Matrix swelling rate and cavity volume balance of UO2 fuels at high burn-up

Abstract The low temperature matrix swelling of UO 2 fuels was analysed as a function of burn-up, taking into account changes in the fuel density, porosity and retained Xe concentration as measured by EPMA. The evaluation of these data combined with an analytical solution to a rate-theory model for gas-driven swelling leads to the conclusion that at average pellet burn-ups ⩽ 60 GWd/t M the total matrix swelling rate is gradually reduced from ≈1% per 10 GWd/t M to ≈0.3% per 10 GWd/t M; the latter value being reached at an average burn-up above 110 GWd/t M. The decrease in the swelling rate is due to the progressive depletion of fission gas in the fuel matrix by thermal and athermal processes, such that at very high burn-up the matrix swelling becomes dominated by the precipitation of solid fission products. Owing to volume conservation, the volume occupied by the depleted gas is replaced by porosity.

[1]  C. Ronchi,et al.  Extrapolated equation of state for rare gases at high temperatures and densities , 1981 .

[2]  Kazuhiro Nogita,et al.  Radiation-induced microstructural change in high burnup UO2 fuel pellets , 1994 .

[3]  K. Une,et al.  Irradiation-induced recrystallization in high burnup UO2 fuel , 1995 .

[4]  M. Wood,et al.  On the in-pile nucleation and growth of grain-boundary bubbles , 1983 .

[5]  M. Speight.  Letter to the editors — lettres aux redacteursA calculation on the size distribution of intragranular bubbles in irradiated UO2 , 1971 .

[6]  J. A. Turnbull,et al.  The distribution of intragranular fission gas bubbles in UO2 during irradiation , 1971 .

[7]  J. Spino,et al.  Lattice Parameter Changes Associated with the Rim-Structure Formation in High Burn-up UO2-Fuels by Micro X-Ray Diffraction. , 2000 .

[8]  M. V. Speight,et al.  A Calculation on the Migration of Fission Gas in Material Exhibiting Precipitation and Re-solution of Gas Atoms Under Irradiation , 1969 .

[9]  Donald R. Olander,et al.  Fundamental Aspects of Nuclear Reactor Fuel Elements , 1976 .

[10]  David G. Franklin,et al.  Low temperature swelling and densification properties of LWR fuels , 1984 .

[11]  S. Nasu,et al.  Irradiation induced volume change in UN2 , 1978 .

[12]  H. Matzke.  Xenon migration and trapping in doped ThO2 , 1967 .

[13]  M. Mogensen,et al.  An experimental study of the distribution of retained xenon in transient-tested UO2 fuel , 1993 .

[14]  Determination of xenon concentrations in nuclear fuels by electron microprobe analysis , 1980 .

[15]  R. Manzel,et al.  EPMA and SEM of fuel samples from PWR rods with an average burn-up of around 100 MWd/kgHM , 2002 .

[16]  J. Rest,et al.  The effect of irradiation-induced gas-atom re-solution on grain-boundary bubble growth , 2003 .

[17]  M. Coquerelle,et al.  Detailed characterisation of the rim microstructure in PWR fuels in the burn-up range 40–67 GWd/tM , 1996 .

[18]  H. Zimmermann.  Investigations on swelling and fission gas behaviour in uranium dioxide , 1978 .

[19]  J. Rest.  Validation of mechanistic models for gas precipitation in solids during postirradiation annealing experiments , 1989 .

[20]  H. Matzke,et al.  Gas release mechanisms in UO2—a critical review , 1980 .

[21]  C. Walker.  Measurement of retained xenon in advanced fuels by microprobe analysis , 1979 .

[22]  R. Manzel,et al.  The matrix swelling rate of UO2 , 1977 .

[23]  C. Ronchi,et al.  Effect of burn-up on the thermal conductivity of uranium dioxide up to 100.000 MWd t−1 , 2004 .

[24]  J. Glatz,et al.  Comments on the threshold porosity for fission gas release in high burn-up fuels , 2004 .

[25]  Clive T. Walker,et al.  Assessment of the radial extent and completion of recrystallisation in high burn-up UO2 nuclear fuel by EPMA , 1999 .

[26]  A. W. Cronenberg,et al.  Modeling the behavior of Xe, I, Cs, Te, Ba, and Sr in solid and liquefied fuel during severe accidents☆ , 1987 .