Exposure to welding fumes is associated with acute systemic inflammatory responses

Aims: To investigate the acute systemic inflammatory response to welding fume exposure. Methods: Twenty four welders (42% smokers) and 13 non-exposed controls (23% smokers) were monitored at a welding school. Exposure to fine particulate matter (PM2.5) was assessed using cyclone samplers. Markers of systemic inflammation, including C-reactive protein (CRP), fibrinogen, and white blood cell (WBC) levels, were determined in peripheral blood samples collected at baseline and after 5.3 (SD 1.0) hours of exposure. Results: The median PM2.5 concentration for welders was 1.66 mg/m3, which was significantly greater than that for controls (0.04 mg/m3). Compared to non-smokers, smokers had a significantly higher baseline WBC count, but comparable levels of CRP and fibrinogen. In non-smokers, welding fume exposure was associated with a significant increase in WBC and neutrophil counts immediately following exposure (+0.8×103/μl, 95% CI 0.1 to 1.6, and +1.0×103/μl, 95% CI 0.4 to 1.7, respectively). A significant decrease in fibrinogen levels was observed in non-smokers (−32 mg/dl, 95% CI −63 to −1). No significant changes in WBC, neutrophil, and fibrinogen levels were found in smokers. Sixteen hours after welding exposure, CRP levels were found to be significantly increased in both non-smokers and smokers (0.90 mg/l, 95% CI 0.17 to 1.64). PM2.5 concentrations were found to be significantly associated with absolute neutrophil counts in non-smokers, and CRP levels in both non-smokers and smokers. Conclusions: High levels of welding fume exposure induce acute systemic inflammation in a relatively young, healthy working population. These results also suggest that smoking may modify the effect of welding fume exposure on specific inflammatory markers.

[1]  Delbert J Eatough,et al.  Ambient particulate air pollution, heart rate variability, and blood markers of inflammation in a panel of elderly subjects. , 2004, Environmental health perspectives.

[2]  D W Brown,et al.  White blood cell count: an independent predictor of coronary heart disease mortality among a national cohort. , 2001, Journal of clinical epidemiology.

[3]  A. Peters,et al.  Particulate air pollution is associated with an acute phase response in men; results from the MONICA-Augsburg Study. , 2001, European heart journal.

[4]  G. Perlman,et al.  Airway reactivity in welders: a controlled prospective cohort study. , 1996, Journal of occupational and environmental medicine.

[5]  B. Sjögren,et al.  Welding and Ischemic Heart Disease , 2002, International journal of occupational and environmental health.

[6]  Steffen Loft,et al.  Personal PM2.5 exposure and markers of oxidative stress in blood. , 2002, Environmental health perspectives.

[7]  N. Pearce,et al.  Two year follow up of pulmonary function values among welders in New Zealand. , 1999, Occupational and environmental medicine.

[8]  J Schwartz,et al.  Air pollution and blood markers of cardiovascular risk. , 2001, Environmental health perspectives.

[9]  D. Alper,et al.  Chronic effects of welding exposure on pulmonary function tests and respiratory symptoms. , 1995, Occupational and environmental medicine.

[10]  R. Elton,et al.  Particulate air pollution and the blood , 1999, Thorax.

[11]  K. Williams,et al.  Atherosclerosis--an inflammatory disease. , 1999, The New England journal of medicine.

[12]  N. Day,et al.  Smoking status and differential white cell count in men and women in the EPIC-Norfolk population. , 2003, Atherosclerosis.

[13]  F. Burzotta,et al.  Fibrinogen as a marker of inflammation: a clinical view. , 1999, Blood coagulation & fibrinolysis : an international journal in haemostasis and thrombosis.

[14]  F. Rosenthal,et al.  Evaluation of an aerosol photometer for monitoring welding fume levels in a shipyard. , 1985, American Industrial Hygiene Association journal.

[15]  J. Plutzky.  Inflammatory pathways in atherosclerosis and acute coronary syndromes. , 2001, The American journal of cardiology.

[16]  L. Lind.  Circulating markers of inflammation and atherosclerosis. , 2003, Atherosclerosis.

[17]  S T Holgate,et al.  Acute inflammatory responses in the airways and peripheral blood after short-term exposure to diesel exhaust in healthy human volunteers. , 1999, American journal of respiratory and critical care medicine.

[18]  A. Clauss,et al.  Gerinnungsphysiologische Schnellmethode zur Bestimmung des Fibrinogens , 1957 .

[19]  E J Mueller,et al.  Metal fume fever--a review. , 1985, The Journal of emergency medicine.

[20]  N. Pearce,et al.  Chronic bronchitis, work related respiratory symptoms, and pulmonary function in welders in New Zealand. , 1998, Occupational and environmental medicine.

[21]  Diane Catellier,et al.  C-reactive protein and incident coronary heart disease in the Atherosclerosis Risk In Communities (ARIC) study. , 2002, American heart journal.

[22]  J. Malo,et al.  Prevalence and association of welding related systemic and respiratory symptoms in welders , 2003, Occupational and environmental medicine.

[23]  B Sjögren,et al.  Asthma, lung function, and bronchial responsiveness in welders. , 1994, American journal of industrial medicine.

[24]  J. Malo,et al.  Incidence of probable occupational asthma and changes in airway calibre and responsiveness in apprentice welders , 2003, European Respiratory Journal.

[25]  A. Clauss.  [Rapid physiological coagulation method in determination of fibrinogen]. , 1957, Acta haematologica.

[26]  C. Stefanadis,et al.  Inflammatory and thrombotic mechanisms in coronary atherosclerosis , 2003, Heart.

[27]  R Peto,et al.  Association of fibrinogen, C-reactive protein, albumin, or leukocyte count with coronary heart disease: meta-analyses of prospective studies. , 1998, JAMA.

[28]  Jiang He,et al.  Relationship between Cigarette Smoking and Novel Risk Factors for Cardiovascular Disease in the United States , 2003, Annals of Internal Medicine.

[29]  A. Döring,et al.  C-Reactive protein, a sensitive marker of inflammation, predicts future risk of coronary heart disease in initially healthy middle-aged men: results from the MONICA (Monitoring Trends and Determinants in Cardiovascular Disease) Augsburg Cohort Study, 1984 to 1992. , 1999, Circulation.

[30]  R. Sothern,et al.  Relation between circadian patterns in levels of circulating lipoprotein(a), fibrinogen, platelets, and related lipid variables in men. , 2000, American heart journal.

[31]  R. de Gaudemaris,et al.  A mortality study among mild steel and stainless steel welders. , 1993, British journal of industrial medicine.

[32]  K. Schenck-Gustafsson,et al.  Relationship between plasma fibrinogen and coronary heart disease in women. , 1999, Arteriosclerosis, thrombosis, and vascular biology.

[33]  Mark B Pepys,et al.  C-reactive protein: a critical update. , 2003, The Journal of clinical investigation.

[34]  William A. Burgess,et al.  Recognition of health hazards in industry : a review of materials and processes , 1981 .

[35]  T. Aw,et al.  Recognition of Health Hazards in Industry , 1996 .

[36]  W. Koenig,et al.  Independent association of various smoking characteristics with markers of systemic inflammation in men. Results from a representative sample of the general population (MONICA Augsburg Survey 1994/95). , 2003, European heart journal.

[37]  D. Oakes,et al.  Mortality of welders and other craftsmen at a shipyard in NE England. , 1985, British journal of industrial medicine.