Wetting and drying of concrete using aqueous solutions containing deicing salts

Abstract A series of wetting and drying tests were performed on concrete using different aqueous solutions containing deicing salts. The rate of fluid absorption was generally lower for aqueous solutions containing deicing salts than it was for water. In addition, less fluid was absorbed for samples exposed to aqueous solutions containing deicing salts than for samples exposed to water. The change in the rate of aqueous fluid absorption was proportional to the square root of the ratio of surface tension and viscosity of the absorbed fluid. Concrete that has been exposed to solutions containing deicing salts showed less mass loss during drying. Measures of equilibrium relative humidity over the salt solutions are used to interpret drying behavior. Experimental data indicates that concretes that had previously been exposed to deicing solutions can also exhibit reduced rate of absorption, even if water is the fluid being absorbed.

[1]  J.G.M. van Mier,et al.  How to study drying shrinkage microcracking in cement-based materials using optical and scanning electron microscopy? , 2002 .

[2]  R. D. Hooton,et al.  Effects of cyclic chloride exposure on penetration of concrete cover , 1999 .

[3]  George W. Scherer,et al.  Silicate Consolidants for Stone , 2008 .

[4]  M. Afzal,et al.  Temperature and concentration dependence of viscosity of aqueous electrolytes from 20.degree.C to 50.degree.C chlorides of (sodium(1+), potassium(1+), magnesium(2+), calcium(2+), barium(2+), strontium(2+), cobalt(2+), nickel(2+), copper(2+) and chromium(3+) , 1989 .

[5]  Manuel R. Conde,et al.  Properties of aqueous solutions of lithium and calcium chlorides: formulations for use in air conditioning equipment design , 2004 .

[6]  Chao-Lung Hwang,et al.  Drying shrinkage of portland cement pastes I. Microcracking during drying , 1984 .

[7]  L. Greenspan.  Humidity Fixed Points of Binary Saturated Aqueous Solutions , 1977, Journal of Research of the National Bureau of Standards. Section A, Physics and Chemistry.

[8]  Kenneth C. Hover,et al.  Influence of microcracking on the mass transport properties of concrete , 1992 .

[9]  J. Weiss,et al.  Numerical and Experimental Assessment of Unsaturated Fluid Transport in Saw-Cut (Notched) Concrete Elements , 2009, SP-266: Modeling As a Solution to Concrete Problems CD.

[10]  S. Kelham,et al.  A WATER ABSORPTION TEST FOR CONCRETE , 1988 .

[11]  Dale P. Bentz,et al.  Influence of Shrinkage-Reducing Admixtures on Moisture Absorption in Cementitious Materials at Early Ages , 2010 .

[12]  S. Chatterji.  Drying shrinkage of cement paste and concrete: A reappraisal of the measurement technique and its significance , 1976 .

[13]  R. Spragg,et al.  Portland Cement Concrete Pavement Permeability Performance , 2010 .

[14]  Irving Kett.  Air Content of Freshly Mixed Concrete by the Pressure Method (C 231) , 2009 .

[15]  Z. P. Bažant,et al.  Nonlinear water diffusion in nonsaturated concrete , 1972 .

[16]  C. MacInnis,et al.  The Effects of a Deicing Agent on the Absorption and Permeability of Various Concretes , 1980 .

[17]  Wilfrid A. Nixon,et al.  Damaging effects of deicing chemicals on concrete materials , 2006 .

[18]  Bernard Y. Tao,et al.  Can Soy Methyl Esters Reduce Fluid Transport and Improve Durability of Concrete? , 2009 .

[19]  L. Fay,et al.  Freeze–thaw damage and chemical change of a portland cement concrete in the presence of diluted deicers , 2010 .

[20]  Kenneth A. Snyder,et al.  Doubling the service life of concrete structures. II: Performance of nanoscale viscosity modifiers in mortars , 2010 .

[21]  Nicos Martys,et al.  Capillary transport in mortars and concrete , 1997 .

[22]  Kurt D Smith,et al.  The Deleterious Chemical Effects of Concentrated Deicing Solutions onPortland Cement Concrete , 2008 .

[23]  R. Stokes,et al.  Density, viscosity, conductance, and transference number of concentrated aqueous magnesium chloride at 25°C , 1980, Journal of Solution Chemistry.

[24]  W. D. Hoff,et al.  Water Transport in Brick, Stone and Concrete , 2002 .

[25]  Thomas J. Van Dam,et al.  Hardened Concrete Air Void Analysis with a Flatbed Scanner , 2001 .

[26]  Kenneth A. Snyder,et al.  VERDiCT: Viscosity Enhancers Reducing Diffusion in Concrete Technology , 2009 .

[27]  Luciano Picarelli,et al.  Final Report 2008 , 2008 .

[28]  W. Jason Weiss,et al.  Water Transport in Concrete Damaged by Tensile Loading and Freeze–Thaw Cycling , 2006 .

[29]  Zdeněk P. Bažant,et al.  Drying of concrete as a nonlinear diffusion problem , 1971 .