Experimental and theoretical analysis of the dominant lateral waveguiding mechanism in 975 nm high power broad area diode lasers

For maximum fibre-coupled power, high power broad area diode lasers must operate with small lateral far field angles at high continuous wave (CW) powers. However, these structures are laterally multi-moded, with low beam quality and wide emission angles. In order to experimentally determine the origin of the low beam quality, spectrally resolved near and far field measurements were performed for a diode laser with 50 µm stripe width. Within the range measured (CW optical output powers to 1.5 W) the laser is shown to operate in just six stable lateral modes, with spatially periodic profiles. Comparisons of the measured profiles with the results of two-dimensional modal simulation demonstrate that current-induced thermal lensing dominates the lateral waveguiding, in spite of the presence of both strong built-in index guiding and gain guiding. No evidence is seen for filamentation. Building on the diagnosis, proposals are presented for improvements to beam quality.

[1]  H. Sommers.  Experimental properties of injection lasers: modal distribution of laser power , 1973 .

[2]  Henry Kressel,et al.  Semiconductor Lasers and Heterojunction LEDs , 1977 .

[3]  G. Lengyel,et al.  A study of lateral modes in wide double‐heterostructure GaAs‐GaAlAs laser diodes , 1978 .

[4]  B. Stegmüller.  Influence of lateral waveguiding properties on the longitudinal mode spectrum for semiconductor lasers , 1983 .

[5]  M. Yamada.  Transverse and longitudinal mode control in semiconductor injection lasers , 1983 .

[6]  J. Hohimer,et al.  Mode control in broad-area diode lasers by thermally induced lateral index tailoring , 1988 .

[7]  R. Frey,et al.  A broad-area mode-coupling model for multiple-stripe semiconductor lasers , 1990 .

[8]  L. Figueroa,et al.  Buried‐ridge striped planar GaAlAs/GaAs lasers with a wide range of effective index steps , 1990 .

[9]  Robert J. Lang,et al.  Lateral modes of broad area semiconductor lasers: theory and experiment , 1991 .

[10]  A. Sudbø,et al.  Numerically stable formulation of the transverse resonance method for vector mode-field calculations in dielectric waveguides , 1993, IEEE Photonics Technology Letters.

[11]  David F. Welch,et al.  Spatial evolution of filaments in broad area diode laser amplifiers , 1993 .

[12]  Ingo Fischer,et al.  Complex spatio-temporal dynamics in the near-field of a broad-area semiconductor laser , 1996 .

[13]  J. P. Ziel,et al.  Characterization of the array modes of high-power gain-guided GaAs single-quantum-well laser arrays , 1996 .

[14]  D. Gallant,et al.  IMPROVED METHOD FOR GAIN/INDEX MEASUREMENTS OF SEMICONDUCTOR LASERS , 1996 .

[15]  R. Indik,et al.  Full space-time simulation for high-brightness semiconductor lasers , 1997, IEEE Photonics Technology Letters.

[16]  Y. Champagne,et al.  Single-mode operation of a broad-area semiconductor laser with an anamorphic external cavity: experimental and numerical results. , 2000, Applied optics.

[17]  B. Sverdlov,et al.  Ultra-high power RWG laser diodes with lateral absorber region , 2002, IEEE 18th International Semiconductor Laser Conference.

[18]  Peter Blood,et al.  Characterization of semiconductor laser gain media by the segmented contact method , 2003 .

[19]  Jayanta Mukherjee,et al.  Lateral mode dynamics in high-power wide-aperture quantum dot laser , 2007, SPIE OPTO.

[20]  G. Erbert,et al.  Fundamental-Lateral Mode Stabilized High-Power Ridge-Waveguide Lasers With a Low Beam Divergence , 2008, IEEE Photonics Technology Letters.

[21]  T. Numai,et al.  Fiber Pump Semiconductor Lasers With Optical Antiguiding Layers for Horizontal Transverse Modes , 2008 .

[22]  G. Erbert,et al.  Control of optical mode distribution through etched microstructures for improved broad area laser performance , 2008 .

[23]  C. Chen,et al.  Stabilization of lateral mode transients in high-power broad area semiconductor lasers , 2009 .

[24]  N. Stelmakh,et al.  External-to-cavity lateral-mode harnessing devices for high-brightness broad-area laser diodes: concept, realizations, and perspectives , 2009, OPTO.

[25]  Katrin Paschke,et al.  Experimental determination of the thermal lens parameters in a broad area semiconductor laser amplifier , 2009 .

[26]  William W. Bewley,et al.  Corrugated-sidewall interband cascade lasers with single-mode midwave-infrared emission at room temperature , 2009 .

[27]  Paul Crump,et al.  11W broad area 976 nm DFB lasers with 58% power conversion efficiency , 2010 .

[28]  Heiko Kissel,et al.  Comparison of concepts for high-brightness diode lasers at 976 nm , 2010, LASE.

[29]  A. Pietrzak,et al.  975-nm high-power broad area diode lasers optimized for narrow spectral linewidth applications , 2010, LASE.

[30]  Heiko Kissel,et al.  Scaling brilliance of high power laser diodes , 2010, LASE.

[31]  Paul Crump,et al.  Root-Cause Analysis of Peak Power Saturation in Pulse-Pumped 1100 nm Broad Area Single Emitter Diode Lasers , 2010, IEEE Journal of Quantum Electronics.

[32]  G. Erbert,et al.  Theoretical and experimental analysis of the lateral modes of high-power broad-area lasers , 2011, 2011 Numerical Simulation of Optoelectronic Devices.

[33]  Wolfgang Schmid,et al.  Control of slow axis mode behaviour with waveguide phase structures in semiconductor broad-area lasers , 2009, OPTO.

[34]  Sandrio Elim,et al.  Mitigation of thermal lensing effect as a brightness limitation of high-power broad area diode lasers , 2011, OPTO.

[35]  Peter Cheng,et al.  100W high-brightness multi-emitter laser pump , 2011, LASE.