Condition monitoring and diagnostics of power transformers

This paper addresses the subject of condition monitoring and diagnostics of power transformers. The main results of two reliability surveys, carried out under the auspices of CIGRE and IEEE in order to assemble objective data on the performance of transformers in service, are presented, providing useful information on the main causes of transformer failures, the most likely affected components and the related outages times. A survey of the most important methods, actually in use, for condition monitoring and diagnostics of power transformers is also given, which stresses the need for the development of new diagnostic methods, that can be applied without taking the transformers out of service, and that can also provide a fault severity criteria, in particular for determining transformers windings integrity. Preliminary results, concerning the on-going research activity on the development of a new approach for inter-turn winding fault diagnosis in three-phase transformers, are also reported in the paper.

[1]  Kevin Tomsovic,et al.  A fuzzy information approach to integrating different transformer diagnostic methods , 1993 .

[2]  P. Boss,et al.  Detection and location of internal defects in the insulation of power transformers , 1993 .

[3]  K. Suganuma,et al.  Development of oil-dissolved hydrogen gas detector for diagnosis of transformers , 1990 .

[4]  Eldon J. Rogers,et al.  Instrumentation Techniques for Low Voltage Impulse Testing of Power Transformers , 1972 .

[5]  P. J. Griffin,et al.  An Artificial Neural Network Approach to Transformer Fault Diagnosis , 1996, IEEE Power Engineering Review.

[6]  C. K. Mechefske.  Correlation power transformer tank vibration characteristics to winding looseness , 1995 .

[7]  C. Bengtsson,et al.  Status and trends in transformer monitoring , 1996 .

[8]  Chin E. Lin,et al.  An expert system for transformer fault diagnosis using dissolved gas analysis , 1993 .

[9]  Satoru Yanabu,et al.  Partial-Discharge Measurement on High-Voltage Power Transformers , 1969 .

[10]  Hong-Tzer Yang,et al.  Developing a new transformer fault diagnosis system through evolutionary fuzzy logic , 1997 .

[11]  E.P. Dick,et al.  Transformer Diagnostic Testing by Frequuency Response Analysis , 1978, IEEE Transactions on Power Apparatus and Systems.

[12]  A. Garcia-Cerrada,et al.  Experiences learned from the on-line internal monitoring of the behaviour of a transformer , 1997, 1997 IEEE International Electric Machines and Drives Conference Record.

[13]  Birgitte Bak-Jensen,et al.  Detection of faults and ageing phenomena in transformers by transfer functions , 1995 .