycle. This feature permits to optimize the batteries stack capacity and extend its life time as well. The ultracapacitors stack can be designed considering the peaks of RESs power on DC-bus and the imposed window for its state-of-charge (SOC). This FC/RES/ESS HPS is ideal to be used for standalone plug-in charge station (PCS) or as DG system grid connected. In the last case, which is not analyzed here, the energy management unit (EMU) that communicates with smart grid will establish the moments to match the HPS power demand with grid supply availability, stabilizing the grid. Using load and RES power profiles that have a higher dynamic than in reality, the HPS operation is shown based on an analytical analysis and the appropriate Matlab/Simulink® simulations.

[1]  Li Jia,et al.  Effects of inlet humidification on PEM fuel cell dynamic behaviors , 2011 .

[2]  Rashid Ansumana,et al.  Evaluating the impact of adding energy storage on the performance of a hybrid power system , 2011 .

[3]  M. Kolhe,et al.  Techno-Economic Optimum Sizing of a Stand-Alone Solar Photovoltaic System , 2009, IEEE Transactions on Energy Conversion.

[4]  Fortunato Migliardini,et al.  Experimental analysis and management issues of a hydrogen fuel cell system for stationary and mobile application , 2007 .

[5]  Masafumi Miyatake,et al.  Power fluctuations suppression of stand-alone hybrid generation combining solar photovoltaic/wind turbine and fuel cell systems , 2008 .

[6]  Ahmed Al-Salaymeh,et al.  Optimal operation of conventional power plants in power system with integrated renewable energy sources , 2013 .

[7]  Carlos Andrés Ramos-Paja,et al.  Fuel cell emulator for oxygen excess ratio estimation on power electronics applications , 2012, Comput. Electr. Eng..

[8]  Claire H. Woo,et al.  PEM fuel cell current regulation by fuel feed control , 2007 .

[9]  Denis Candusso,et al.  Study of gas pressure and flow rate influences on a 500 W PEM fuel cell, thanks to the experimental design methodology , 2006 .

[10]  M.R. Iravani,et al.  Power Management Strategies for a Microgrid With Multiple Distributed Generation Units , 2006, IEEE Transactions on Power Systems.

[11]  Anna G. Stefanopoulou,et al.  Control of Fuel Cell Power Systems: Principles, Modeling, Analysis and Feedback Design , 2004 .

[12]  Yong Tang,et al.  Experimental investigation of dynamic performance and transient responses of a kW-class PEM fuel cell stack under various load changes , 2010 .

[13]  Maxime Wack,et al.  Robust control of the PEM fuel cell air-feed system via sub-optimal second order sliding mode , 2013 .

[14]  Ehsan Adib,et al.  A bidirectional soft switched ultracapacitor interface circuit for hybrid electric vehicles , 2008 .

[15]  José M. Martínez-Val,et al.  Energy for Sustainable Development: A systematic approach for a badly defined challenge , 2013 .

[16]  Alon Kuperman,et al.  A frequency domain approach to analyzing passive battery–ultracapacitor hybrids supplying periodic pulsed current loads , 2011 .

[17]  Ozan Erdinc,et al.  A wavelet-fuzzy logic based energy management strategy for a fuel cell/battery/ultra-capacitor hybrid vehicular power system , 2009 .

[18]  Caisheng Wang,et al.  Power Management of a Stand-Alone Wind/Photovoltaic/Fuel Cell Energy System , 2008, IEEE Transactions on Energy Conversion.

[19]  K. H. Loo,et al.  Quasi-Maximum Efficiency Point Tracking for Direct Methanol Fuel Cell in DMFC/Supercapacitor Hybrid Energy System , 2012, IEEE Transactions on Energy Conversion.

[20]  Thomas J Overbye,et al.  Key Technical Challenges for the Electric Power Industry and Climate Change , 2010, IEEE Transactions on Energy Conversion.

[21]  O. Erdinç,et al.  Modeling and analysis of an FC/UC hybrid vehicular power system using a wavelet-fuzzy logic based load sharing and control algorithm , 2009 .

[22]  Ozan Erdinc,et al.  Experimental performance assessment of an online energy management strategy for varying renewable power production suppression , 2012 .

[23]  K. Agbossou,et al.  Performance of a stand-alone renewable energy system based on energy storage as hydrogen , 2004, IEEE Transactions on Energy Conversion.

[24]  V. Agarwal,et al.  An Integrated Hybrid Power Supply for Distributed Generation Applications Fed by Nonconventional Energy Sources , 2008, IEEE Transactions on Energy Conversion.

[25]  Subhashish Bhattacharya,et al.  Optimal Control of Battery Energy Storage for Wind Farm Dispatching , 2010, IEEE Transactions on Energy Conversion.

[26]  Phatiphat Thounthong,et al.  Control strategy of fuel cell/supercapacitors hybrid power sources for electric vehicle , 2006 .

[27]  Nicu Bizon,et al.  FC energy harvesting using the MPP tracking based on advanced extremum seeking control , 2013 .

[28]  J. G. Vlachogiannis.  Simplified reactive power management strategy for complex power grids under stochastic operation and incomplete information , 2009 .

[29]  K.M. Smedley,et al.  Load-Following Strategies for Evolution of Solid Oxide Fuel Cells Into Model Citizens of the Grid , 2009, IEEE Transactions on Energy Conversion.

[30]  Serge Pierfederici,et al.  Energy control of supercapacitor/fuel cell hybrid power source , 2008 .

[31]  Nicu Bizon,et al.  Energy efficiency for the multiport power converters architectures of series and parallel hybrid power source type used in plug-in/V2G fuel cell vehicles , 2013 .

[32]  Diego Feroldi,et al.  Energy management strategies based on efficiency map for fuel cell hybrid vehicles , 2009 .

[33]  Pang-Chia Chen,et al.  Robust voltage tracking control for proton exchange membrane fuel cells , 2013 .

[34]  Ionel Vechiu,et al.  Comparison of three topologies and controls of a hybrid energy storage system for microgrids , 2012 .

[35]  Azah Mohamed,et al.  Multi-sources model and control algorithm of an energy management system for light electric vehicles , 2012 .

[36]  Ömer Nezih Gerek,et al.  The effect of model generated solar radiation data usage in hybrid (wind–PV) sizing studies , 2009 .

[37]  A. J. Calderón,et al.  Automatic management of energy flows of a stand-alone renewable energy supply with hydrogen support , 2010 .

[38]  Salah Laghrouche,et al.  Extremum seeking control for net power output maximization of a PEM fuel cell using second order sliding mode , 2012, 2012 12th International Workshop on Variable Structure Systems.

[39]  Sigurd Skogestad,et al.  Control of fuel cell power output , 2007 .

[40]  P. Thounthong,et al.  Analysis of Supercapacitor as Second Source Based on Fuel Cell Power Generation , 2009, IEEE Transactions on Energy Conversion.

[41]  F. V. P. Robinson,et al.  Analysis of Battery Lifetime Extension in a Small-Scale Wind-Energy System Using Supercapacitors , 2013, IEEE Transactions on Energy Conversion.

[42]  Daniel Hissel,et al.  MPPT of a PEMFC based on air supply control of the motocompressor group , 2010 .

[43]  David A. Cartes,et al.  Adaptive controller for tracking power profile in a fuel cell powered automobile , 2008 .

[44]  Song-Yul Choe,et al.  Modeling and simulation of a PEM fuel cell stack considering temperature effects , 2006 .

[45]  Mona N. Eskander,et al.  Energy flow and management of a hybrid wind/PV/fuel cell generation system , 2006 .