Modeling, state estimation and nonlinear model predictive control of cathode exhaust gas mass flow for PEM fuel cells

Abstract Polymer electrolyte membrane fuel cells are efficient energy converters and provide electrical energy, water and oxygen depleted air with a low oxygen content as exhaust gas if fed with air. Due to their low emission of greenhouse gases and noise they are investigated as replacement for auxiliary power units currently used for electrical power supply on aircraft. Oxygen depleted air, called ODA-gas, with an oxygen concentration of 10–11% and a low humidity can be used for tank-inerting on aircraft. A challenging task is controlling the fuel cell system for generation of dehumidified ODA-gas mass flow while simultaneously keeping bounds and gradients on control inputs. This task is attacked by a nonlinear model predictive control. Not all system states can be measured and some states measured exhibit a significant time delay. A nonlinear state estimation strategy builds the entire system state and compensates for the delay. The nonlinear model predictive control and the state estimation are derived from the system model, which is presented. Simulation and experimental results are shown.

[1]  J. C. Amphlett,et al.  Performance modeling of the Ballard Mark IV solid polymer electrolyte fuel cell. II: Empirical model development , 1995 .

[2]  Giorgio Battistelli,et al.  Advances in moving horizon estimation for nonlinear systems , 2010, 49th IEEE Conference on Decision and Control (CDC).

[3]  Joachim Horn,et al.  Nonlinear Model Predictive Control of a PEM Fuel Cell System for Cathode Exhaust Gas Generation , 2014 .

[4]  S. Haykin.  Kalman Filtering and Neural Networks , 2001 .

[5]  Rudolph van der Merwe,et al.  The square-root unscented Kalman filter for state and parameter-estimation , 2001, 2001 IEEE International Conference on Acoustics, Speech, and Signal Processing. Proceedings (Cat. No.01CH37221).

[6]  James B. Rawlings,et al.  Critical Evaluation of Extended Kalman Filtering and Moving-Horizon Estimation , 2005 .

[7]  J. Birk.  Zustandsschätzung für nichtlineare Prozesse mit zeitdiskreten und totzeitbehafteten Messgrößen (State Estimation for Nonlinear Processes with Discrete-Time and Time-Delayed Measurements) , 2000 .

[8]  Josef Kallo,et al.  Fuel Cell System Development and Testing for Aircraft Applications , 2010 .

[9]  Matt Barker,et al.  Mathematical Model of Water Contamination in Aircraft Fuel Tanks , 2011 .

[10]  Adam McLoughlin.  More electric — Ready for take off? , 2009, 2009 13th European Conference on Power Electronics and Applications.

[11]  Julia H. Buckland,et al.  Humidity and Pressure Regulation in a PEM Fuel Cell Using a Gain-Scheduled Static Feedback Controller , 2009, IEEE Transactions on Control Systems Technology.

[12]  Anna G. Stefanopoulou,et al.  Optimal Power Control of Hybrid Fuel Cell Systems for an Accelerated System Warm-Up , 2007, IEEE Transactions on Control Systems Technology.

[13]  D. P. Sekulic,et al.  Fundamentals of Heat Exchanger Design , 2003 .

[14]  Anna G. Stefanopoulou,et al.  Current Management in a Hybrid Fuel Cell Power System: A Model-Predictive Control Approach , 2006, IEEE Transactions on Control Systems Technology.

[15]  Lars Grne,et al.  Nonlinear Model Predictive Control: Theory and Algorithms , 2011 .

[16]  Manfred Morari,et al.  Nonlinear offset-free model predictive control , 2012, Autom..

[17]  Joachim Horn,et al.  State estimation with time delay and state feedback control of cathode exhaust gas mass flow for PEM fuel cell systems , 2013, 2013 European Control Conference (ECC).

[18]  R. E. Kalman,et al.  A New Approach to Linear Filtering and Prediction Problems , 2002 .

[19]  Donald E. Kirk,et al.  Optimal control theory : an introduction , 1970 .

[20]  Gabriele Pannocchia,et al.  Disturbance models for offset‐free model‐predictive control , 2003 .

[21]  R. O’Hayre,et al.  Fuel Cell Fundamentals , 2005 .

[22]  Huei Peng,et al.  Model predictive control for starvation prevention in a hybrid fuel cell system , 2004, Proceedings of the 2004 American Control Conference.

[23]  H.F. Durrant-Whyte,et al.  A new approach for filtering nonlinear systems , 1995, Proceedings of 1995 American Control Conference - ACC'95.

[24]  Anna G. Stefanopoulou,et al.  Control of Fuel Cell Power Systems: Principles, Modeling, Analysis and Feedback Design , 2004 .

[25]  Joachim Horn,et al.  State estimation for PEM fuel cell systems with time delay by an Unscented Kalman filter and predictor strategy , 2013, 21st Mediterranean Conference on Control and Automation.

[26]  Joachim Horn,et al.  Nonlinear Model Predictive Control of PEM Fuel Cell Systems for Generation of Exhaust Gas with Low Oxygen Content , 2013 .

[27]  F. Allgöwer,et al.  Nonlinear Model Predictive Control: From Theory to Application , 2004 .

[28]  David Q. Mayne,et al.  Constrained model predictive control: Stability and optimality , 2000, Autom..

[29]  J. Horn,et al.  Modeling and simulation of a coupled double-loop-cooling system for PEM-fuel cell stack cooling , 2012, Proceedings of 2012 UKACC International Conference on Control.

[30]  Mahlon Wilson,et al.  Scientific aspects of polymer electrolyte fuel cell durability and degradation. , 2007, Chemical reviews.

[31]  J. C. Amphlett.  Performance Modeling of the Ballard Mark IV Solid Polymer Electrolyte Fuel Cell , 1995 .