Hydrogen production by steam reforming of liquefied natural gas over a nickel catalyst supported on mesoporous alumina xerogel

Abstract Mesoporous alumina xerogel (A-SG) is prepared by a sol–gel method for use as a support for a nickel catalyst. The Ni/A-SG catalyst is then prepared by an impregnation method, and is applied to hydrogen production by steam reforming of liquefied natural gas (LNG). The effect of the mesoporous alumina xerogel support on the catalytic performance of Ni/A-SG catalyst is investigated. For the purpose of comparison, a nickel catalyst supported on commercial alumina (A-C) is also prepared by an impregnation method (Ni/A-C). Both the hydroxyl-rich surface and the electron-deficient sites of the A-SG support enhance the dispersion of the nickel species on the support during the calcination step. The formation of the surface nickel aluminate phase in the Ni/A-SG catalyst remarkably increases the reducibility and stability of the catalyst. Furthermore, the high-surface area and the well-developed mesoporosity of the Ni/A-SG catalyst enhance the gasification of surface hydrocarbons that are adsorbed in the reaction. In the steam reforming of LNG, the Ni/A-SG catalyst exhibits a better catalytic performance than the Ni/A-C catalyst in terms of LNG conversion and hydrogen production. Moreover, the Ni/A-SG catalyst shows strong resistance toward catalyst deactivation.

[1]  J. Yi,et al.  Effect of preparation conditions on the phase transformation of mesoporous alumina , 2005 .

[2]  G. Haller,et al.  Solid-state magic-angle spinning 27Al NMR used to study alumina support and surface compound structure of catalysts , 1986 .

[3]  Ryuji Kikuchi,et al.  Study on steam reforming of CH4 and C2 hydrocarbons and carbon deposition on Ni-YSZ cermets , 2002 .

[4]  Tadeusz Borowiecki,et al.  Effects of small MoO3 additions on the properties of nickel catalysts for the steam reforming of hydrocarbons , 1997 .

[5]  F. B. Noronha,et al.  Influence of the addition of promoters to steam reforming catalysts , 2005 .

[6]  M. Amini,et al.  Decomposition of Nickel Formate on Sol–Gel Alumina and Characterization of Product by X-Ray Photoelectron and TOF-SIMS Spectroscopies , 2002 .

[7]  B. Rebours,et al.  Theoretical Study of the Dehydration Process of Boehmite to γ-Alumina , 2001 .

[8]  Y. Matsumura,et al.  Steam reforming of methane over nickel catalysts at low reaction temperature , 2004 .

[9]  K. Chawla,et al.  Fabrication and characterisation of Ni-coated carbon fibre-reinforced alumina ceramic matrix composites using electrophoretic deposition , 2001 .

[10]  Jens R. Rostrup-Nielsen,et al.  Hydrogen and Synthesis gas by Steam- and CO2 reforming , 2002 .

[11]  P. Irving,et al.  Steam Reforming of Hydrocarbon Fuels , 2002 .

[12]  Joong-Kee Lee,et al.  Kinetics of steam reforming over a Ni/alumina catalyst , 1995 .

[13]  R. Giudici,et al.  A Monte Carlo model for the sintering of Ni/Al2O3 catalysts , 2001 .

[14]  S. Nam,et al.  Methane steam reforming in a Pd-Ru membrane reactor , 2000 .

[15]  Jin-Hong Kim,et al.  Effect of metal particle size on coking during CO2 reforming of CH4 over Ni–alumina aerogel catalysts , 2000 .

[16]  K. L. Tan,et al.  CO2 Reforming of Methane to Synthesis Gas over Sol–Gel-made Ni/γ-Al2O3 Catalysts from Organometallic Precursors , 2000 .

[17]  J. Fripiat,et al.  Aluminum coordination and Lewis acidity in transition aluminas , 1992 .

[18]  M. Jacono,et al.  Structural, magnetic, and optical properties of nickel oxide supported on .eta.- and .gamma.-aluminas , 1971 .

[19]  Jens K. Nørskov,et al.  Sintering of nickel steam-reforming catalysts: effects of temperature and steam and hydrogen pressures , 2004 .

[20]  E. Longo,et al.  Synthesis of Ni nanoparticles in microporous and mesoporous Al and Mg oxides , 2004 .

[21]  Umit S. Ozkan,et al.  Deactivation characteristics of lanthanide-promoted sol–gel Ni/Al2O3 catalysts in propane steam reforming , 2005 .

[22]  L. Noreña,et al.  Properties of sol–gel derived mesoporous aluminas as metal traps , 2004 .

[23]  D. Suh,et al.  Fast sol-gel synthetic route to high-surface-area alumina aerogels , 1997 .

[24]  D. Suh,et al.  Nickel–alumina aerogel catalysts prepared by fast sol–gel synthesis , 1998 .

[25]  J. Rostrup-Nielsen.  Mechanisms of carbon formation on nickel-containing catalysts , 1977 .

[26]  Masanori Yoshida,et al.  Addition of zirconia in Ni/SiO2 catalyst for improvement of steam resistance , 2004 .

[27]  J. Rostrup-Nielsen.  New aspects of syngas production and use , 2000 .

[28]  Joong-Kee Lee,et al.  Hydrogen production from fluidized bed steam reforming of hydrocarbons , 1998 .

[29]  G. R. Hays,et al.  Characterization of transitional alumina by solid-state magic angle spinning aluminium NMR , 1983 .

[30]  Hyun-Seog Roh,et al.  Hydrogen production for fuel cells through methane reforming at low temperatures , 2002 .

[31]  T. Borowiecki,et al.  Carbon deposition on Ni/Al2O3 catalysts doped with small amounts of molybdenum , 2000 .

[32]  K. Jun,et al.  Highly active and stable Ni/Ce-ZrO2 catalyst for H2 production from methane , 2002 .

[33]  D. Goodman,et al.  Production of COx-free hydrogen for fuel cells via step-wise hydrocarbon reforming and catalytic dehydrogenation of ammonia , 2003 .

[34]  K. Jun,et al.  Methane-reforming reactions over Ni/Ce-ZrO2/θ-Al2O3 catalysts , 2003 .

[35]  I. Song,et al.  Hydrogen production by steam reforming of LNG over Ni/Al2O3–ZrO2 catalysts: Effect of Al2O3–ZrO2 supports prepared by a grafting method , 2007 .

[36]  E. Basaldella,et al.  Ni/γ-Al2O3 catalyst from kaolinite for the dry reforming of methane , 2004 .

[37]  Guoxing Xiong,et al.  Deactivation studies over NiO/?-Al 2O 3 catalysts for partial oxidation of methane to syngas , 2000 .

[38]  M. P. Mcdonald,et al.  Structural aspects of certain phase transformations in lyotropic liquid-crystal systems , 1985 .

[39]  P. S. Santos,et al.  Pseudomorphic transformations of euhedral crystals of γ-AlOOH into aluminas , 1994 .

[40]  J. Armor,et al.  The multiple roles for catalysis in the production of H2 , 1999 .

[41]  Malcolm L. H. Green,et al.  Recent advances in the conversion of methane to synthesis gas , 1995 .

[42]  W. Gac,et al.  Effects of small MoO3 additions on the properties of nickel catalysts for the steam reforming of hydrocarbons. III. Reduction of Ni-Mo/Al2O3 catalysts , 2004 .

[43]  J. Yi,et al.  Synthesis and characterization of mesoporous alumina with nickel incorporated for use in the partial oxidation of methane into synthesis gas , 2004 .

[44]  Julian R.H. Ross,et al.  Syngas production from natural gas using ZrO2-supported metals , 1998 .